WenmarOpen by Wenmar Pro

Service bulletins for the 2023 Ford F-650

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

94 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

Only bulletins with component: Electrical system are shown. Show all

Bulletins, newest first
SSM 549762026-07-07. Service bulletin. POWER TRAIN; ELECTRICAL SYSTEM. Some 2023-2026 F-53 Motorhome Chassis/F-59 Commercial Stripped Chassis and 2024-2026 F-650/F-750/E-Series vehicles equipped with a 6R140 transmission may be limited to 5th gear and reverse gear only. Additionally, the driver will be able to shift back to park. Diagnostic trouble codes (DTC) P2701, P2704, P0757, and/or P0733 may be stored in the powertrain control module (PCM). This may be due to PCM software being unable to command the transmission solenoid clutch actuators when the battery has a low state of charge (SOC) and/or the vehicle has been jump started. To restore proper transmission functionality, charge the battery as stated in the Workshop Manual (WSM), Section 414-01 Charging System > General Information. Cycle the ignition on then off and leave the vehicle off for 5 minutes to confirm the condition is no longer present. To prevent this issue from reoccurring, refer to the Owner's Manual > Storing Your Vehicle > Preparing Your Vehicle for Storage > 12V Battery. Replacement of transmission components will not resolve this condition. Inform the customer that the condition has no impact on tr
TSB 25-23482025-07-30. Service bulletin. POWER TRAIN; ELECTRICAL SYSTEM. Some of the vehicles listed in the Model statement above may exhibit an incorrectly illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTC) P0128, P0420, and/or P0430 stored in the powertrain control module (PCM). This may be due to the software in the PCM.
TSB 25-23222025-07-24. Service bulletin. POWER TRAIN; ELECTRICAL SYSTEM. This article supersedes TSB 25-2200 to update the parts list to add the new camshaft and tappet service kit and add F-650/F-750. Some of the vehicles listed in the Model statement above may exhibit an upper engine ticking or tapping noise at idle. Customers may also report experiencing rough engine performance, engine misfire, or a malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P0301-P0308 in the powertrain control module (PCM). This may be due to camshaft and/or valve tappet having excess wear within the engine assembly.
TSB 24-22102024-07-18. Service bulletin. ELECTRICAL SYSTEM. This article supersedes TSB 23-2426 to update the list of modules needing a software update in the Service Procedure. Some 2023 F-Super Duty chassis cab vehicles equipped with a 6.7L engine may exhibit an engine coolant temperature gauge falsely reading at the high end of the normal range while towing in high ambient temperatures with no diagnostic trouble codes (DTC) stored in the powertrain control module (PCM) or warning messages present in the instrument panel cluster (IPC). This may be due to the software in the IPC. To correct the condition, follow the Service Procedure to reprogram the IPC. Note: Some vehicles built on or before 28-Feb-2023 may have TSB 23-2426 performed previously, but no IPC software update was available at that time. NOTE: The IPC software update that addresses the symptom listed in this bulletin may have been sent via Ford Power-Up software updates delivered over-the-air (OTA) to connected vehicles that have automatic updates enabled through the center display screen. Enter the vehicle identification number (VIN) in Professional Technician System (PTS) and check the "OTA Dashboard" under the "Connected Vehicle" tab for OTA update history. If an update to the IPC has successfully completed recently and the customer is reporting thesymptoms are no longer present, this article may not apply.
TSB 24-20662024-04-03. Service bulletin. ELECTRICAL SYSTEM; POWER TRAIN; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); ELECTRICAL SYSTEM:SOFTWARE. This TSB supersedes article 24-2036 to update the vehicles affected. Some 2023-2024 F-Super Duty pickup vehicles built on or before 02-Jan-2024 equipped with a 6.7L engine may exhibit an illuminated MIL with diagnostic trouble codes (DTC) P0133, P0139, and/or P0145 stored in the powertrain control module (PCM). This may be due to the software in the PCM and does not affect vehicle operation.
SSM 523452024-03-20. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. Some 2022-2024 various Ford/Lincoln vehicles equipped with SYNC 4 may experience concern where customers are receiving an error message when trying to enroll in connected services. This may be due to the gateway module (GWM) software. To correct the concern, download and run the Transport and Factory Mode Deactivation app: under HS1 modules select BCM > Transport and Factory Mode > Download > Run. When the pop-up message appears for Change Vehicle Mode - Transport/Factory/Normal Mode, press OK. This will proceed to the Transport and Factory Mode Deactivation screen, select Unlock Vehicle Connectivity Settings (21 MY + Vehicles). A pop-up message appears noting Vehicle Is Now In Normal Mode, select OK. This will return to the Transport and Factory Mode Deactivation screen, select Exit. A final pop-up notification stating that the application is finished, select OK. For claiming, use causal part 14G490 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
SSM 523332024-03-20. Service bulletin. ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM. Many body control module C (BCMC) warranty return parts are coming back with no trouble found. To verify that the BCMC is at fault prior to replacing, perform the following. First, disconnect the battery then check all BCMC connectors for terminal pushout, pin damage, spread terminals, and corrosion. Refer to Workshop Manual Section 100-00 Wire Terminal Inspection and Replacement. If none found, reconnect the BCMC and battery terminals then recheck functionality. If concern still exists, proceed with BCMC replacement.
SSM 523172024-03-20. Service bulletin. ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER; UNKNOWN OR OTHER. 2023 F-Super Duty, 2023-2024 Expedition, 2024 Nautilus/F-150 vehicles will exhibit no light emitting diode (LED) confirmation from the key fob indicating that the vehicle has remote started (or not remote started). Factory key fobs with remote start no longer contain a LED feedback indicator. Do not replace the key fob for this condition. This is a normal operating characteristic and no service action is necessary.
SSM 522992024-03-05. Service bulletin. ELECTRICAL SYSTEM; POWER TRAIN; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM). Some 2023-2024 F-Super Duty vehicles equipped with a 6.7L engine may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTC) U02A2, P206B, P203B, P208A, P20FA, P20FD, and/or P20FC stored in the powertrain control module (PCM). Before performing normal diagnostics, inspect connectors C1273C (32 pin) and C406 (14 pin) for proper connection. Also disconnect and inspect C1415 (32 pin), C406 (14 pin), C4863 (7 pin) and C4864 (5 pin) on the 14405 vehicle harness for signs of terminal push out, water intrusion and/or corrosion. Refer to the Wiring Diagram for connector locations. Repair as necessary. Refer to Wiring Diagram Cell 005 for repair procedures.
22N152024-02-01. Service bulletin. ELECTRICAL SYSTEM:BODY CONTROL MODULE:SOFTWARE; UNKNOWN OR OTHER. Certain 2020-2023 Model Year Bronco Sport, Escape, Corsair, E-Series, F-650/F-750, F-53 Motorhome Chassis, F-59 Commercial Stripped Chassis Vehicles Equipped with Smart Data Link Connector (SDLC) Gateway Module Reprogramming for Inspection and Maintenance (I/M) Testing Addinf owner letters. First part submitted 01/02/24
SSM 522132024-01-30. Service bulletin. UNKNOWN OR OTHER; ELECTRICAL SYSTEM:BODY CONTROL MODULE:SOFTWARE. Some 2022-2023 F-150 and 2023 F-Super Duty vehicles equipped with a direct current/alternating current converter module A (DCACA) inverter (minor feature code HUKAK) may exhibit a Please Contact Authorized Dealer For Service message in the center display screen with DTC P0A93:96 stored in the DCACA. This may be due to the software level of the DCACA and has no effect on vehicle operation. To confirm a vehicle is built with a certain minor feature code, review the build information by double-clicking the vehicle identification number (VIN) in the upper left corner in the Professional Technician System (PTS). To correct this condition, reprogram the DCACA to the latest software level using the latest version of the Ford Diagnosis and Repair System (FDRS) scan tool. For claiming, use causal part 19G317 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
23H072023-12-05. Service bulletin. ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM. Certain 2021-2023 Model Year F150, 2022 Model Year F53/F59 Stripped Chassis, 2022-2023 Model Year F650/F750, 2023 Model Year Ranger, 2024 Model Year Econoline - Body Control Module (BCM) Replacement
SSM 520992023-12-01. Service bulletin. ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL. Some 2023 F-Super Duty chassis cab vehicles equipped with a 6.7L engine may exhibit an engine coolant temperature gauge reading at the high end of the normal range while towing in high ambient temperatures with no diagnostic trouble codes (DTC) or warning messages present in the instrument panel cluster (IPC). This may be due to the software in the IPC. To correct the condition, reprogram the IPC using the latest software level of the Ford Diagnosis and Repair System (FDRS) diagnostic scan tool. For claiming, use causal part 10849 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
SSM 517912023-07-18. Service bulletin. ELECTRICAL SYSTEM; ENGINE AND ENGINE COOLING. Some 2023 F-Super Duty vehicles equipped with a 6.7L engine may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTC) U029D, U029E, U02A1, U02A3, P2209, P24D0, P22A7, and/or P23B5. This may be due to a wiring chafe on harness 14406 near connector C146 touching the exhaust gas recirculation (EGR) cooler on the right side of the engine. Before performing normal diagnostics, inspect 20 amp fuse F18 (position 26). If fuse F18 is found open, inspect the 14406 harness for contact with the EGR cooler and repair as necessary. Refer to Wiring Diagram, Cell 005 for repair procedures. If no damage is found, refer to Workshop Manual, Section 303-08A for normal diagnostics.
SSM 517502023-06-30. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM; ENGINE AND ENGINE COOLING; ELECTRICAL SYSTEM. Some 2023 F-Super Duty vehicles equipped with a 6.7L engine, and built on or before 02-May-2023, may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTC) U029D, U029E, U02A1, U02A3, P2209, P24D0, P22A7, and/or P23B5. This may be due to a wiring chafe on harness 14406 near connector C146 touching the exhaust gas recirculation (EGR) cooler on the right side of the engine. Before performing normal diagnostics, inspect 20 amp fuse F18 (position 26). If fuse F18 is found open, inspect the 14406 harness for contact with the EGR cooler and repair as necessary. Refer to Wiring Diagram, Cell 005 for repair procedures. If no damage is found, refer to Workshop Manual, Section 303-08A for normal diagnostics.
SSM 517482023-06-30. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT; ELECTRICAL SYSTEM:WIRING. Some 2023 F-Super Duty vehicles equipped with a wireless charging pad may exhibit an excessive buzzing noise from the WACM cooling fan. This may be due to the wiring harness or electrical tape contacting the cooling fan. Remove the WACM and inspect for contact between the wiring harness and the WACM cooling fan. Refer to Workshop Manual, Section 414-06. If contact is found, reroute the wiring harness away from the WACM cooling fan to eliminate the noise. Use the Report a Vehicle Concern link at the bottom of OASIS to submit a report with photos attached (if possible) if contact is found between the wiring harness and the fan.
SSM 517382023-06-30. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. Some 2023 F-Super Duty vehicles may set diagnostic trouble code (DTC) U211B:87 in various modules when a diagnostic self-test is performed, which includes: powertrain control module (PCM), advanced driver assistance system (ADAS), anti-lock brake system (ABS), power steering control module (PSCM), body control module (BCM), telematics control unit (TCU), driver door module (DDM), and/or passengers door module (PDM). This may be due to the modules DTC sensitivity during vehicle key-on/start-up. Replacement or reprogramming of these module(s) may not resolve this condition. U211B:87 should be ignored if: no other DTCs are present, no warning indicators are illuminated while the engine is running and no noticeable symptoms are present. No further service action is required.
SSM 516932023-06-13. Service bulletin. ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL. Some 2023 F-Super Duty vehicles do not have a compass displayed in the instrument panel cluster (IPC). Replacement or reprogramming the IPC will not enable the feature. Inform customers that Ford is planning to deploy an enhancement via Ford Power-Up software updates delivered over-the-air (OTA) in 4Q2023. Software will update automatically on vehicles with connected vehicle features enabled. Monitor OASIS for additional information. Schedule a service appointment in late 4Q2023, for customers without connected vehicle features enabled once the enhancement becomes available.
SSM 516792023-06-08. Service bulletin. ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL. Some 2023 F-Super Duty vehicles do not have a compass displayed in the instrument panel cluster (IPC). Replacement or reprogramming the IPC will not enable the feature. Inform customers that Ford is planning to deploy an enhancement via Ford Power-Up software updates delivered over-the-air (OTA) in 4Q2023. Software will update automatically on vehicles connected to FordPass. Monitor OASIS for additional information. Schedule a service appointment in late 4Q2023, for customers that are not connected to FordPass once the enhancement becomes available.
SSM 516752023-06-08. Service bulletin. ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM. Some 2023 F-Super Duty vehicles equipped with SYNC 4 may experience programming errors after a replacement of the body control module (BCM) for various concerns. After programmable module installation (PMI) of the new BCM, diagnostic trouble codes (DTC) U2100:00, U2101:00 and/or U211B:87 may be present. Download and run the Ford Diagnosis and Repair System (FDRS) application titled Trusted Real-Time Operation Network (TRON) Module Authentication, and perform the TRON Diagnosis and Repair and Reset ECU on CAN BUS routines. Once both TRON routines have been completed, re-run the BCM PMI application. Verify that all BCM DTCs have cleared. Service procedures are being updated to improve this process. Monitor OASIS for updates.
SSM 516642023-05-31. Service bulletin. ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM. Some 2023 F-Super Duty vehicles equipped with SYNC 4 may require a replacement of the body control module (BCM) for various concerns. After programmable module installation (PMI) of the new BCM, diagnostic trouble codes (DTC) U2100:00, U2101:00 and/or U211B:87 may be present. Download and run the Ford Diagnosis and Repair System (FDRS) application titled Trusted Real-Time Operation Network (TRON) Module Authentication, and perform the TRON Diagnosis and Repair and Reset ECU on CAN BUS routines. Once both TRON routines have been completed, re-run the BCM PMI application. Verify that all BCM DTCs have cleared. Service procedures are being updated to improve this process. Monitor OASIS for updates.
SSM 516012023-05-24. Service bulletin. ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL; TRAILER HITCHES. Some 2021-2023 F-150 and 2022-2023 F-Super Duty/Expedition/Navigator/Maverick vehicles equipped with an integrated trailer module (iTRM) may exhibit a trailer lamp fault message with various related diagnostic trouble codes (DTC). Most trailer emulator testers will not draw enough current to correctly diagnose these concerns. They may be used to diagnose basic functionality of the iTRM, however, some trailer emulator testers may cause false trailer lamp fault messages to appear. The customer's trailer should be used for diagnosis instead of a trailer emulator tester. Refer to Workshop Manual (WSM), Section 417-01 for normal diagnostics.
SSM 516262023-05-16. Service bulletin. ELECTRICAL SYSTEM. Some 2023 F-Super Duty vehicles built on or before 28-Mar-2023 and equipped with a 12.3 inch IPC display may experience a blank IPC screen. This may be due to a faulted graphics interface processor (GIP) in the IPC Module. If a vehicle exhibits this condition, use the Ford Diagnostic and Repair System (FDRS) to determine if the GIP is communicating. To confirm GIP communication, start a session with the vehicle using FDRS. From the Vehicle Info tab, select IPC. Under Module Details, if device identification (DID) F120 indicates Null, the GIP is faulted, and the IPC module (base part number: 10849) requires replacement. Do not replace the IPC display for this condition. For claiming, use causal part 10849 and M-time.
SSM 515932023-05-16. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT:ELECTRICAL:INFOTAINMENT. Some 2023 F-Super Duty vehicles may exhibit the IPC reverting back to the home screen after the vehicle is shut off and restarted. The last screen viewed by the customer may not be remembered after the ignition is cycled. This is an operating characteristic of the vehicle and no repairs should be performed at this time. Use the Report a Vehicle Concern link at the bottom of OASIS to submit a report if there is a customer concern of IPC operation.
SSM 515792023-05-04. Service bulletin. VISIBILITY:POWER WINDOW DEVICES AND CONTROLS; ELECTRICAL SYSTEM. Some 2023 F-Super Duty vehicles may exhibit static in the audio system when operating various electrical components such as power windows/roof opening panel. This may be due to the body side ground cable fastener G119 being loose. Inspect the body side ground cable fastener G119 for proper tightness of 6 lb-ft (8 Nm). If the body side ground cable fastener G119 is tightened properly to 6 lb-ft (8 Nm) and the concern persists, refer to Workshop Manual (WSM), Section 415-00 for normal diagnostics.

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.