WenmarOpen by Wenmar Pro

Service bulletins for the 2016 Ford Transit

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

233 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

By topic

Bulletins, newest first
SSM 468902017-12-14. Service bulletin. FUEL SYSTEM, DIESEL; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM). Some 2017 F-Super Duty/2016-2017 F650-750 equipped with 6.7L diesel engines and 2015-2017 Transit equipped with 3.2L diesel engines may exhibit a MIL on with diagnostic trouble code (DTC) P206C stored in powertrain control module(PCM). This may be due to incorrect diesel exhaust fluid (DEF) concentration. Prior to performing Powertrain Control and Emissions Diagnosis (PC/ED) pinpoint test RJ, ensure DEF concentration is checked using Central Tools Refractometer tool number CEN3R201 and if DEF contamination is suspected use the Rotunda Hydrocarbon Test Kit tool number 328-480508.
SSM 468892017-12-14. Service bulletin. ENGINE. Some 2015-2018 Transit vehicles may have unique accessory drive noise characteristics. Engineering review of warranty returned belt tensioners has not identified an out of specification part, nor have abnormal sounds been recreated during on-vehicle evaluations with warranty returned tensioners. Before attempting a repair for an accessory drive system noise, compare the sound to a like Transit vehicle in similar RPM and temperature conditions. If the sound is not characteristic, use chassis ears to help isolate the source of the noise. If tensioner replacement is deemed necessary, use the Report a Vehicle Concern link at the bottom of the vehicle's OASIS screen and submit a detailed Global Concern Report highlighting the specific conditions when the noise was observed.
SSM 468612017-12-14. Service bulletin. EQUIPMENT:ELECTRICAL. Some 2016-2017 Ford and Lincoln vehicles with SYNC 3 may intermittently display an overhead image of a vehicle in the center of the SYNC touchscreen with no obstacle detection grids or warning chimes. SYNC may appear unresponsive when the overhead vehicle image is displayed. The vehicle image may intermittently display after shifting out of reverse or turning the vehicle off when in reverse. To recover the screen, perform any one of the following actions: touch the SYNC screen anywhere outside the vehicle image pop-up box, safely shift the vehicle into and out of reverse, or perform a complete ignition cycle (key off, open and close the driver's door then wait 5 minutes). If this does not resolve the concern, do not attempt any repairs at this time. Engineering is investigating, monitor OASIS for updates.
SSM 468602017-12-14. Service bulletin. EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM). Some 2016-2018 Ford or Lincoln vehicles equipped with SYNC 3 may exhibit a blank screen or other various SYNC symptoms only when the vehicle is in transport mode. This is due to the power saving features enabled while in transport mode and is beneficial for battery life to keep the vehicle in transport mode until the vehicle is prepped for sale. To prevent a SYNC system lockup during transport mode deactivation, follow the Workshop Manual (WSM) procedure allowing time for the SYNC system to complete all tasks such as fully booting up or powering down and shutting off before moving to the next step of the procedure. If the vehicle exhibits a blank screen or SYNC symptoms after transport mode deactivation, refer to WSM, Section 415-00 for normal diagnosis. The SYNC version can be confirmed via OASIS.
SSM 468482017-10-21. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. Some owners of 2016-2017 Ford and Lincoln vehicles equipped with SYNC 3 may experience inoperative mobile device navigation applications. Mobile device navigation via AppLink requires SYNC 3 version 2.3 or higher for Apple iOS users. Mobile device navigation via AppLink is not currently available for Android users. SYNC 3 software upgrades to support these apps are not currently available, do not attempt any repairs at this time. Engineering is investigating, monitor OASIS for updates. SYNC 3 software upgrade to support these apps is not a warrantable repair per the Warranty And Policy Manual, Section 3, Warranty Coverages SYNC.
SSM 468342017-10-21. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. Some 2016-2017 Ford and Lincoln vehicles with SYNC 3 may exhibit an intermittent blue or black screen. Check for SYNC software update under the OASIS Tab SYNC selection. If update is available refer to WSM, Section 415-00 and update APIM software. After Installation Complete pop-up appears, remove USB flash drive and install into IDS tool to update Ford database. Perform a complete ignition cycle by turning the key off for 5 minutes which is critical for a successful installation. If no updates are available or a blue or black screen is present after an update refer to WSM, Section 415-00 for diagnosis or SYNC 3 intermittent blank screen GSB for tips. For claiming, use causal part 14G371 and applicable labor operations in section 10 of the SLTS manual.
SSM 468242017-10-21. Service bulletin. ELECTRICAL SYSTEM; ENGINE. Some 2013-2017 F-Super Duty/2015-2017 Transit/2016-2017 F650-750 vehicles equipped with a diesel engine may exhibit DTC P207F and/or P20EE (Reductant Quality Performance) in the powertrain control module (PCM). When repairing DTC P207F or P20EE, refer to the online version of the powertrain control/emission diagnostic (PC/ED) manual for the latest diagnostics. The pinpoint test RD and diagnostic trouble code chart have been updated in section 4 and 5 for DTC P207F and P20EE.
SSM 468232017-10-21. Service bulletin. EQUIPMENT. 2015-2018 Transit vehicles equipped with dual rear wheels (DRWs) have a high mount rear marker lamp that does not illuminate with the stop lamps. This lamp assembly may appear to be a stop lamp but is intended to illuminate with the parking lamps only. This information is available in Workshop Manual Section 417-01.
SSM 468132017-10-21. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. Some 2016-2017 Ford and Lincoln vehicles equipped with SYNC 3 version 2.2 software may exhibit a blank screen after attempting to exit Valet mode. To recover the screen, perform a complete ignition cycle (key off, open and close the driver's door then wait 5 minutes). The SYNC software version of the vehicle can be confirmed via OASIS. Do not attempt any repairs at this time. Engineering is investigating; Monitor OASIS for updates.
SSM 468072017-10-21. Service bulletin. ELECTRICAL SYSTEM. Some 2015-2018 Transits may exhibit a lack of airflow from the front climate control system cabin vents in fresh air mode. This concern can be due to improper installation of the hood vent air duct plug. The correct location for the plug is on the left side hood opening per the Workshop Manual (WSM), Section 501-02.
SSM 467162017-08-25. Service bulletin. SEATS. Some 2015-2017 Transit vehicles may exhibit front seat safety belts that do not extend or retract properly or may exhibit an abnormal noise. Verify if the vehicle has been modified, in particular if a bulkhead partition between the front seats and cargo area has been added to the vehicle. Fasteners or holes in the lower b-pillar are indicators that the seat belt retractor mechanism could have been compromised. If diagnostics lead to retractor replacement, inspect for drill or screw holes in the retractor housing. Damage to the seat belt retractor caused by a vehicle modifier is not warrantable.
SSM 467062017-08-25. Service bulletin. ENGINE. Some 2013-2016 F-Super Duty/2015-2017 Transit/2016-2017 F650-750 vehicles equipped with a diesel engine may exhibit DTC P207F and/or P20EE (Reductant Quality Performance) in the powertrain control module (PCM). When repairing DTC P207F or P20EE, refer to the online version of the powertrain control/emission diagnostic (PC/ED) manual for the latest diagnostics. The pinpoint test RD and diagnostic trouble code chart have been updated in section 4 and 5 for DTC P207F.
16B322017-08-01. Service bulletin. VEHICLE SPEED CONTROL. Certain 2015 Model Year Edge, 2015-2016 Model Year F-150, MKT, and Police Interceptor Sedan, and 2016 Model Year Escape, Explorer, Flex, Fusion, MKX, Mustang, Police Interceptor Utility, Taurus, and Transit Vehicles - Electronic Throttle Body Repair
SSM 461022017-08-01. Service bulletin. SEAT BELTS:FRONT:RETRACTOR; SEAT BELTS. Some vehicles may have a concern where the safety belt retractor webbing does not extract from the stowed position or exhibits excessive pressure on the occupant during use. This may be due to a normal condition which happens when the seatbelt retracts at a high rate of speed. The Workshop Manual, Section 501-20A General Procedures has been updated with a locked seatbelt retractor releasing procedure.
SSM 460932017-08-01. Service bulletin. FUEL SYSTEM, GASOLINE; FUEL SYSTEM, GASOLINE:STORAGE. Diesel customers may inquire about a Distance to Empty (DTE) warning message for the DEF system. It may be necessary to add up to 2.5 gallons of DEF for the system to detect a refill event and clear the DTE warning messages, however it is recommended to fill the tank to capacity, which may take up to 5 gallons. Driving conditions that increase fuel consumption will increase DEF consumption and will require additional fills between oil change intervals. If the DTE message is displayed and no Diagnostic Trouble Codes (DTCs) are present, read the Reduct_TNK_LV PID with the Integrated Diagnostic System (IDS). If it reads less than 100%, DEF must be added. If the message doesnt clear after the PID reads 100%, run the IDS SCR System Refill Activation routine.
SSM 460852017-08-01. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE); ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER; ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS; ENGINE AND ENGINE COOLING; ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY; ENGINE; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV); ENGINE AND ENGINE COOLING:COOLING SYSTEM; ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER; ENGINE AND ENGINE COOLING:ENGINE:DIESEL; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM; ENGINE AND ENGINE COOLING:ENGINE:GASOLINE; ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS; ENGINE AND ENGINE COOLING:ENGINE; ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN. The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
SSM 460732017-08-01. Service bulletin. EQUIPMENT:ELECTRICAL; ELECTRICAL SYSTEM. Some 2016-2017 Escape, MKC, Fiesta, F150, Expedition, Navigator, Mustang, Transit, Focus, C-Max, MKX, Taurus, MKS, Flex, MKT, and Edge and 2017 Explorer, Fusion, MKZ, Super Duty, Transit Connect and Continental vehicles equipped with SYNC 3 might exhibit a blank screen or other various SYNC symptoms only when the vehicle is in Transport mode. Engineering is aware of this possibility and it is considered normal due to the power saving features enabled while in transportation mode. It is beneficial to extended battery life to keep the vehicle in Transport Mode until the vehicle is prepped for sale. If the vehicle should exhibit a blank screen or other SYNC symptoms after it has been taken out of Transport mode, refer to Workshop Manual, Section 415-00 for normal diagnosis. The SYNC version can be confirmed via OASIS.
SSM 460662017-08-01. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); ELECTRICAL SYSTEM. Some 2013-2017 F-Super Duty, 2015-2017 Transit and 2016-2017 F650-F750 vehicles equipped with a diesel engine may exhibit diagnostic trouble code (DTC) P2201 (NOX Sensor Circuit Range/Performance Bank 1 Sensor 1) in the powertrain control module (PCM). When repairing DTC P2201, refer to the online version of the powertrain control/emission diagnostic (PC/ED) manual for the latest diagnostics. The pinpoint test RD and diagnostic trouble code chart have been updated in section 4 and 5 for DTC P2201.
SSM 460592017-08-01. Service bulletin. WHEELS:HUB. Some 2016-2017 Transit full-size hubcaps may be damaged or cracked during pre-delivery installation or a repair procedure due to misalignment of the hubcap. To avoid damage, align the valve stem opening in the hubcap with the valve stem, confirming the lug nut tubes on the back of the hubcap are aligned with the lug nuts. Using a mallet gently tap the hubcap around the outer diameter; avoid hitting the center of the hubcap during installation. Please bring this message to the attention of the per-delivery technicians.
SSM 460482017-08-01. Service bulletin. ENGINE AND ENGINE COOLING; ELECTRICAL SYSTEM. Some 2016-2017 Ford and Lincoln vehicles equipped with SYNC 3 may have DTCs U3000:04, B108E:12 and/or U1A00:87 present in the APIM. If these DTCs are present and no other symptoms are reported by the customer, then clear the DTCs and retest. If the DTC(s) do not return then no further repairs should be attempted. If one or more DTCs return as current faults and/or the customer reports other symptoms, then refer to Workshop Manual, Section 415-00 for further diagnostics. The SYNC version can be confirmed via OASIS.
SSM 464612017-05-22. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. SOME 2016 TRANSIT EQUIPPED WITH SYNC 3 MAY REQUIRE ACCESSORY PROTOCOL INTERFACE MODULE (APIM) REPLACEMENT FOR VARIOUS REASONS. TO PREVENT A SOFTWARE CONFLICT BETWEEN THE APIM AND THE AUDIO CONTROL MODULE (ACM) CAUSING INOPERATIVE RADIO PRESETS, ALSO INSTALL ACM PART NUMBER CK4Z-18C869-H. MONITOR OASIS FOR FUTURE UPDATES, ENGINEERING IS DEVELOPING A SOFTWARE SOLUTION TO ELIMINATE THE NEED FOR ACM REPLACEMENT. FOR CLAIMING, USE CAUSAL PART 14G371 AND APPLICABLE LABOR OPERATIONS IN SECTION 10 OF THE SERVICE LABOR TIME STANDARDS (SLTS) MANUAL.
SSM 464232017-05-15. Service bulletin. EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL. 2015-2017 TRANSIT VEHICLES EQUIPPED WITH DUAL REAR WHEELS (DRWS) HAVE A HIGH MOUNT REAR MARKER LAMP THAT DOES NOT ILLUMINATE WITH THE STOP LAMPS. THIS LAMP ASSEMBLY MAY APPEAR TO BE A STOP LAMP BUT IS INTENDED TO ILLUMINATE WITH THE PARKING LAMPS ONLY. THIS INFORMATION IS AVAILABLE IN WORKSHOP MANUAL SECTION 417-01.
SSM 462192017-03-20. Service bulletin. EQUIPMENT. SOME 2015-2017 LOW ROOF TRANSIT VEHICLES BUILT ON OR BEFORE 30-SEP-2016 AND UPFITTED WITH A ROOF RACK MAY EXHIBIT INTERIOR ROOF BOW BRACKET TO SIDE PANEL SEPARATION. DURING REPAIR, IN ADDITION TO RENEWING THE ORIGINAL SPOT WELDS WITH METAL INERT GAS (MIG) PLUG WELDS, MIG SKIP WELD THE ENTIRE PERIMETER OF THE HORIZONTAL BRACKET TABS TO THE SIDE PANEL. MIG SKIP WELDING IS REQUIRED TO AVOID EXCESSIVE HEAT DURING THE WELDING PROCESS. AFTER FINISHING OPERATIONS AND PAINTING, RESTORE CORROSION PROTECTION FOLLOWING THE APPLICABLE WORKSHOP MANUAL (WSM) GUIDELINES IN SECTION 501-25. THE ROOF RACK SHOULD BE MOUNTED ACCORDING TO TRANSIT ROOF RACK MOUNTING GUIDELINES FOUND IN QUALITY VEHICLE MODIFIER BULLETIN (QVMB) Q-249 PUBLISHED 1-AUG-16. REFER TO WWW.FLEET.FORD.COM/TRUCKBBAS/TOPICS/QVMP.HTML.
SSM 462102017-03-20. Service bulletin. STEERING. SOME 2010-2016 EPAS EQUIPPED VEHICLES MAY EXHIBIT STEERING RELATED NOISES. THE WORKSHOP MANUAL (WSM) DIAGNOSTIC PROCEDURES HAVE BEEN UPDATED IN SECTION 211-02. WHEN DIAGNOSING AND REPAIRING EPAS STEERING NOISES USE THE UPDATED PROCEDURES.
SSM 464132017-03-20. Service bulletin. ENGINE. SOME 2015-2017 TRANSIT VEHICLES BUILT ON OR BEFORE 17-OCT-2016, EQUIPPED WITH A 3.2L ENGINE, AND WITH LOW TIME IN SERVICE (LESS THAN 8,000 KM (5,000 MILES)) MAY EXHIBIT AN OIL LEAK FROM AREAS SUCH AS THE CRANKSHAFT FRONT SEAL, CRANKSHAFT REAR SEAL, OR FUEL INJECTION PUMP DRIVE ACCESS COVER. THESE EARLY OIL LEAKS MAY BE CAUSED BY HIGH CRANKCASE PRESSURE DUE TO AN IMPROPERLY MOLDED OIL SEPARATOR IN THE VALVE COVER. IN ADDITION TO REPAIRING THE OIL LEAK, INSTALL A NEW VALVE COVER. FOR CLAIMING, USE CAUSAL PART 6K271 AND APPLICABLE LABOR OPERATIONS IN SECTION 06 OF THE SERVICE LABOR TIME STANDARDS (SLTS) MANUAL.

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.