WenmarOpen by Wenmar Pro

Service bulletins for the 2022 Ford F-150

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

594 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

Bulletins, newest first
SSM 514522023-04-05. Service bulletin. ELECTRICAL SYSTEM. Some 2021-2023 F-150, 2021-2023 F-Super Duty, 2021-2023 Ranger customers may have concerns including, but not limited to: no power to the distribution box, rear camera inoperative, rear park assist inoperative, box lights inoperative, power up/down tailgate inoperative, unable to open tailgate by tailgate switch, and no tailgate ajar message when the tailgate is ajar. These concerns may be caused by faulty connections between the pickup bed, tailgate, rear lamp assemblies, or bumper where connectors are disconnected, damaged, or coated with bedliner. Prior to performing any warranty diagnosis or repairs, verify if the vehicle had an aftermarket spray-in-bedliner. Any repairs resulting from aftermarket products/installation, including but not limited to a spray-in bedliner, are not covered under warranty.
SSM 514342023-04-04. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. Some 2021-2022 F-150 vehicles equipped with On-Board Scale may exhibit DTC U3000:54 stored in the VDM after replacement and will not clear. This may be due to the configuration data for the VDM. To correct the condition, download and run the VDM - Vehicle Dynamics Module Configuration app using the latest level of the Ford Diagnosis and Repair System (FDRS). After the VDM configuration has completed, download and run the VDM - On Board Scales Calibration app and perform the Vehicle Payload Update and the Height Sensor Calibration to complete the repair. The Vehicle Payload Update entry in FDRS should correspond with the rating shown on the Tire and Load Information label found on either the B-pillar or the edge of the driver door. For claiming, use causal part 18B008 and applicable labor operations in Section 10 of the Service Labor Time Standards Manual.
SSM 514332023-04-04. Service bulletin. ELECTRICAL SYSTEM; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM. Some 2022-2023 F-150 vehicles equipped with single exhaust may have various symptoms relating to parking brake, ABS, Traction Control, AdvanceTrac, Park Aid, and/or Locking Differential functionality. Vehicles may also exhibit one or more of the following DTCs in the ABS module: B1111, C1013, C1034, C2005, C2006, C2007, C2008. This condition may be the result of a wiring harness chafing on the left tube of the rear axle. Visually inspect the wiring harnesses in close proximity to the left axle tube, and if damage is found, repair the affected wiring harness following Wiring Diagram Cell 5.
SSM 514192023-04-04. Service bulletin. POWER TRAIN. Some 2017-2023 Ford and Lincoln vehicles equipped with a 10R60/10R80/10R80 MHT/10R100 transmission may exhibit a whine noise at idle and/or while driving. This may be identified as coming from the bellhousing and the front of the transmission fluid pan. The whine noise may become louder when the transmission is at operating temperature and may increase with engine revolutions per minute (RPM) in the park (P) position. A small amount of whine noise is considered to be characteristic of the 10R60/10R80/10R80 MHT/10R100 transmissions due to the offset gear drivetrain in the front support and has no effect on durability.
SSM 514112023-04-04. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL. Some 2021-2022 F-150 vehicles may not be able to communicate with some emissions testing equipment. Engineering is aware of the concern and is currently working on a solution expected in 2nd Quarter 2023. Monitor OASIS for updates. As a temporary corrective action, technicians may attempt one of the following: (a) Leave the engine running when performing the emissions test, even when the machine prompts to shut the engine off. (b) If a Ford Diagnosis and Repair System (FDRS) tool is available at the same location as the emissions testing equipment, use the FDRS tool to download and run the On-Demand DTC self-test on the audio front control module (ACM) and clear diagnostic trouble codes (DTCs) in the ACM, even if none are present. Then within the same key cycle, connect to the emissions test machine and perform the emissions test immediately.
SSM 514082023-04-04. Service bulletin. ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL. Some 2022-2023 F-150 Lightning vehicles may exhibit This Trip mileage not resetting after a key cycle. This may be due to the software in the instrument panel cluster (IPC). To correct the condition, reprogram the IPC to the latest software level using the Ford Diagnosis and Repair System (FDRS) diagnostic scan tool. For claiming, use causal part 10849 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
SSM 514072023-04-04. Service bulletin. BACK OVER PREVENTION:SOFTWARE. Some 2021-2022 Ford and Lincoln vehicles equipped with SYNC 4 may experience an error message during the gateway module (GWM) software update application which states Procedure Unsuccessful- GetConfigDataFromGIVIS. This may be the result of a server related concern. To correct the condition, download and run the Ford Diagnosis and Repair System (FDRS) application GWM-Read the Gateway Module A (GWM) Configuration Data application. When the application completes, refresh and re-attempt the GWM-Gateway Module A (GWM) Software Update application. For claiming, use causal part 14G229 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
SSM 514022023-04-04. Service bulletin. PARKING BRAKE. Some 2021-2022 F-150 vehicles equipped with light duty electric park brake calipers (minor feature code FAJAK) may exhibit a squeal noise from the rear brakes after sitting for 8 hours or more. To confirm a vehicle is built with minor feature code FAJAK, review the build information by double-clicking the vehicle identification number in the upper left-hand corner in the Professional Technician System (PTS). To correct this condition, replace rear brake disc (ML14-2A315-BC) and rear brake pads, caliper pin bolts, brake pad clips, and retraction springs (ML3Z-2200-E) on both sides of the vehicle. Refer to Workshop Manual Section 206-04 Rear Disc Brake. For claiming, use causal part number 2552 and applicable labor times from Section 02 of the Service Labor Times Standard Manual. NOTE: Using incorrect service parts on the braking system could impair brake performance.
TSB 23-20732023-04-04. Service bulletin. LANE DEPARTURE:SOFTWARE; LANE DEPARTURE. Some 2022-2023 F-150 Lightning vehicles equipped with BlueCruise and/or Lane Centering may exhibit the vehicle moving left and right within the vehicle's lane with the BlueCruise feature and/or Lane Centering active. This may be due to the software in the power steering control module (PSCM). To correct the condition, follow the Service Procedure to reprogram the PSCM.
TSB 23-20312023-04-04. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); ELECTRICAL SYSTEM:SOFTWARE. Some 2021-2022 F-150 vehicles equipped with a 3.5L PowerBoost engine may exhibit an illuminated powertrain malfunction (wrench) indicator with diagnostic trouble code (DTC) P2C44:00 stored in the powertrain control module (PCM). This may be due to the software in the PCM and the auxiliary battery isolator. To correct the condition, follow the Service Procedure to reprogram the PCM and replace the auxiliary battery isolator.
TSB 23-20142023-04-04. Service bulletin. ELECTRICAL SYSTEM. This article supersedes TSB 22-2355 to update the vehicle model years affected. Some 2021-2023 Mustang Mach-E, 2022-2023 e-Transit and F-150 Lightning vehicles may experience inoperative level 3 charging with an illuminated Charger Service Required indicator in the instrument panel cluster (IPC) and diagnostic trouble codes (DTCs) P0D93:00, P0D94:00, P0D98:00, P0D9E:00 and/or P0DA0:00 in the secondary on-board diagnostic module (SOBDM). If the charging cord is removed from the charge port without the lock/release button fully pressed, this can damage the charge port locking pin actuator and disable level 3 charging for the next charging session. To correct the condition, follow the Service Procedure to replace only the charge port lock actuator.
23H012023-03-07. Service bulletin. ELECTRICAL SYSTEM. Certain 2022-2023 Model Year F-150 Battery Electric Vehicle (BEV) High Voltage Battery Module Replacement This is a proactive investigation program by Ford Motor Company to obtain field parts for evaluation.
23B012023-03-06. Service bulletin. ENGINE AND ENGINE COOLING. Certain 2021-2022 Model Year Various Vehicle Lines Long Block Replacement
22B342023-03-06. Service bulletin. SUSPENSION. Certain 2021-2022 Model Year F-150 Vehicles Equipped with 9.75 HD Axle ¾ Float Axle Rear Axle Half-Shaft and Hub Assembly Replacement
TSB 23-20552023-03-04. Service bulletin. POWER TRAIN. Some 2022-2023 F-150 vehicles equipped with four-wheel drive (4WD), without a center console, and built on 17-Nov-2022 and through 28-Nov-2022 may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) U2002 stored in the powertrain control module (PCM). This may be due to an issue with the lower centerstack trim panel where the all terrain control panel (ATCM) mounts. To correct the condition, follow the Service Procedure to replace the lower centerstack trim panel.
TSB 23-20402023-03-04. Service bulletin. EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL. Some 2021-2022 F-150 built on or before 19-May-2022, Mustang Mach-E built on or before 04-May-2022 and 2022 Expedition/Navigator vehicles built on or before 13-May-2022 may exhibit various driver assistance system warning messages or inoperative features and/or diagnostic trouble codes (DTC) U3000:49, U3000:89, U2107:68, C1001:54 and/or C1001:78. This may be due to software in the IPMA. To correct the condition, follow the Service Procedure to reprogram the IPMA to the latest level.
SSM 513792023-03-04. Service bulletin. ELECTRICAL SYSTEM. Some 2021-2023 F-150/Transit, 2022-2023 F-150 Lightning vehicles may experience issues utilizing the Smart Hitch, ProPower Onboard or Onboard Scales features (if equipped) in the FordPass app. Symptoms may include inability to connect, incorrect data displayed in the app, no weight displayed, unable to power on/off the feature, unable to turn on generator mode (gas vehicles only). The connection for these features has been removed from the Android version of the FordPass app, and will soon be removed from the iOS version. The Smart Hitch and Onboard Scales will also be removed in a future FordPass release expected no later than March 1st, 2023. Full functionality of these features will remain in vehicle, but will not be controllable from FordPass. Advise the customer of the FordPass changes and do not perform any repairs for this concern.
SSM 513732023-03-04. Service bulletin. ELECTRICAL SYSTEM. Some 2021-2023 F-150 vehicles equipped with BLIS may experience inoperative blind spot monitoring with a Blind Spot System Fault message in the instrument panel cluster. This may also be accompanied by diagnostic trouble codes (DTCs) B118C:11 and/or B118C:15 stored in the driver door module (DDM), and/or B118D:11 and/or B118D:15 stored in the passenger door module (PDM). This may be due to the connector going from the mirror to the BLIS module (C576 for driver side, C676 for passenger side) having a pin out condition. To correct this condition, inspect the connector on the side experiencing the issue for a pin out condition and repair the circuit as necessary. Refer to Wiring Diagram, Cell 005, Connector Repair Procedures. If there is no issue with the connector or circuit, continue with normal diagnostics.
SSM 513562023-03-04. Service bulletin. ELECTRICAL SYSTEM. Some 2021-2022 F-150 vehicles may exhibit a condition of intermittent headlamp operation while the vehicle is off with diagnostic trouble code (DTC) B1533 stored in the body control module (BCM). This may be due to the internal logic within the headlamp switch. To correct this condition, replace the headlamp switch (service base part number 11654). Refer to Workshop Manual (WSM), Section 417-01. For claiming, use casual part 11654 and the applicable labor operations of Section 10 of the Service Labor Time Standards (SLTS) Manual.
SSM 513522023-03-04. Service bulletin. BACK OVER PREVENTION:SOFTWARE; EQUIPMENT:ELECTRICAL. Some 2021-2022 F-150 vehicles may still have a false alarm activation with a trailer connected and/or diagnostic trouble code (DTC) U0143:87 stored in the TRM after technical service bulletin (TSB) 22-2122 was completed. This was due to a software release issue. To correct the condition download and run the TRM configuration application in the Ford Diagnosis and Repair System (FDRS). For claiming use 12651D4 in section 10 of the service labor time standard (SLTS) manual.
SSM 513312023-03-04. Service bulletin. ELECTRICAL SYSTEM. Some 2021-2022 F-150 vehicles may exhibit all modules on the HS2, HS3, HS4 and MS CAN networks not responding to the Ford Diagnosis and Repair System (FDRS) and modules on these networks fail the network test. Modules on the FD1 and HS1 networks will communicate with the FDRS. Vehicles equipped with a power opening/closing tailgate may also exhibit an inoperative power tailgate. This may be due to a gateway module (GWM) that is not configured properly. To correct this condition, download and run the GWM - Gateway Module A (GWM) Configuration application. For claiming, use causal part number 14G490 and applicable labor times from Section 10 of the Service Labor Times Standard (SLTS) Manual.
22PU1010MILLT2023-02-06. Service bulletin. SERVICE BRAKES. Priority Update 22-PU1010-MIL-LT for 2022 F-150 vehicles is now available. Quality improvements include: - Improvement to calibration of brake fluid viscosity algorithm to prevent false DTC detection at cold weather
SSM 513232023-02-02. Service bulletin. EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL. Some 2022-2023 F-150 Lightning vehicles may experience an Active Air Dam System Fault See Manual warning message in the instrument panel cluster (IPC). This IPC message should be disregarded. Engineering is currently developing software to remove this message from the vehicle, which is scheduled to be available in March 2023. Continue to follow current Workshop Manual (WSM) diagnostics for the active air dam system.
SSM 513192023-02-02. Service bulletin. EQUIPMENT:ELECTRICAL. Some 2021-2023 F-150 vehicles may exhibit a side door ajar and/or a hood ajar warning message displayed in the instrument panel cluster (IPC) with or without diagnostic trouble codes (DTC) P166B, B1175, B1176, B11C1 and/or B11C0. This may be due to a misalignment of the the door or hood and/or their strikers. Before attempting any component diagnosis or replacement, check the door and/or hood and their strikers for proper alignment. Refer to Workshop Manual (WSM), Section 501-03 alignment procedures. If the doors and hood are properly aligned, continue with normal diagnostics.
SSM 513102023-02-02. Service bulletin. BACK OVER PREVENTION:DISPLAY FUNCTION. Some 2021-2022 F150 vehicles may experience buttons or screens overlapping in the center display screen after an accessory protocol interface module (APIM) over the air (OTA) update. This may be due to an incomplete or partial OTA download. The APIM software update that addresses this concern may have been sent via Ford Power-Up software updates delivered OTA to connected vehicles that have automatic updates enabled through the center display screen. It is recommended that customers that have experienced this concern verify automatic updates are enabled and that the vehicle has been run long enough to receive updates via OTA. If the problem still persists after the vehicle has been run, use the Report a Vehicle Concern link at the bottom of the OASIS report and fill out the form.

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.