Service bulletins for the 2022 Ford F-150
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
594 on file from NHTSA, as of 2026-10-19.
By type
By component
By trouble code
| SSM 51306 | 2023-02-02. Service bulletin. ELECTRICAL SYSTEM. Some 2018-2023 F-150, Expedition, Navigator, Transit, Aviator and Explorer vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0627, P025A, P025B, P00C6, P008A and/or U0109 stored in the powertrain control module (PCM). This may be due to an intermittent or partial disconnect of the harness to the fuel pump control module (FPCM) connector, connector pin push-outs, damaged pins/terminals, or loose/corroded grounds. Inspect FPCM connector, applicable grounds (F-150 - G401, Expedition/Navigator - G403, Transit - G401, 2018-2019 Explorer G302, 2020-2022 Explorer/Aviator - G407) and confirm FPCM connector (F-150 - C4336, Expedition/Navigator - C433, Transit - C433, 2018-2019 Explorer - C3239, 2020-2022 Explorer/Aviator - C4033) is fully seated prior to performing PC/ED diagnostics or replacing any components. |
|---|---|
| SSM 51298 | 2023-01-31. Service bulletin. EQUIPMENT:ELECTRICAL. Some 2022 F-150 vehicles built on 04-Aug-2022 and through 20-Sep-2022 at Dearborn Truck Plant (DTP) may exhibit inoperative FordPass activation, a Feature Unavailable error message when trying to activate the vehicle from FordPass, a telematics control unit (TCU) not responding to network test while using the Ford Diagnosis and Repair System (FDRS), diagnostic trouble codes (DTCs) U2402:00 and U2402:92 stored in the gateway module (GWM), and U0198:00 stored in the accessory protocol interface module (APIM). This may be due to absence of TCU. Check for TCU presence and if missing, install TCU and perform programmable module installation (PMI) using the latest software level of FDRS. For claiming, use causal part number 14F546 and applicable labor times from Section 10 of the Service Labor Times Standard (SLTS) Manual. |
| SSM 51289 | 2023-01-31. Service bulletin. EQUIPMENT:ELECTRICAL. Some 2022 F-150 vehicles built on 04-Aug-2022 and through 20-Sep-2022 at Dearborn Truck Plant (DTP) may exhibit inoperative FordPass activation, a FEATURE UNAVAILABLE error message when trying to activate the vehicle from FordPass, a TCU not responding to Network test while using the Ford Diagnosis and Repair System (FDRS), Diagnostic Trouble Codes (DTCs) U2402:00 and U2402:92 stored in the Gateway Module (GWM), and U0198:00 stored in the Accessory Protocol Interface Module (APIM). This may be due to absence of TCU. Check for TCU presence and if missing, install TCU and perform Programmable Module Installation (PMI) using the latest software level of FDRS. For claiming, use causal part number 14C708 and applicable labor times from Section 10 of the Service Labor Times Standard (SLTS) Manual. |
| TSB 23-2030 | 2023-01-31. Service bulletin. POWER TRAIN. 2020-2022 Aviator/Explorer/Police Interceptor, 2021-2022 F-150 vehicles equipped with a 10R80 MHT transmission and built on or before 15-Nov-2022 may exhibit an 8th gear start after coming to a stop and/or a no movement in Reverse condition. This may be due to the driver applying the accelerator pedal and brake pedal simultaneously during regenerative braking. To improve the condition, follow the Service Procedure to reprogram the powertrain control module (PCM) and refer the customer to the Automatic Transmission Section of the Owners Manual warning regarding applying both pedals simultaneously. |
| TSB 23-2015 | 2023-01-31. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); ENGINE AND ENGINE COOLING. 2021-2022 F-150 vehicles with 2.7L, 3.3L, 3.5L EcoBoost or 5.0L engines, 2020-2022 Transit vehicles with 3.5L Duratec/3.5L EcoBoost engines, 2023 Bronco with the 2.3L engine having charging system diagnostics performed in the Workshop Manual (WSM) may experience the generator voltage desired (GENVDSD) parameter identification (PID) missing from the powertrain control module (PCM) PID list in the Ford Diagnosis And Repair System (FDRS) scan tool. This may be due to a software parameter in the PCM. To correct the condition, follow the Service Procedure to reprogram the PCM. |
| 22OTA SU4P1F150 | 2023-01-07. Service bulletin. BACK OVER PREVENTION:SOFTWARE. Software Update 4 P1 for 2022 Model Year F-150 Lightning vehicles is now available. Quality Improvements Include: - Emergency Tow initializing screen pop-up enhancement for 12" screen - Enhancement to bidirection power transfer, currently briefly popping up a fault before switching to main screen - Improvement to max battery charge slider appearance |
| 22G05 S2 | 2023-01-06. Service bulletin. EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL. Certain 2022 Model Year F-150 and Super Duty Vehicles Exterior Badge Retrofit REASON FOR THIS SUPPLEMENT Service Action: Dealers are to order parts through the SSSC as needed. Claims Preparation And Submission: Causal part number correction. Labor Allowances: Clarification - temporary fender vent badge adjustment is for Super Duty only. Parts: Dealers are to order parts through the SSSC as needed. Correction: The small King Ranch tailgate badge does not apply to the F-150 2022 Model Year in this program. |
| SSM 51279 | 2023-01-06. Service bulletin. ELECTRICAL SYSTEM. Some 2021-2023 F-150, 2021-2022 F-Super Duty, 2021-2023 Ranger customers may have concerns including, but not limited to: no power to the distribution box, rear camera inoperative, rear park assist inoperative, box lights inoperative, power up/down tailgate inoperative, unable to open tailgate by tailgate switch, and no tailgate ajar message when the tailgate is ajar. These concerns may be caused by faulty connections between the pickup bed, tailgate, rear lamp assemblies, or bumper where connectors are disconnected, damaged, or coated with bedliner. Prior to performing any warranty diagnosis or repairs, verify if the vehicle had an aftermarket spray-in-bedliner. Any repairs resulting from aftermarket products/installation, including but not limited to a spray-in bedliner, are not covered under warranty. |
| SSM 51265 | 2023-01-06. Service bulletin. VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR; EQUIPMENT. Some vehicles equipped with power folding mirrors may exhibit power folding mirrors that are inoperative or exhibit a clicking sound. This may be due to the mirrors being manually folded in, during transportation, going through a car wash, bumped in a parking lot, or found during pre-delivery inspection (PDI). Prior to the replacement of any components, attempt to synchronize the mirrors by following the Power Mirrors Synchronization procedure. Refer to Workshop Manual (WSM) Section 501-09 Rear View Mirrors - General Procedures - Power Mirrors Synchronization. |
| SSM 51263 | 2023-01-06. Service bulletin. BACK OVER PREVENTION; STRUCTURE:BODY:DOOR. Some 2015-2023 F-150, 2017-2022 F-Super Duty, and 2019-2023 Ranger vehicles may exhibit dust ingress into the cabin through the doors or air extractors. This may be due to the climate control system being in recirculation mode as a result of the recirculation button being on or automatic strategies for heating/cooling efficiency. To minimize dust ingress when driving in off-road or secondary road conditions, make sure that all doors and windows are fully closed and the climate control system is switched to defrost on and the instrument panel and footwell air vents are switched to off. Temperature and fan settings may be adjusted as desired. Alternatively, max defrost can be activated which will adjust all settings automatically. Operating in defrost mode will keep constant air flow through the rear air extractors and other small areas, helping minimize dust ingress. |
| SSM 51261 | 2023-01-06. Service bulletin. SERVICE BRAKES. Some Ford and Lincoln vehicles may exhibit noise when the brakes are applied. When diagnosing and repairing brake noise conditions, use the Workshop Manual (WSM) and the appropriate pinpoint test in section 206-00. The brake rotors should only be machined if directed by the WSM because one or more of the following conditions are present on the braking surface: scoring, excessive corrosion/rust or pitting, bluing/discoloration and/or heat spots. For additional information, refer to WSM section 206-00. |
| SSM 51244 | 2023-01-05. Service bulletin. EQUIPMENT:ELECTRICAL. Some 2021-2022 F-150 vehicles may exhibit a condition of intermittent headlamp operation while the vehicle is OFF and have diagnostic trouble code (DTC) B1533 stored in the body control module (BCM). This may be due to the internal logic within the headlamp switch. Switch and/or module replacement will not resolve this condition. Headlamp operation is not affected while the vehicle is ON. A new headlamp switch is currently under development to correct this condition. Let the customer know they can continue to drive the vehicle and schedule a follow-up appointment in January 2023, when parts are expected to become available. Follow up with the customer to confirm the appointment once OASIS is updated with the repair information. |
| SSM 51226 | 2023-01-05. Service bulletin. UNKNOWN OR OTHER; STEERING:STEERING CONTROL MODULE; ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL. Some 2021-2023 F-150 vehicles may experience a lack of steering assist upon start-up along with a Steering Assist Fault message in the instrument panel cluster (IPC) with diagnostic trouble codes (DTC) U3001:89 and U3000:96 in the power steering control module (PSCM). This may be due to low voltage at the PSCM. Power steering assist will be restored when sufficient voltage is supplied. To clear the DTCs using the Ford Diagnosis and Repair System (FDRS), select and run the PSCM - Reset the Power Steering Control Module (PSCM) application. Once cleared, cycle the ignition to verify normal system operation. If the DTCs return, refer to Workshop Manual Section 211-02 for normal diagnostics. For claiming, use causal part 3504. |
| TSB 22-2497 | 2023-01-05. Service bulletin. ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM; ELECTRICAL SYSTEM:SOFTWARE; UNKNOWN OR OTHER; ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL. Some 2021-2022 F-150 Tremor vehicles built on or before 18-Nov-2022 may experience the instrument panel cluster (IPC) goes blank or reboots after attempting to access Trailer Tire Info in the Towing menu. This may be due to the software in the IPC. To correct the condition, follow the Service Procedure to reprogram the IPC. |
| TSB 22-2495 | 2023-01-05. Service bulletin. ELECTRICAL SYSTEM. Some 2022 F-150 Lightning vehicles may exhibit an illuminated red triangle indicator lamp with diagnostic trouble codes (DTC) P27B4 in the primary drive control module (PDCM) or the CSI is blinking red with P0A7F in the battery energy control module (BECM) and/or P0CF7 in the battery charger control module (BCCM). This may be due to the software within the BCCM module. To correct the condition, follow the Service Procedure to reprogram the BCCM module. |
| TSB 22-2494 | 2023-01-05. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT. This article supersedes TSB 22-2105 to update the vehicles affected, issue, action, and service procedure. Some 2021-2022 F-150/Mach-E and 2022 Expedition/Navigator vehicles equipped with BlueCruise/ActiveGlide may experience loss of BlueCruise/ActiveGlide hands-free driving mode availability. This may be due to an expired BlueCruise/ActiveGlide map file in the gateway module (GWM). To correct the condition, follow the Service Procedure to update the GWM. |
| TSB 22-2485 | 2023-01-05. Service bulletin. EQUIPMENT; EQUIPMENT:ELECTRICAL:WIRELESS CHARGER/CRADLE. Some 2020-2021 Expedition/Navigator, 2020-2022 F Super Duty/Explorer, 2021-2022 Bronco/Corsair/Escape/Bronco Sport, 2022 Maverick vehicles may exhibit the wireless charger inoperative or poor performance when using some Apple iPhone models that use MagSafe wireless charging including iPhone 12 and 13. This may be due to limited compatibility with the wireless accessory charging module (WACM). To correct the condition, follow the Service Procedure to update the WACM. Note: The WACM software is designed to improve the compatibility between some Apple MagSafe charging iPhones, including iPhone 12 and 13 models, and the Ford Qi wireless charging module. |
| TSB 22-2483 | 2023-01-05. Service bulletin. POWER TRAIN. Some 2021-2022 F-150 vehicles equipped with a 10R80 MHT transmission and built on or before 13-Oct-2022 may exhibit a rattle noise from the transmission area after a cold start in freezing temperatures. The noise typically goes away as the powertrain warms up. To improve the cold start noise condition, follow the Service Procedure to reprogram the PCM. |
| TSB 22-2471 | 2023-01-05. Service bulletin. ELECTRICAL SYSTEM; ELECTRICAL SYSTEM:PROPULSION SYSTEM. This article supersedes TSB 21-2205 to update the vehicles and vehicle model years affected. 2021-2022 F-150 vehicles with 2.7L, 3.5L EcoBoost or 5.0L engines, 2020-2022 Transit vehicles with 3.5L EcoBoost engine having charging system diagnostics performed in the Workshop Manual (WSM) may experience the generator voltage desired (GENVDSD) parameter identification (PID) missing from the powertrain control module (PCM) PID list in the FDRS. This may be due to a software parameter in the PCM. To correct the condition, follow the Service Procedure to reprogram the PCM. |
| TSB 22-2388 | 2023-01-05. Service bulletin. FUEL SYSTEM, GASOLINE. Some 2021-2022 F-150 Raptor vehicles built on or before 06-Jun-2022 may experience a rattle noise from the exhaust at the exhaust tailpipe actuators. This may be due to the exhaust tailpipe actuator valves rattling inside the muffler assembly. To correct the condition, follow the Service Procedure to reprogram the powertrain control module (PCM) and install new exhaust tailpipe actuator valve springs on the exhaust tailpipe actuator valves. |
| 22OTASU3 P2 F150 | 2022-12-08. Service bulletin. BACK OVER PREVENTION:SOFTWARE. Software Update 3 P2 for 2021-2021 Model Year F-150 is now available. Quality Improvements Include: Changing the default trailer profile trailer brake gain from 0 to 15, change to low power mode rearview camera distortion when the vehicle is shut off and restarted quickly without opening the vehicle doors. Improvement to onboard scales and sync camera view interaction. |
| 2122OTA22PU11010 | 2022-12-08. Service bulletin. EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL. Priority Update OTA 22-PU1010-MIL-QL for 2021 Model Year F-150 vehicles is now available. Quality Improvements Include: Shift quality improvements, failsafe cooling improvements, improvement to calibration of brake fluid viscosity algorithm to prevent false DTC detection at cold weather. |
| 22OTA22PU1110SNC | 2022-12-07. Service bulletin. EQUIPMENT:ELECTRICAL. Priority Update 22-PU1110-SNC-RS for 2022 Model Year F-150 Lightning vehicles is now available. Quality Improvements Include: improvement to 1-Pedal-Drive pop-up on Sync, update to valet geofence. |
| 22OTAPU2210MILDT | 2022-12-07. Service bulletin. EQUIPMENT:ELECTRICAL. Priority Update PU-22-10-MIL-DTE for 2022 Model Year F-150 Lightning vehicles is now available. Quality Improvements Include: Shorter time to engage electric park brake after driver's door is closed, motor temperature display changes more gradually, improvement to calibration of brake fluid viscosity algorithm to prevent false DTC detection at cold weather, robustness action to retract locking pin while off plug, 12V battery drain improvements, improvements to distance-to-empty learned efficiency. |
| 22G05 S1 | 2022-12-02. Service bulletin. UNKNOWN OR OTHER. Certain 2022 Model Year F-150 and Super Duty Vehicles Exterior Badge Retrofit REASON FOR THIS SUPPLEMENT Service Action: Interim Service Action for temporary fender vent badge interference as needed Added details for vehicles arriving with production badges. Labor Allowances: Added labor code for temporary fender vent badge adjustment as an interim repair Added labor code for a vehicle that has production badges to close out of the program. Technical Information: Updated service details including interim actions for temporary badges |
The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.