Service bulletins for the 2024 Mazda CX-90
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
552 on file from NHTSA, as of 2026-10-19.
By type
By component
By trouble code
By topic
Only bulletins with component: Engine are shown. Show all
| SA-009-24e | 2025-01-04. Service bulletin. UNKNOWN OR OTHER; ENGINE; ELECTRICAL SYSTEM. Frequently Asked Questions (FAQ) |
|---|---|
| 07-004-24a | 2025-01-04. Service bulletin. UNKNOWN OR OTHER; ENGINE. Some vehicles may exhibit check engine light turned on at engine startup, with DTC P0531:00 stored in memory. DTC P0531:00 [PCM] - Refrigerant pressure sensor No.1 system: Function malfunction. This is caused by improper control logic of the PCM and the dash-electrical supply unit (Dash-ESU). To eliminate this concern, the control logic of the PCM and the Dash-ESU has been modified. |
| SA-020-24c | 2024-12-03. Service bulletin. FUEL/PROPULSION SYSTEM; ELECTRICAL SYSTEM; ENGINE. The CX-70 and CX-90 have new and revised features that are different from previous models and may be difficult to understand. This Service Alert provides valuable information to support potential dealer and customer concerns. |
| SA-040-24a | 2024-11-04. Service bulletin. ENGINE; ELECTRICAL SYSTEM. Some customer may experience any of the following: Multiple Warning Lights On • Infotainment center display blank • Engine no start unless the key transmitter is placed near the start button • Interior lights do not illuminate • DTC P2507:00 - PCM, PCM POWER SYSTEM: (LOW INPUT) stored. • DTC U0156:00 - PCM, CAN communication system, Communication error with CMU (Connectivity Master Unit). • This may be caused by Fuse F1 not fully seated (poor terminal tension) or a poor ground connection at the front harness connector G03. |
| SA-017-24b | 2024-10-05. Service bulletin. ELECTRICAL SYSTEM; ENGINE; EXTERIOR LIGHTING. Some customers may complain about any of the following: 1. Infotainment Center Display does not provide the Authorization Code (OTP) during the MyMazda App Connected Vehicle enrollment. 2. Remote function(s) inoperative. Engine Start / Stop Door Lock / Unlock Lights ON / OFF Climate Control |
| SA-071-24 | 2024-10-04. Service bulletin. ENGINE; ELECTRICAL SYSTEM. After an HV inverter replacement, there is no instruction in the WSM to perform Initial Learning of the Electric Motor Speed Sensor. This is required after replacing the inverter or electric motor. As a result, when attempting to start the vehicle, the Internal combustion (ICE) engine will start and then stop with DTC P0C17 stored. If this DTC is set, refer to P0C17:00 [SGC2/DMCM (e-SKYACTIV PHEV)] in the troubleshooting manual. NOTE: When attempting to complete the Learn of Electric Motor Speed Sensor with MDARS, it will be unsuccessful until the vehicle is shut off and left undisturbed for 1-2 hours. Make sure the 12V battery is fully charged and the EV battery is charged, then connect the battery and wait a minimum of 1-2 hrs with the ignition OFF before proceeding directly to the relearn procedure. DO NOT start the engine until directed to do so in the relearn procedure. |
| SA-066-24 | 2024-10-04. Service bulletin. ELECTRICAL SYSTEM; ENGINE. Some customers may complain that the MyMazda App Remote Engine Start function fails. MX-30 and PHEV vehicles do not have a Remote Engine Start function; instead, they are equipped with the following remote functions: Start / Stop Charge Climate On / Off |
| SA-040-24 | 2024-10-04. Service bulletin. ENGINE; ELECTRICAL SYSTEM. Some customer may experience any of the following: Multiple Warning Lights On • Infotainment center display blank • Engine no start unless the key transmitter is placed near the start button • Interior lights do not illuminate • DTC P2507:00 - PCM, PCM POWER SYSTEM: (LOW INPUT) stored. • DTC U0156:00 - PCM, CAN communication system, Communication error with CMU (Connectivity Master Unit). |
| SA-020-24b | 2024-10-04. Service bulletin. ELECTRICAL SYSTEM; LANE DEPARTURE: WARNING; ENGINE; LANE DEPARTURE: BLIND SPOT DETECTION; FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL. The CX-70 and CX-90 have new and revised features that are different from previous models and may be difficult to understand. This Service Alert provides valuable information to support potential dealer and customer concerns. |
| SA-057-24 | 2024-09-04. Service bulletin. ENGINE; ELECTRICAL SYSTEM; UNKNOWN OR OTHER. If you encounter any type of electrical concern (e.g, dead battery, engine no start, DTC(s) stored...), interview the customer before proceeding with normal MGSS diagnosis by asking if any aftermarket devices have been installed. Aftermarket devices may be the cause of the electrical concern. Below are a few examples of unusual electrical concerns caused by aftermarket devices. |
| SA-052-24 | 2024-09-04. Service bulletin. POWER TRAIN; ENGINE. Some customer's might state that they notice fluid or oil leaking/dripping on the ground when the vehicle is parked. For this concern, inspect the vehicle for any trace of a fluid or oil leak and use the following examples as a guide to determine if it is severe enough to require a repair, or just to clean the area and monitor it at the next service. |
| SA-019-24b | 2024-08-03. Service bulletin. ELECTRICAL SYSTEM; ENGINE. Some customers may experience a vehicle no start (no "Ready-ON") due to the 12V battery discharged or the High Voltage (HV) battery discharged. This may be caused by: Ignition left ON when exiting the vehicle (exiting the vehicle during "Ready-On"). Door/liftgate opened multiple times without ignition "Ready-ON" or driving vehicle. Installation of aftermarket electronic devices. To minimize the battery drain concern, ensure that the vehicle shift selector is in Park when exiting and verify the ignition is turned OFF when exiting. NOTE: If multiple door/liftgate opening without "Ready-ON', drive vehicle to charge 12V battery. |
| SA-004-24 | 2024-08-03. Service bulletin. ENGINE. Click here to view coolant bleeding procedure. |
| 01-006-24 | 2024-07-04. Service bulletin. POWER TRAIN; ENGINE; UNKNOWN OR OTHER. Some customers may experience a driving feel concern due to a late response to start the engine (and cancel EV mode) while climbing uphill in EV mode under a low battery SOC (30% or lower) condition. This may be caused by improper control software of the PCM. To eliminate this concern, the control software of the PCM has been modified. |
| 01-004-24a | 2024-07-04. Service bulletin. ENGINE; FUEL/PROPULSION SYSTEM. Some customers may complain about a noise from the engine compartment at idle. This may be caused by the fuel injection learning cycle at idle from the high pressure fuel pump. To eliminate this concern, the control software of the PCM has been modified. |
| SA-035-24 | 2024-06-04. Other. ENGINE. There is a concern that some water pumps are being replaced that are not faulty, due to signs of a very small coolant leak from the bleed hole. This Service Alert is to inform you about the water pump sealing mechanism and the criteria if replacement is necessary or not. |
| SA-029-24 | 2024-06-03. Other. ENGINE. The CX-90 and CX-70 PHEV are equipped with two electric water pumps that look similar but have different part numbers. CAUTION: If the wrong water pump is ordered or they are reversed, DTC U019F could be set. |
| PF-24-05 | 2024-06-03. Other. ENGINE. The CX-90 and CX-70 PHEV is equipped with two electric water pumps that look similar but have different part numbers and functionalities. CAUTION: If the wrong water pump is ordered or they are installed reversed, DTC U019F could be set. |
| 01-004-24 | 2024-06-03. Service bulletin. ENGINE; FUEL/PROPULSION SYSTEM. Some customers may complain about a noise from the engine compartment at idle. This may be caused by the fuel injection learning cycle at idle from the high pressure fuel pump. To eliminate this concern, the control software of the PCM has been modified. |
| SA-017-24a | 2024-05-04. Service bulletin. EXTERIOR LIGHTING; ENGINE AND ENGINE COOLING; LATCHES/LOCKS/LINKAGES. Some customers may complain about any of the following: 1. Infotainment Center Display does not provide the Authorization Code (OTP) during the MyMazda App Connected Vehicle enrollment. 2. Remote function(s) inoperative. Engine Start / Stop Door Lock / Unlock Lights ON / OFF Climate Control |
| SA-025-24 | 2024-05-03. Service bulletin. ENGINE AND ENGINE COOLING; ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER. On some vehicles, an engine oil leak from the rear of the engine at the turbocharger drain back tube could be be confused as an oil leak from behind the bell housing. The bolt holes for the drain back tube to the block are drilled through to the inside of the engine and thread sealer was not properly applied to the bolts threads, causing oil to leak past the threads. NOTE: The WSM was updated to show these bolts are a to be replaced if removed. New bolts will have thread sealer already applied. |
| SA-019-24a | 2024-05-03. Service bulletin. ELECTRICAL SYSTEM; ENGINE AND ENGINE COOLING; EQUIPMENT ADAPTIVE/MOBILITY. Some customers may experience a vehicle no start (no "Ready-ON") due to the 12V battery discharged or the High Voltage (HV) battery discharged. This may be caused by: Ignition left ON when exiting the vehicle (exiting the vehicle during "Ready-On"). Door/liftgate opened multiple times without ignition "Ready-ON" or driving vehicle. Installation of aftermarket electronic devices. To minimize the battery drain concern, ensure that the vehicle shift selector is in Park when exiting and verify the ignition is turned OFF when exiting. NOTE: If multiple door/liftgate opening without "Ready-ON', drive vehicle to charge 12V battery. |
| SA-017-24 | 2024-04-03. Service bulletin. EQUIPMENT; EQUIPMENT:ELECTRICAL:INFOTAINMENT; ENGINE AND ENGINE COOLING; ELECTRICAL SYSTEM. Some customers may complain about any of the following: 1. Infotainment Center Display does not provide the Authorization Code (OTP) during the MyMazda App Connected Vehicle enrollment. 2. Remote function(s) inoperative. Engine Start / Stop, Door Lock / Unlock, Lights ON / OFF, Climate control |
| SA-020-24 | 2024-04-02. Service bulletin. ENGINE AND ENGINE COOLING; EQUIPMENT ADAPTIVE/MOBILITY; ELECTRICAL SYSTEM; POWER TRAIN. CX-70 and CX-90 service cautions for new and revised features. The CX-70 and CX-90 have new and revised features that are different from previous models and may be difficult to understand. This Service Alert provides valuable information to support potential dealer and customer concerns. |
| SA-019-24 | 2024-04-02. Service bulletin. ENGINE AND ENGINE COOLING; ELECTRICAL SYSTEM; POWER TRAIN. Some customers may experience a vehicle no start (no "Ready-ON") due to the 12V battery discharged or the High Voltage (HV) battery discharged. This may be caused by: Ignition left ON when exiting the vehicle (exiting the vehicle during "Ready-On"). Door/liftgate opened multiple times without ignition "Ready-ON" or driving vehicle. Installation of aftermarket electronic devices. To minimize THE battery drain concern, ensure that the vehicle shift selector is in Park when exiting and verify the ignition is turned OFF when exiting. NOTE: If multiple door/liftgate opening without "Ready-ON', drive vehicle to charge 12V battery. |
The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.