WenmarOpen by Wenmar Pro

Service bulletins for the 2017 MINI Clubman

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

139 on file from NHTSA, as of 2026-10-19.

By type

By component

Only bulletins with component: Equipment and accessories are shown. Show all

Bulletins, newest first
M6501162019-02-25. Service bulletin. EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.. XM Satellite Radio Reception. INFORMATION Currently Satellite Radio is provided by SiriusXM for MINI customers. SiriusXM is the only company currently broadcasting Satellite Radio in North America. Satellite radio was broadcast from two different sets of Satellites using different earth orbits. XM uses geosynchronous (GEO) satellites located roughly above the equator. This means that the satellite signal to some parts of the United States can come in at an angle as low as 32 degrees to the horizon. This is different than Sirius Satellites in a Highly Elliptical Orbit (HEO) which came in to the vehicle at a higher angle to the horizon. As of April 2016 Sirius equipped head units moved to the XM Satellites constellation and now show the same location based cutouts.
M6402162018-12-10. Service bulletin. EQUIPMENT; EQUIPMENT:APPLIANCE:AIR CONDITIONER. Air Conditioning Refrigerant R1234yf Introduction. INFORMATION Several precautions need to be observed when working on automotive air conditioning systems: Always wear eye protection and gloves while handling refrigerant or servicing air conditioning system. Avoid breathing R1234yf lubricant vapor or mist. Use only approved service equipment to discharge A/C systems. If refrigerant or compressor oil contacts the skin or eyes, large quantities of cool water should be used to flush the affected area. Never heat a refrigerant container with an open flame. Keep all refrigerant away from open flames. Under no circumstances should R1234yf service equipment or vehicle A/C systems be pressure tested or leak tested with air/R1234yf mixtures. NOTE: The use of compressed air (shop air) for leak detection in an R1234yf system can contaminate the system and/or refrigerant with moisture. Leak detection equipment that meets the SAE J2791 standard will work with R1234yf Never use fittings for an R12 or R134a system on an R1234yf system. Any difficulty in connecting service equipment may be an indication of refrigerant/equipment incompatibility with the vehicle's system. Always carefully ascertain the type of refrigerant used in the vehicle's system before performing service. Labels on underside of hood, will detail which refrigerant is used in the air conditioning system. Service the vehicle with compatible recycling equipment ONLY. Attempts to adapt and use incompatible service tools will destroy both the vehicle's air conditioning system and the service tool. Never use any R-12/R134a service tools on R1234yf systems. Tools, such as manifold gauge sets, retain small amounts of refrigerant and lubricant. Attempting to use the same equipment on both R-12/R134a and R1234yf vehicles will contaminate the air conditioning systems. Obtain and use the correct type of refrigerant recovery/recycling machine. Follow the directions included in the machine's instruction manual. WARR
M1109162018-12-10. Service bulletin. EQUIPMENT. VANOS AND VANOS CENTRAL BOLT IDENTIFICATION. INFORMATION Replacing the VANOS gear central bolts or the VANOS gear will require a component inspection when the engine assembly has been previously replaced in one of the vehicles listed above. Ordering the parts via the model, production or VIN may provide the incorrect part numbers. The procedure below will help identify which VANOS parts are installed in the replacement engine. 11 36 7 608 788 Inlet adjustment unit Oulet adjustment unit Refer to the ETK and the repair instructions for one time use fastener and component information regarding additional screws, gaskets and seals.
M8401142018-12-10. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT; EQUIPMENT:ELECTRICAL. Bluetooth Connection Failures This Service Information bulletin supersedes SI M84 01 14 dated February 2016.. There are various connectivity failures with the following devices: Apple iPhones Samsung S6 and the S6 Edge. Connectivity failure examples are: Call disconnection - Call is transferred back to the handset. In some instances the call is then transferred back to the vehicle. Contact List incomplete General connection failures Apple iOS software (issue started with iOS 8.3 continues with iOS 9.x and its variants) Samsung S6 and S6 Edge device firmware
M6513152018-12-10. Service bulletin. EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.. Hissing noise from speakers when radio volume is turned down. There is an audible hissing noise from the speakers when there is no active audio source. This noise is most apparent with the engine and climate system fan turned off. Software in the HK HiFi amplifier.
M6505162018-12-10. Service bulletin. EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.. Sporadic Failure of Different Audio Channels. Intermittently, different speakers may be inoperative during an entire drive cycle until the vehicle enters sleep mode and the vehicle is restarted. CAUSE Shut-down of output circuit(s) from pressure variations caused by door shutting during diagnostic self-test. After unlocking the vehicle the Harman/Kardon (HK) Amplifier goes into a speaker self-test mode. If a door is slammed during this self-test vibrating the speaker cone, the HK amplifier may interpret the changing resistance of the speaker as a circuit failure. The HK Amplifier will then go into protection mode and turn off the output transistor(s) for the particular speaker(s) until the next selftest which is performed after the next sleep cycle.
M6503162018-12-10. Service bulletin. EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.. NBT and Entry Head Unit Software Update for Improved Satellite Radio Reception. Poor Satellite Radio reception CAUSE After this software update there is a slight improvement in Satellite Radio reception for these vehicles when receiving their signal from XM Satellites. This is due to the changeover from Sirius Satellite broadcasting to XM Satellite broadcasting in 2016 (See SI M65 01 16).
M6502162018-12-10. Service bulletin. EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES. False Alarms of the Anti-Theft Alarm System. The alarm (DWA) siren continues to activate after locking vehicle A device is connected to the On-Board Diagnostics (OBD) port of the vehicle. This keeps the Ethernet communication line active which triggers the alarm when the vehicle tries to enter sleep mode.
M6402162018-12-10. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER. "Air Conditioning Refrigerant R1234yf Introduction. INFORMATION Highlights of R-1234yf Meets SAE J2888_201301 ""This SAE Standard covers fittings, couplers, and hoses intended for connecting service hoses from mobile air- conditioning Systems to service equipment such as charging, recovery and recycling equipment"". New tools and equipment are required. To service vehicles equipped with R-1234yf refer to SI M04 01 16. Air conditioning technician certification is required to work on system. Refer to your State Law. Unique low and high side fittings. Revised evaporator core as per SAE J2842. System will use about 5% more refrigerant than a comparable R134a system. System oil is a specific PAG oil. Refer to ISTA repair recommendation. Do not interchange components between systems using other refrigerants. Do not reuse Seals / O-ring material from another system. The system piping has internal heat exchangers (IHX or IWT). SAFETY INFORMATION Several precautions need to be observed when working on automotive air conditioning systems: Always wear eye protection and gloves while handling refrigerant or servicing air conditioning system. Avoid breathing R1234yf lubricant vapor or mist. Use only approved service equipment to discharge A/C systems. If refrigerant or compressor oil contacts the skin or eyes, large quantities of cool water should be used to flush the affected area. Never heat a refrigerant container with an open flame. Keep all refrigerant away from open flames. Under no circumstances should R1234yf service equipment or vehicle A/C systems be pressure tested or leak tested with air/R1234yf mixtures. NOTE: The use of compressed air (shop air) for leak detection in an R1234yf system can contaminate the system and/or refrigerant with moisture. Leak detection equipment that meets the SAE J2791 standard will work with R1234yf Never use fittings for an R12 or R134a system on an R1234yf system. Any difficulty in connecting service equipment may be an indication of ref
M6401162018-12-10. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER. Water Ingress In Footwell Area From A/C Condensate Drain. Customer complains of musty odor and/or damp front footwell carpet. CAUSE The A/C condensate drain hose is either blocked by the heatshield or not attached properly to the the housing.
M8401142018-12-10. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE; EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.. This Service Information bulletin supersedes SI M84 01 14 dated November 2014. SUBJECT Bluetooth Connection Failures. There are various connectivity failures with the following devices: z Apple iPhones z Samsung S6 and the S6 Edge. Connectivity failure examples are: z Call disconnection - Call is transferred back to the handset. In some instances the call is then transferred back to the vehicle. z Contact List incomplete z General connection failures z Apple iOS software (issue started with iOS 8.3 continues with iOS 9.x and its variants) z Samsung S6 and S6 Edge device firmware
M6501162018-12-10. Service bulletin. EQUIPMENT ADAPTIVE/MOBILITY; EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.. SI M65 01 16 February 2016 Audio, Navigation, Monitors, Alarms, SRS Technical Service SUBJECT XM Satellite Radio Reception. Currently Satellite Radio is provided by SiriusXM for MINI customers. Satellite radio is broadcast from two different sets of Satellites using different earth orbits. XM uses geosynchronous (GEO) satellites located roughly above the equator. This means that the satellite signal to some parts of the United States can come in at an angle as low as 32 degrees to the horizon. This is different than Sirius Satellites in a Highly Elliptical Orbit (HEO) which currently come in to the vehicle at a higher angle to the horizon. As of April 2016 Sirius equipped head units will move to the XM Satellites constellation and will show the same location-based cutouts. SiriusXM is currently updating the repeater network to cover areas of low reception, but the general disadvantage of geostationary satellites can't be compensated completely. Buildings, hills, trees, highway sound blocking walls or any other obstacles might block the satellite signal coming from the south at a 32 degree elevation angle and might cause audio dropouts in absence of terrestrial repeaters. Reception quality decreases the further north you travel, as the angle of the incoming signal gets flatter. Adverse weather conditions will affect reception. Sirius XM will increase the amount of Sirius and XM repeaters gradually to improve situation in metropolitan areas. When investigating Satellite Radio cutouts or a temporary loss of reception: z Please compare to a similarly equipped vehicle. z Do not compare an XM equipped vehicle to a Sirius equipped vehicle. z Replace no parts Customers should direct all reception complaints to MINI Customer Relations department at 1-866275-6464 Customers must provide: z the exact location (street address or Latitude/Longitude) of dropout z weather conditions z time of day the drop occurred. Customer Relations will collect the locations of the XM reception c
M6101152018-12-10. Service bulletin. STEERING; EQUIPMENT:ELECTRICAL. This Service Information bulletin supersedes SI M61 01 15 dated February 2015. SUBJECT Noise from Steering Column Switch Center when Turning. The customer states that there is a grating or scraping noise when the steering wheel is turned. The noise comes from the area of the Steering Column Switch Center (SZL). When turning the steering wheel, the connection between the steering wheel and the SZL causes torsion stress, creating interference noise.
M5102162018-12-10. Service bulletin. EQUIPMENT ADAPTIVE/MOBILITY; ENGINE. SI M11 03 15 February 2016 Engine Technical Service This Service Information bulletin supersedes SI M11 03 15 dated April 2015. SUBJECT B38 Engine: Mixture Faults Stored in DME and Cylinder Head Cover Leaking Engine Oil.
M3601152018-12-10. Service bulletin. EQUIPMENT ADAPTIVE/MOBILITY; ENGINE. SI M11 03 15 February 2016 Engine Technical Service This Service Information bulletin supersedes SI M11 03 15 dated April 2015. SUBJECT B38 Engine: Mixture Faults Stored in DME and Cylinder Head Cover Leaking Engine Oil.
M3103152018-12-10. Service bulletin. ENGINE; EQUIPMENT ADAPTIVE/MOBILITY. SI M11 03 15 February 2016 Engine Technical Service This Service Information bulletin supersedes SI M11 03 15 dated April 2015. SUBJECT B38 Engine: Mixture Faults Stored in DME and Cylinder Head Cover Leaking Engine Oil.
M6502172018-12-10. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE; EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM). ?Technical Service ERRONEOUS CID MENU ENTRY- 'IMPORT JOURNEY'. ?Import Journey (USB)? submenu item in the Stored Journeys menu of the Navigation system is not working.
M8408182018-12-03. Service bulletin. EQUIPMENT:ELECTRICAL; EQUIPMENT. ?CONNECTEDDRIVE/MINI ASSIST SYSTEM DIAGNOSIS INFORMATION. ConnectedDrive/MINI Assist features are partially or completely inoperative. This Service Information bulletin is being published because vehicles are down for an extended period of time when researching system failures with ConnectedDrive or MINI Assist. This Service Information bulletin will assist you both in identifying the issue and providing technical support. CAUSE In order to assist with your ConnectedDrive issue as quickly as possible, a checklist has been developed which provides all the essential information to the support team. Any requested information that is missing from the checklist will delay the resolution of your issue.
M6103182018-11-26. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT:ELECTRICAL. THE DISPLAY GOES BLACK, THE ENGINE CAN BE SWITCHED OFF ONLY VIA THE EMERGENCY-OFF.. * On board computer and navigation system goes black or resets. * The engine can only be switched off by pressing the START/STOP button three times (Emergency STOP) * Various Check Control messages are displayed * At a minimum the following fault code is present: D91C86 - CAN message, status functional safety (ST_FSSY): Timeout-BDC * Additional fault messages may also be displayed Software error in the central gateway of the Body Domain Controller (BDC) control unit. Note: Parts replacement does NOT provide a solution!
M5403182018-11-26. Service bulletin. EQUIPMENT. RATTLE NOISE FROM SUNSHADE WHILE DRIVING. With either of the sunshades fully opened, there is a rattle noise present when driving over rough road surfaces The sunshade is contacting the roof liner trim.
M6505162018-11-26. Service bulletin. EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.; EQUIPMENT ADAPTIVE/MOBILITY; EQUIPMENT; EQUIPMENT:ELECTRICAL. SPORADIC FAILURE OF DIFFERENT AUDIO CHANNELS. Intermittently, different speakers may be inoperative during an entire drive cycle until the vehicle enters sleep mode and the vehicle is restarted. Shut-down of output circuit(s) from pressure variations caused by door shutting during diagnostic self-test. After unlocking the vehicle the Harman/Kardon (HK) Amplifier goes into a speaker self-test mode. If a door is slammed during this self-test vibrating the speaker cone, the HK amplifier may interpret the changing resistance of the speaker as a circuit failure. The HK Amplifier will then go into protection mode and turn off the output transistor(s) for the particular speaker(s) until the next selftest which is performed after the next sleep cycle.
M6401172018-11-26. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER. FOUL, MUSTY ODOR FROM HVAC: WET FOOTWELL CARPET This Service Information bulletin supersedes SI M64 01 16 dated September 2016 and SI M64 02 14 dated August 2016 are being combined to prevent duplication of effort and streamline the repair. The customer reports one, or both, of the following: ? Damp front foot-well carpet after long period of air conditioning use. ? A foul smell (musty, rotten, and vinegary) when the A/C is first turned on for a short time. The condensate drain hose is not properly draining the condensate from the vehicle. The micro-filter is absorbing condensate water from the evaporator housing.
M5102172018-11-26. Service bulletin. EQUIPMENT. ONSOLE STORAGE COMPARTMENT LID DOES NOT OPEN EASILY. Center console storage compartment lid requires too much force to open as demonstrated in accompanying video. tinyurl.com/mkphrma A. Sticky release mechanism. And/or B. Improper alignment.
M3201162018-11-05. Service bulletin. EQUIPMENT; STEERING. "EPS INTERMITTENT ASSIST FAILURE, FC 4823FA. The steering assistance fails after several, consecutive parking maneuvers or sustained hold at the end stop. EPS assistance starts functioning again after a few minutes. And, Fault code 4823FA (""EPS control unit internally overload, reduction in steering assistance"") is stored in the EPS control module. EPS software error (overloading protection function over sensitivity)."
M3103152018-11-05. Service bulletin. SUSPENSION:FRONT; EQUIPMENT ADAPTIVE/MOBILITY. CRACKING NOISE IN THE AREA OF THE FRONT AXLE SUPPORT/WISHBONE This Service Information bulletin supersedes SI 31 03 15 dated February 2016. Cracking noise coming from the area of the front axle when driving over rough road surfaces, railroad crossings and speed bumps. CAUSE Wishbone rubber mount.

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.