WenmarOpen by Wenmar Pro

Service bulletins for the 2024 Ford F-550

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

197 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

By topic

Bulletins, newest first
SSM 529802024-10-01. Service bulletin. UNKNOWN OR OTHER. Some of the following vehicles may exhibit one passive key that is unable to start the vehicle or activate the passive entry feature; however, all remote keyless entry (RKE) physical button functionality works correctly and the second passive key will have full/correct functionality (including being able to start the vehicle):
SSM 529672024-10-01. Service bulletin. UNKNOWN OR OTHER. Some of the following vehicles may exhibit a condition where the passive key will not program to the vehicles:
SSM 529352024-10-01. Service bulletin. UNKNOWN OR OTHER. Some 2023-2024 F-Super Duty vehicles equipped with a 6.8L or 7.3L engine may exhibit an illuminated malfunction indicator lamp (MIL) with various EVAP system diagnostic trouble codes (DTC) stored in the powertrain control module (PCM).
SSM 529252024-09-24. Service bulletin. UNKNOWN OR OTHER. Some 2020-2024 Explorer/Aviator/Corsair, 2021-2024 F-150/Bronco, 2023-2024 F-Super Duty, and 2024-2025 Nautilus vehicles may experience the overhead console sunglass bin cannot be locked in a closed position.
SSM 528522024-09-23. Service bulletin. UNKNOWN OR OTHER. 018-2024 F-150/F-Super Duty - Tailgate Step Binds/Will Not Open Or Opens/Pops Up While Driving
SSM 528612024-09-19. Service bulletin. UNKNOWN OR OTHER. 2024 F-Super Duty - 5th Wheel Hitch Installation Concerns
24-OTA ECG-24.2.5.6.2 SD2024-09-05. Over-the-air update. UNKNOWN OR OTHER. Quality Improvement include: -Update to Enhanced Central Gateway (ECG) module software to prevent battery draining when vehicle is parked. - Addresses Accessory Protocol Interface Module (SYNC) displaying update status as not completed. - Addresses potential vehicle no start after OTA update.
TSB 24-22592024-09-02. Service bulletin. UNKNOWN OR OTHER. Some 2024 F-Super Duty/F-150 vehicles may exhibit a concern where the vehicle's center display screen gets stuck in a reboot loop of the Ford logo and eventually goes black. This may be due to a concern with the software on the telematics control unit module (TCU). To correct the condition, follow the Service Procedure to reprogram the TCU and then perform a battery disconnect to make sure the accessory protocol interface module (APIM) receives the correct date from TCU.
TSB 24-22562024-09-02. Service bulletin. POWER TRAIN. Some 2023-2024 F-Super Duty vehicles built on or before 22-Jul-2024 and equipped with a 6.7L engine may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTC) P203B, P206B, and/or P2201:92 stored in the powertrain control module (PCM). This may be due to the software in the PCM. To correct the condition, follow the Service Procedure to reprogram the PCM using the latest software level of the Ford Diagnosis and Repair System (FDRS) scan tool.
24B27 S22024-08-07. Service bulletin. UNKNOWN OR OTHER. Certain 2020-2024 Super Duty and 2021-2025 Model Year Econoline Equipped With a 6.8L or 7.3L Gasoline Engine Powertrain Control Module (PCM) Software Update REASON FOR THIS SUPPLEMENT • Software Availability Update: Software is now available to repair 2021-2022 and 2025 Model Year Econoline vehicles. The service action has been updated accordingly. • Technical Information: IDS programing information has been added for 2021-2023 Model Year Econoline Vehicles.
DDM-24.19.3 Super Duty2024-08-06. Over-the-air update. UNKNOWN OR OTHER. Quality improvements include: - Robustness action to prevent false window bounce back alerts.
SSM 527302024-08-06. Service bulletin. UNKNOWN OR OTHER. Some 2023-2024 F-Super Duty and 2024 F-150/Nautilus vehicles may set DTC U211B:51 in the telematics control unit (TCU) module after a software update on the TCU is performed at dealer or via over the air (OTA) Update. The DTC U211B:51 in the TCU has no effect on vehicle functionality or connectivity. Replacement or reprogramming of the TCU will not resolve this condition. DTC U211B:51 should be ignored if no other DTCs are present in the TCU and no symptoms present. No further service action is required.
OTA 24-PU0107-VI-FX SD2024-07-04. Over-the-air update. STRUCTURE:BODY; UNKNOWN OR OTHER. Quality improvements include: -Walk away lock is implemented. Customer's vehicle will be locked automatically after sometime of walking away from vehicle.
OTA TCU-24.2.4.10 SD2024-07-04. Over-the-air update. UNKNOWN OR OTHER. Quality improvements include: -Robustness action to improve connectivity functionality of Google Automotive Services. -Pre theft alerts notification via Ford Pass is updated. -Robustness action to prevents TCU from providing bad Uinversal Time Clock Time/Date to Sync.
SSM 526562024-07-03. Service bulletin. UNKNOWN OR OTHER. Some 2021-2024 F-150/Bronco and 2023-2024 Escape/F-Super Duty vehicles built with SYNC 4 require a connected phone with Android Auto or Apple CarPlay active to enable voice interactions and use of the steering wheel voice control button. This is due to the affected vehicles not having built in voice interactions capability. Vehicles with built in voice interaction capability can be identified as also being equipped with the built in connected navigation feature which includes a navigation tab on the center display screen. Diagnostics should only be performed for voice interactions on vehicles equipped with built in voice interaction capability or with Android Auto or Apple CarPlay active.
SSM 526292024-07-03. Service bulletin. UNKNOWN OR OTHER. Some 2023-2024 F-Super Duty vehicles may have difficulty coming out of transport mode. This may be due to the vehicle entering temporary normal mode. This can be caused by the body control module (BCM) not registering 5 brake pedal presses prior to the hazard button being pressed 4 times.
24B27 S12024-07-02. Service bulletin. ENGINE. Certain 2020-2024 Super Duty and 2021-2025 Model Year Econoline Equipped With a 6.8L or 7.3L Gasoline Engine Powertrain Control Module (PCM) Software Update In affected vehicles, the Variable Displacement Oil Pump (VDOP) delivers oil to the engine at low pressure/capacity during idle conditions. Routine occurrences of prolonged idle time may result in excess wear to the engine camshaft lobes and valve tappet surfaces due to reduced lubrication. Over time, the engine may progressively run rough due to cylinder misfire. Additionally, customers may hear engine tapping noises and the Check Engine Light (CEL) may illuminate
TSB 24-21422024-06-12. Service bulletin. POWER TRAIN. This article supersedes TSB 23-2376 to update the Part List and the Service Procedure. Some 2022-2024 F-550 and F-600 F-Super Duty vehicles equipped with a 10R140 automatic transmission and 6.7L diesel engine may exhibit an illuminated powertrain malfunction (wrench) indicator with diagnostic trouble codes (DTCs) P2704 and P0771 stored in the transmission control module (TCM) with poor shift quality and over 5,000 miles (8,000 km) in service. This may be due to wear between the input shaft and the E clutch hub causing the input shaft O-rings to become damaged resulting in an open E clutch circuit. To correct this condition, follow the Service Procedure to replace the E clutch hub and input shaft O-rings.
SSM 526062024-06-10. Service bulletin. UNKNOWN OR OTHER. Some 2023-2024 F-Super Duty vehicles equipped with a keyed ignition may exhibit a "Vehicle May Not Start/Restart Service Now" message in the instrument panel cluster (IPC) with diagnostic trouble code (DTC) U300A:01 stored in the body control module (BCM). This may be due to an obstruction of the ignition key due to a mispositioned grommet around the ignition lock cylinder. To correct this condition, reseat the grommet. This may require full or partial removal of the center instrument panel trim which the grommet seats into. Refer to Workshop Manual (WSM), Section 501-12. Once complete, make sure there is no restriction to movement and retest. If the condition persists, refer to normal diagnostics in WSM, Section 211-05.
SSM 525972024-06-10. Service bulletin. ELECTRICAL SYSTEM. 2024 F-Super Duty vehicles equipped with a diesel engine and dual generators built on or after 02-May-2024 now utilize an accessory drive belt that is grooved on one side only. Prior to this build date, a dual groove accessory drive belt was used for this application. The accessory drive belt should not be considered a misbuild and not be changed to the dual-sided design.
SSM 525952024-06-10. Service bulletin. POWER TRAIN. When replacing the E clutch hub (7P211) on 2020-2024 F-Super Duty and 2024-2025 F-650/F-750 vehicles equipped with a 10R140 transmission, a new washer (7482) has been added and must be installed with the new updated E clutch hub. Refer to the Workshop Manual (WSM), Section 307-01B for proper installation of the washer. Refer to the parts catalog for the appropriate part numbers for the E clutch hub and the washer.
SSM 525902024-06-10. Service bulletin. SERVICE BRAKES. Some 2023-2024 F-Super Duty vehicles may require a replacement of the anti-lock brake system (ABS) module for various reasons. Replacing the ABS module may result in an error state with diagnostic trouble code (DTC) C0020:64 stored in the ABS module due to the Ford Diagnosis and Repair System (FDRS) software. If directed to replace the ABS module (2C219) during normal diagnostics in the Workshop Manual, replace the complete ABS module/hydraulic control unit (2C215) instead to avoid this error state. Monitor OASIS for updates.
24B272024-06-06. Service bulletin. POWER TRAIN; UNKNOWN OR OTHER. Certain 2023-2024 Super Duty and 2021-2025 Model Year Econoline Equipped With a 6.8L or 7.3L Gasoline Engine - Powertrain Control Module Software Update
SSM 525762024-06-06. Service bulletin. POWER TRAIN. 2023-2024 F-Super Duty/F-53 Motorhome Chassis/F-59 Commercial Stripped Chassis and 2023-2025 F-650/F-750/E-Series vehicles equipped with a Dana rear axle and built on or after 01-Nov-2022 may have orange/red RTV sealant used as the gasket on the differential housing cover. This does not indicate any previous repairs as it is used by Dana during assembly.
SSM 525742024-06-06. Service bulletin. UNKNOWN OR OTHER. Some vehicles equipped with SYNC4 may exhibit one or more of the following symptoms after all currently available accessory protocol interface module (APIM) software updates have been performed. - General system performance, stability, and intermittent system reboots. - Intermittent Wireless CarPlay or Android Auto function. - Phone related concerns with intermittent No Audio or Static. - Navigation/global positioning system (GPS) related concerns through CarPlay and Android Auto. - Alexa function consistency and stability. These symptoms may be due to the software in the APIM. Replacing the APIM will not resolve these symptoms for the customer. Before returning the vehicle to the customer, review the procedures within Workshop Manual, Section 415-00 and ensure the latest APIM software is installed. Refer to General Service Bulletin (GSB) 23-7146 for help determining the latest available level of software. IMPORTANT: some module software updates will only display as available on Ford Diagnosis and Repair System (FDRS) after prerequisite modules are updated. This may require the technician to update certain modules multiple times during the service visit, before the latest APIM software is accessible in FDRS. If symptoms continue after latest APIM software has been installed, inform customers that Ford is working on additional software enhancements which are expected to be delivered over-the-air (OTA) by Q4 2024 on F-150, F-150 Lightning, Mustang Mach-E, Mustang, Escape, Corsair, Expedition, Navigator, Bronco, Mustang, and 2023-2024 F-Super Duty. Software will update automatically if vehicle connectivity is enabled in the vehicle's settings. For all other vehicles with SYNC4, schedule a service visit for customers in October 2024, when the updated APIM software is expected to be available to dealers. Monitor OASIS for additional information.

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.