WenmarOpen by Wenmar Pro

Service bulletins for the 2016 Ram 2500

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

463 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

By topic

Only bulletins with component: Suspension are shown. Show all

Bulletins, newest first
91002682024-01-16. Service bulletin. SUSPENSION; STEERING. Steering Drag Link If drag link had been welded due to V06 recall repair and there is an alignment concern, prior to drag link replacement ensure that the welded draglink toe setting procedure has been followed first. ~ ~ Service Library: 02 - Front Suspension / Wheel Alignment / Standard Procedure / TOE SETTING PROCEDURE FOR TRUCKS WITH DRAG LINK RECALL WELD ~
91002292023-10-30. Service bulletin. SUSPENSION. LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect.
03-001-202020-06-22. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT; SUSPENSION. Rear Axle Vibration, Shudder Or Chatter This bulletin involves changing the rear axle lube to possibly address a chatter, shudder or vibration. The customer may describe the following: A chatter, shudder, or vibration from the rear axle during turns. This may happen more as the vehicle ages, especially if the vehicle is used extensively for towing or hauling heavy loads. The cause of the concern may be due to degradation of the rear axle fluid. It is very important to follow the routine maintenance schedules on these vehicles when it comes to changing the rear axlefluid if the vehicle is used primarily for towing or hauling heavy loads. If you experience a vehicle with the above condition, please perform the proper maintenance procedures for the rear axle and replace the fluid first before replacing any hardware components.This service bulletin is only applicable to vehicles that have no history of an axle fluid replacement. If the vehicle usage includes police, taxi, fleet, off-road or frequent trailer towing, regular axle fluid changes are required every2 years or 20,000 miles (whichever comes first) per the Maintenance Schedule in the vehicle Owner's Manual.
S20030000022020-05-26. Service bulletin. SUSPENSION. Chatter, Shudder, or Vibration From Rear Axle During Turns
S20030000022020-05-18. Service bulletin. SUSPENSION. Chatter, Shudder, or Vibration From Rear Axle During Turns
S20030000022020-04-27. Service bulletin. SUSPENSION. Chatter, Shudder, or Vibration From Rear Axle During Turns
90040222020-01-21. Service bulletin. SUSPENSION. Air Suspension Components Star Parts Catalog has been updated to show individual service parts for the compressor assembly. This will allow service technicians to repair the root cause without over repairing the system. Replace only the part deemed failed by the diagnostics performed. Individual parts include: - Compressor - Valve block - Individual hoses - Temp sensor - Shield - Air line clips NOTE: in most situations when a new compressor is needed, the compressor as a separate part is the correct repair, and the assembly would not be required.
08-046-162018-06-11. Service bulletin. SUSPENSION. Flash: Air Suspension Control Module (ASCM) System Enhancements This Bulletin involves updating the (ASCM) software. A customer may describe the following: · **Cluster stays awake after ignition is turned off for 10 minutes or more.** · False message Battery Voltage Low - Start Engine to Change Ride Height which appears in the Electronic Vehicle Information Center (EVIC). This condition may happen when the vehicle is first started and trying to move the suspension from trailer ride height to normal ride height.
08-046-162016-07-14. Service bulletin. SUSPENSION:REAR:SPRINGS:AIR SUSPENSION SYSTEM; ELECTRICAL SYSTEM:SOFTWARE. SUBJECT: Flash: Air Suspension Control Module (ASCM) System Enhancements SYMPTOM/CONDITION: A customer may describe the following: · **Cluster stays awake after ignition is turned off for 10 minutes or more.** · False message “Battery Voltage Low - Start Engine to Change Ride Height” which appears in the Electronic Vehicle Information Center (EVIC). This condition may happen when the vehicle is first started and trying to move the suspension from trailer ride height to normal ride height.
08-046-162016-07-07. Service bulletin. SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM; ELECTRICAL SYSTEM:SOFTWARE. SUBJECT: Flash: Air Suspension Control Module (ASCM) System Enhancements OVERVIEW: This Bulletin involves updating the (ASCM) software. SYMPTOM/CONDITION: A customer may describe the following: • **Cluster stays awake after ignition is turned off for 10 minutes or more.** • False message “Battery Voltage Low - Start Engine to Change Ride Height” which appears in the Electronic Vehicle Information Center (EVIC). This condition may happen when the vehicle is first started and trying to move the suspension from trailer ride height to normal ride height.

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.