WenmarOpen by Wenmar Pro

Recalls that may apply to the 2024 Peterbilt 567

A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.

By component

United States: NHTSA, as of 2026-10-19
25V4360002025-06-26. EXTERIOR LIGHTING:LIGHTING CONTROL MODULE:SOFTWARE. PACCAR Incorporated (PACCAR) is recalling certain 2024-2026 Kenworth T480, T680, T880, W990, Peterbilt 520, 536, 537, 548, 567, 579, 589, 2025 Kenworth T180, Peterbilt 535, 2025-2026 Kenworth T280, T380 and L770 vehicles. The tail brake light, upper and lower beam headlights, reverse light, and turn signal may not illuminate as intended. In addition, the lift axles, if lowered, may revert to a raised position, or oscillate up and down when the signal warning lights are activated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment." Built from 2023-04-10.
25V3530002025-05-28. SERVICE BRAKES, AIR:ANTILOCK:MODULATOR. PACCAR Incorporated (PACCAR) is recalling certain 2024 Peterbilt 367, 2026 Peterbilt 548, 589, and 2024-2026 Peterbilt 567 trucks. The rear brake piping assembly may have insufficient clearance, which can result in a loss of service brakes or anti-lock brake function. Built 2025-02-25 to 2025-04-03.
24V9150002024-12-09. ELECTRICAL SYSTEM:SOFTWARE; SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE. PACCAR Incorporated (PACCAR) is recalling certain 2021-2025 Peterbilt and Kenworth vehicles, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Please see the recall report for a complete list of models. Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop functioning. Built 2020-04-06 to 2024-12-04.
24V9080002024-12-03. STEERING:LINKAGES:KNUCKLE:SPINDLE:ARM; STEERING:LINKAGES:TIE ROD ASSEMBLY. PACCAR Incorporated (PACCAR) is recalling certain 2024 Peterbilt 367, 389, 548, Kenworth T480, T800, 2024-2025 Peterbilt 520, 567 and Kenworth T880 vehicles with PACCAR 20k steer axles. The steering arm and/or tie rod bracket fasteners may fail, resulting in a loss of steering control. Built 2023-03-13 to 2024-02-05.
24V1900002024-03-20. POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT. PACCAR Incorporated (PACCAR) is recalling certain 2021-2024 Peterbilt 365, 367, 389, 535, 536, 537, 548, 567, 579, and 2021-2025 Kenworth T180, T280, T380, T480, T680, T880 and W990 trucks. The right-hand gear shifter stalk connectors may have been improperly crimped, resulting in a loss of communication.
24V0440002024-01-25. STEERING. PACCAR Incorporated (PACCAR) is recalling certain 2024-2025 Kenworth T280, T380, T480, T680, T880, L770, W990, and 2024-2025 Peterbilt 389, 520, 535, 536, 537, 548, 567, 579, 589 trucks. The steering gear assemblies may have been assembled incorrectly with fewer recirculating balls than are required, which may result in a loss of steering control.
24V0430002024-01-25. STEERING:LINKAGES:KNUCKLE:SPINDLE:ARM. PACCAR Incorporated (PACCAR) is recalling certain 2024 Peterbilt 367, 389, 520, 567, and Kenworth T800, T880, W900, and W990 trucks. The bearing journals may not be fully seated in the steering knuckle assemblies, preventing the proper installation of the wheel end hub assemblies.
23V6530002023-09-27. FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY. PACCAR Incorporated (PACCAR) is recalling certain 2021-2024 Peterbilt 579 and 567 trucks. The U-bolts that attach the air tank to the chassis may contact the fuel tank and over time, wear a hole in the tank.
Canada: Transport Canada, as of 2026-10-19
20247322024-12-03. Steering. Issue: On certain trucks, the bolts for the steering arm and/or tie rods may not have been tightened properly. As a result, the bolts could loosen and separate. If this happens, there could be a loss of steering control. Note: This recall only affects certain trucks equipped with 20k steer axles. Safety Risk: A loss of steering control could create the risk of a crash. Corrective Actions: PACCAR will notify owners by mail and advise you to take your truck to a dealership to replace the affected bolts and tighten them properly.
20241612024-03-08. Powertrain. Issue: On certain trucks, the wiring in the right-hand shift stalk may not be properly connected. As a result, you may not be able to shift the transmission back into gear after coming to a stop. Safety Risk: A loss of power to the wheels could increase the risk of a crash. Corrective Actions: PACCAR will notify owners by mail and advise you to take your truck to a dealership to inspect and, if necessary, replace the right-hand shift stalk assembly.
20240382024-01-25. Suspension. Issue: On a small number of trucks equipped with a Hendrickson Composilite steerable lift axle, the steering knuckles may not have been assembled properly during production. As a result, oil could leak from the wheel hub and cause the axle spindles to become loose and separate. Safety Risk: Parts that separate from the truck could create a road hazard for others and increase the risk of a crash. Corrective Actions: Paccar will notify owners by mail and advise you to take your truck to a dealership to inspect and, if necessary, replace the steering knuckles assemblies.
20240362024-01-25. Steering. Issue: On certain trucks, the steering gear may not have been assembled correctly. As a result, the steering gear could break and cause a loss of steering. Safety Risk: A loss of steering control could create the risk of a crash. Corrective Actions: PACCAR will notify owners by mail and instruct you to take your truck to a dealership to inspect the serial number on the steering gear and, if necessary, replace it.
20235302023-09-27. Fuel System. Issue: On certain trucks that have the air tank mounted behind the fuel tank, the U-bolts that attach the air tank to the side of the frame may be too long. As a result, a bolt could damage the fuel tank and create a fuel leak. Safety Risk: A fuel leak can create the risk of a fire. Corrective Actions: PACCAR will notify owners by mail and advise you to take your truck to a dealership to inspect the clearance of the U-bolts that attach the air tank to the side of the frame. If the bolts are too long, the dealer will cut off the excess length. If the fuel tank has damage from contacting a bolt, it will be replaced.

A campaign lists a year, a make and a model, and often only some of the vehicles built. A list with nothing on it is not a clearance either. The lookups below check one VIN.

Check one vehicle officially

Contains information licensed under the Open Government Licence – Canada.