WenmarOpen by Wenmar Pro

Service bulletins for the 2016 Nissan Titan

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

304 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

By topic

Bulletins, newest first
PC731 2016-17 TI2020-05-06. Service bulletin. ELECTRICAL SYSTEM; FUEL SYSTEM, DIESEL; ENGINE AND ENGINE COOLING:ENGINE:DIESEL. On-Board Diagnostic (OBD) Electronic Control Unit (ECU) Voluntary Emission Recall Campaign ***** Campaign Summary ***** Nissan is conducting a Voluntary Emissions Recall Campaign on 27,085 certain MY2016-17 Titan Diesel vehicles identified in Service Comm to inspect and, if necessary, reprogram the Electronic Control Unit (ECU) with countermeasure software. Nissan has determined that the subject vehicles were manufactured with an On-Board Diagnostic (OBD) calibration that may not allow the exhaust gas sensor monitors to run as intended. If an affected vehicle is not repaired, the exhaust gas sensor monitors may not run as frequently as required by regulation to determine if the sensor is performing as intended. This issue has no effect on vehicle safety, fuel economy, drivability, or performance. ***** What Dealers Should Do**** 1. Verify campaign applicability using Service Comm or DBS National Service History – Open Campaign I.D. PC731. 2. Dealers should use NTB20-030 to correct any vehicles subject to this campaign. 3. Once repaired, dealers should submit the claim, using the claims coding provided, and release the vehicle.
NTB20-0302020-05-05. Service bulletin. ENGINE AND ENGINE COOLING. VOLUNTARY EMISSIONS RECALL CAMPAIGN 2016-2017 TITAN XD WITH DIESEL ENGINE; ENGINE CONTROL MODULE INTRODUCTION Nissan is conducting this voluntary emissions recall campaign on certain specific model year 2016-2017 Titan XD vehicles equipped with a diesel engine. The Engine Control Module (ECM) will be inspected, and reprogrammed if it applies. This service will be performed at no charge to the customer for parts or labor. IDENTIFICATION NUMBER Nissan has assigned identification number PC731 to this campaign. This number must appear on all communication and documentation of any nature dealing with this campaign. DEALER RESPONSIBILITY It is the dealer’s responsibility to check Service COMM or Dealer Business Systems (DBS) National Service History for the campaign status on each vehicle falling within the range of this voluntary emissions recall which for any reason enters the service department. This includes vehicles purchased from private parties or presented by transient (tourist) owners and vehicles in a dealer’s inventory. Federal law requires that new vehicles in dealer inventory which are the subject of a emissions recall must be corrected prior to sale. Failure to do so can result in civil penalties and/or fines by the Environmental Protection Agency. While federal law applies only to new vehicles, Nissan strongly encourages dealers to correct any used vehicles in their inventory before they are retailed.
NTB19-011a2020-03-07. Service bulletin. ENGINE. 2016 – 2019 TITAN XD; MIL ON WITH DTC P2048 STORED This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
NTB15-049t2020-03-07. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT ADAPTIVE/MOBILITY; EQUIPMENT; EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL. TELEMATICS SERVICE INFORMATION This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
NTB19-004a2019-12-06. Service bulletin. SEATS; ELECTRICAL SYSTEM. 2015-2019 MURANO AND 2016-2019 TITAN; CLIMATE CONTROLLED SEAT INOPERATIVE This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
NTB19-0712019-10-09. Service bulletin. ELECTRICAL SYSTEM; AIR BAGS. DTC B00A0-00 STORED IF YOU CONFIRM DTC B00A0-00 (OCCUPANT DETECTION SENSOR UNIT) is stored And OCS zero point reset cannot be performed (continued on the next page) And The following screen displays: ACTION 1. Check the Occupant Classification System (OCS) control unit using the ODS Analysis tool software. • Refer to SERVICE PROCEDURE on page 5. HINT: “OCS” may also be referred to as “ODS”. 2. Perform “75-zero RESET”.
NTB14-012e2019-10-09. Service bulletin. ENGINE AND ENGINE COOLING. REMOTE ENGINE START NOT WORKING This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
NTB19-026a2019-09-10. Service bulletin. FUEL SYSTEM, DIESEL. 2016 – 2018 TITAN XD; STATIC DISCHARGE FROM FUEL LINE This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
NTB19-0262019-08-19. Service bulletin. FUEL SYSTEM, GASOLINE. 2016 - 2018 TITAN XD; STATIC DISCHARGE FROM FUEL LINE IF YOU CONFIRM There is a static discharge from the fuel line causing a click or pop noise. NOTE: Concern is more likely to: - Be heard from under the center of vehicle. - Occur more often on dry days. - Occur at regular intervals about every 30 seconds to 1 minute. ACTION Install the tether assembly as described in the SERVICE PROCEDURE starting on the next page.
NTB19-0492019-07-22. Service bulletin. FUEL SYSTEM, GASOLINE. 2016-2019 TITAN/TITAN XD; WHISTLE NOISE WHEN REFUELING This bulletin applies only to vehicles equipped with a gasoline V8 engine. IF YOU CONFIRM A whistle noise is heard when refueling the vehicle. ACTION Replace the fuel tank with the new one listed in the PARTS INFORMATION section of this bulletin.
NTB15-049s2019-07-22. Service bulletin. EQUIPMENT. TELEMATICS SERVICE INFORMATION This bulletin applies only to vehicles equipped with a Telematics Communication Unit (TCU). This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
NTB17-053a2019-06-24. Service bulletin. ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN. 2016-2017 TITAN/TITAN XD; FAN COUPLING TICK / KNOCK IN COLD AMBIENT TEMPERATURES (32°F (0°C) OR BELOW) This bulletin has been amended. See AMENDMENT HISTORY on the last page. Discard all previous versions of this bulletin.
NTB19-0372019-05-20. Service bulletin. ENGINE. 2016-2019 TITAN; MIL ON WITH DTC P0448 AND WATER IN EVAP FILTER IF YOU CONFIRM The MIL is ON with DTC P0448 (EVAP canister vent control valve close) stored in the ECM and water is found in the EVAP filter, canister, or vent control valve ACTION Remove and replace the: - Fuel filler tube. - EVAP filter. - EVAP canister. - EVAP vent control valve. - EVAP pressure sensor. IMPORTANT: Before any parts are removed from the vehicle, note the EVAP filter orientation and hose routing (take a photo). Hose routing and EVAP filter orientation is critical and varies depending on production date.
NTB17-010a2019-04-22. Service bulletin. EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL; EQUIPMENT ADAPTIVE/MOBILITY. 2016 ? 2019 TITAN AND TITAN XD; STEP RAIL END CAP CHROME TRIM AVAILABLE AS SEPARATE PART This bulletin applies only to Crew Cab models. This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
NTB16-037e2019-03-25. Service bulletin. ENGINE. 2016 TITAN XD; MIL ON WITH ENGINE DTCs STORED AND/OR IDLE FLUCTUATION This bulletin applies only to vehicles equipped with a Cummins 5.0L V8 Diesel engine. This bulletin has been amended. See Amendment History on the last page. Please discard previous versions of this bulletin.
NTB19-0132019-03-18. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER. 2016-2018 TITAN/TITAN XD WITH AUTO A/C; VAST TEMPERATURE DIFFERENCE BETWEEN 61°F & 62°F SETTINGS This bulletin applies only to vehicles equipped with auto A/C. IF YOU CONFIRM The customer states there is a significant difference in vent temperature between auto A/C settings of 61°F and 62°F. ACTION 1. Check the A/C auto amp?s current part number. 2. If the current part number matches one listed in Table A (see page 6), reprogram the A/C auto amp.
NTB19-0112019-03-18. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM; FUEL SYSTEM, GASOLINE. 2016 ? 2018 TITAN XD; MIL ON WITH DTC P2048 STORED This bulletin applies only to vehicles equipped with a Cummins 5.0L V8 Diesel engine. IF YOU CONFIRM The MIL is ON and DTC P2048 (REDUCTANT INJECTION VALVE CIRCUIT LOW 1/1) is stored. ACTION Reprogram the ECM per the SERVICE PROCEDURE in this bulletin. - Refer to SERVICE PROCEDURE on the next page to confirm if reprogramming is needed. - Save Computer Data with CONSULT-III plus (C-III plus). - If this bulletin applies, continue with ECM Reprogramming procedure. - Write Saved Data with CONSULT-III plus.
NTB19-0172019-03-18. Service bulletin. EQUIPMENT. 2016-2019 TITAN XD DIESEL; MIL ON WITH DTC P0299 FOR BOOST PRESSURE This bulletin applies only to vehicles equipped with a Cummins 5.0L V8 Diesel engine. IF YOU CONFIRM The MIL is ON with DTC P0299 (BOOST PRESSURE) stored And - The engine air cleaner box and air filter: - Are free from debris - Are not damaged or have any restrictions - The engine charge air cooler tube clamps are tight and tubes are free from leaks at the following locations: - The turbocharger compressor outlet - The charge air cooler inlet - The charge air cooler outlet - The intake manifold inlet - The Boost Pressure Absolute is within +/- 1.5 PSI of ambient air pressure with ignition ON and engine OFF (observed in Data Monitor). ACTION Refer to Repair Overview on page 2.
NTB19-0102019-02-19. Service bulletin. ENGINE; FUEL SYSTEM, DIESEL. 2016 - 2018 TITAN XD; DEF SYSTEM PARTS AVAILABILITY This bulletin applies only to vehicles equipped with a Cummins 5.0L V8 diesel engine. SERVICE INFORMATION When diagnosing any Diesel Exhaust Fluid (DEF) system component, refer to Table A below. These parts are now available separately. Do not replace the entire DEF tank assembly if the required part is shown in Table A.
NTB19-0072019-02-19. Service bulletin. FUEL SYSTEM, DIESEL; ENGINE. 2016-2019 TITAN XD DIESEL; FUEL FILTER MAINTENANCE This bulletin applies only to vehicles equipped with a Cummins 5.0L V8 diesel engine. SERVICE INFORMATION The Stage 1 and Stage 2 fuel filters must be replaced every 10,000 miles or a restriction may develop. DTCs P008A, P00C6, P0087 and/or a whining noise from the Stage 1 Fuel Filter Module may be present due to a restriction in the Stage 1 and/or Stage 2 fuel filters. NOTE: An inoperable or whining Stage 1 Fuel Filter Module that has not had the fuel filters regularly replaced as per the Owner?s Manual Maintenance schedule is not a warrantable repair. Before proceeding with any fuel system restriction diagnosis: - Confirm that both of the vehicle?s Stage 1 and Stage 2 fuel filters have been replaced at the correct service intervals, as per the Owner?s Manual Maintenance schedule. IMPORTANT: Warranty claim submissions for a Stage 1 Fuel Filter module will be denied if the Stage 1 and/or Stage 2 fuel filters have not been replaced per the Owner's Manual maintenance schedule.
NTB19-0052019-02-19. Service bulletin. SEATS. 2016-2018 TITAN/TITAN XD; VISIBLE VIBRATION IN FRONT PASSENGER SEAT AT 60-80 MPH WHEN UNOCCUPIED IF YOU CONFIRM The front passenger seat has a visible vibration/movement that only occurs at speeds between 60 mph and 80 mph And Vibration/movement can be reproduced while driving on smooth roads (vibration/movement not caused by road surface) And All tires are in balance and road force vibration is within specifications (see NTB11-062). ACTION Replace the front passenger seatback assembly and front passenger headrest. IMPORTANT: The purpose of ACTION (above) is to give you a quick idea of the work you will be performing. You MUST closely follow the entire SERVICE PROCEDURE as it contains information that is essential to successfully completing this repair.
NTB19-0042019-02-19. Service bulletin. SEATS. 2015-2019 MURANO AND 2016-2019 TITAN; CLIMATE CONTROLLED SEAT INOPERATIVE IF YOU CONFIRM The driver or passenger side climate controlled seat: - Heating and cooling features do not operate And - The harness connector or control unit of the climate controlled seat appears as shown in Figure 3 or Figure 5. ACTION Perform the following to the affected seat: A. Replace the climate controlled seat control unit. B. Drill a hole for the new harness clip. C. Replace the harness connector of the climate controlled seat control unit. IMPORTANT: The purpose of ACTION (above) is to give you a quick idea of the work you will be performing. You MUST closely follow the entire SERVICE PROCEDURE as it contains information that is essential to successfully completing this repair.
NTB19-0032019-02-19. Service bulletin. FUEL SYSTEM, DIESEL. 2016-2017 TITAN XD DIESEL; HIGH PRESSURE FUEL INJECTOR SUPPLY LINE TORQUE CHANGE This bulletin applies only to vehicles equipped with a Cummins 5.0L V8 diesel engine. SERVICE INFORMATION For the Applied Vehicles, the high pressure fuel injector supply line nut torque specifiction listed in the Electronic Service Manual (ESM) has been revised. Until the ESMs are updated, use the torque specification shown below.
NTB17-082b2019-02-19. Service bulletin. ENGINE AND ENGINE COOLING. NISSAN; DTC P0456 CAUSED BY EVAP LEAK AT VENT CONTROL VALVE O-RING This bulletin does NOT apply to LEAF vehicles and Titan XD vehicles with V8 diesel engine. This bulletin has been amended. See Amendment History on the last page. Please discard previous versions of this bulletin.
NTB15-049r2019-02-19. Service bulletin. EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM); ELECTRICAL SYSTEM:SOFTWARE. TELEMATICS SERVICE INFORMATION This bulletin applies only to vehicles equipped with a Telematics Communication Unit (TCU). This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.