WenmarOpen by Wenmar Pro

Service bulletins for the 2025 Mazda CX-90

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

296 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

By topic

Bulletins, newest first
SA-074-242024-11-04. Service bulletin. POWER TRAIN. Some customers may experience a grunt or grind noise when the transmission shifts from 1st gear to 2nd gear. The grunt-type noise is produced during the 2nd gear engagement. This issue will not affect the driveability or reliability of the vehicle. The vehicle is safe to drive. It is OK to release the vehicle back to the customer.
SA-069-242024-11-04. Service bulletin. STRUCTURE:BODY. Some vehicles may exhibit poor hands-free liftgate operation after a Mazda genuine trailer tow hitch accessory installation. IMPORTANT: When a Mazda genuine trailer tow hitch is installed on a CX-90 equipped with hands-free liftgate function, the sensing area is reduced due to the mechanical structure of the hitch. The hands-free liftgate’s optimal sensing area below the rear bumper is shown in green boxes in the image below. Since the left side of the hitch has a 7-pin connector socket, the right side is the most ideal for hands-free operation. For safety, be extra careful performing the kicking motion around the hitch.
SA-040-24a2024-11-04. Service bulletin. ENGINE; ELECTRICAL SYSTEM. Some customer may experience any of the following: Multiple Warning Lights On • Infotainment center display blank • Engine no start unless the key transmitter is placed near the start button • Interior lights do not illuminate • DTC P2507:00 - PCM, PCM POWER SYSTEM: (LOW INPUT) stored. • DTC U0156:00 - PCM, CAN communication system, Communication error with CMU (Connectivity Master Unit). • This may be caused by Fuse F1 not fully seated (poor terminal tension) or a poor ground connection at the front harness connector G03.
SA-016-24c2024-11-04. Service bulletin. SERVICE BRAKES. Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. If you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur, and to better assist the customer in resolving their specific brake concern.
SA-002-24a2024-11-04. Service bulletin. POWER TRAIN. Due to a manufacturing change, the CX-70/CX-90 transmission has undergone a transmission part design change when replacing the transmission assembly. Old design originally required a coolant line running to the top of the bell housing, the new design has omitted the hole and need for the coolant line. The new/superseded design can be used in place of the old/original design and the coolant hose is no longer needed to be used.
16-003-242024-11-03. Service bulletin. UNKNOWN OR OTHER. Mazda Connect Infotainment System. Some vehicles may experience the symptoms mentioned below, which can be fixed with the latest software update (Version 7000C0A-NA11_10014). NOTE: If current version is not 7000C0A-NA11_*****, this TSB is not applicable. NOTE: iPod, iPhone, and Apple CarPlayTM are registered trademarks of Apple Inc. Android and Android AutoTM are registered trademarks of Google LLC. The Bluetooth® word mark and logos are registered trademarks owned by Bluetooth SIG, Inc.
09-046-242024-11-03. Service bulletin. STRUCTURE:BODY. Some vehicles may experience stains appearing on the hood, roof and/or trunk of the vehicle. This concern is most likely to be found in a cold weather areas just after the RAPGARD is removed at PDI. This may be caused by moisture which has been trapped and condensed between the paint and the RAPGARD. These types of stains can be removed with a heat gun or an infrared drier. If you encounter this concern during PDI, use a heat gun or an infrared drier to apply heat to the affected area to remove the stain(s).
SA-009-24d2024-10-05. Service bulletin. ELECTRICAL SYSTEM. Mazda Connect Services - Frequently Asked Questions (FAQ)
SA-009-24c2024-10-05. Service bulletin. ELECTRICAL SYSTEM. Mazda Connect Services - Frequently Asked Questions (FAQ)
SA-070-242024-10-05. Service bulletin. ELECTRICAL SYSTEM. When the Telematics Control Unit (TCU) replacement is necessary due to a failure, use MDARS to activate the new TCU after replacement. Use the information in this service alert to initialize the new TCU until the procedure on MGSS is updated.
SA-068-242024-10-05. Service bulletin. UNKNOWN OR OTHER. Some customers may complain about scratches on the instrument cluster lens.
SA-067-242024-10-05. Service bulletin. ELECTRICAL SYSTEM. Qi Wireless Charger symptom troubleshooting.
SA-065-242024-10-05. Service bulletin. ELECTRICAL SYSTEM. Some customers may complain about the Active Driving Display not displaying turn by turn (TBT) travel direction or navigation information.
SA-064-242024-10-05. Service bulletin. ELECTRICAL SYSTEM; UNKNOWN OR OTHER. Some customers may experience a Connected Vehicle failure. The MyMazda App may display an Error Code. This document provides Error Code description and recovery information to assist with repairs.
SA-017-24b2024-10-05. Service bulletin. ELECTRICAL SYSTEM; ENGINE; EXTERIOR LIGHTING. Some customers may complain about any of the following: 1. Infotainment Center Display does not provide the Authorization Code (OTP) during the MyMazda App Connected Vehicle enrollment. 2. Remote function(s) inoperative. Engine Start / Stop Door Lock / Unlock Lights ON / OFF Climate Control
SA-006-24c2024-10-05. Service bulletin. UNKNOWN OR OTHER; ELECTRICAL SYSTEM. Customers having MAZDA CONNECT concerns should have their vehicle repaired using the following repair procedure.
SA-007-24b2024-10-04. Service bulletin. SERVICE BRAKES. This information will give you the necessary knowledge to respond to customers concerns of Smart Brake Support (SBS) unintended braking. By educating the customer on the system operation, it should reduce their anxiety or distrust of the vehicle.
SA-071-242024-10-04. Service bulletin. ENGINE; ELECTRICAL SYSTEM. After an HV inverter replacement, there is no instruction in the WSM to perform Initial Learning of the Electric Motor Speed Sensor. This is required after replacing the inverter or electric motor. As a result, when attempting to start the vehicle, the Internal combustion (ICE) engine will start and then stop with DTC P0C17 stored. If this DTC is set, refer to P0C17:00 [SGC2/DMCM (e-SKYACTIV PHEV)] in the troubleshooting manual. NOTE: When attempting to complete the Learn of Electric Motor Speed Sensor with MDARS, it will be unsuccessful until the vehicle is shut off and left undisturbed for 1-2 hours. Make sure the 12V battery is fully charged and the EV battery is charged, then connect the battery and wait a minimum of 1-2 hrs with the ignition OFF before proceeding directly to the relearn procedure. DO NOT start the engine until directed to do so in the relearn procedure.
SA-069-242024-10-04. Service bulletin. STRUCTURE:BODY. Some vehicles may exhibit poor hands-free liftgate operation after a Mazda genuine trailer tow hitch accessory installation. IMPORTANT: When a Mazda genuine trailer tow hitch is installed on a CX-90 equipped with hands-free liftgate function, the sensing area is reduced due to the mechanical structure of the hitch. The hands-free liftgate’s optimal sensing area below the rear bumper is shown in green boxes in the image below. Since the left side of the hitch has a 7-pin connector socket, the right side is the most ideal for hands-free operation. For safety, be extra careful performing the kicking motion around the hitch.
SA-066-242024-10-04. Service bulletin. ELECTRICAL SYSTEM; ENGINE. Some customers may complain that the MyMazda App Remote Engine Start function fails. MX-30 and PHEV vehicles do not have a Remote Engine Start function; instead, they are equipped with the following remote functions: Start / Stop Charge Climate On / Off
SA-061-24a2024-10-04. Service bulletin. VISIBILITY/WIPER. Some customers may complain about a low washer fluid level warning message even though a visual inspection of the washer fluid tank looks like it still has a fair amount of fluid in it. With the CX-90 and CX-70 introduction of the front-engine and rear-wheel-drive layout, the washer tank shape was changed from a vertical to a horizontal type. This makes it look like there is still enough liquid left if viewed from the spout when the warning light comes on.
SA-040-242024-10-04. Service bulletin. ENGINE; ELECTRICAL SYSTEM. Some customer may experience any of the following: Multiple Warning Lights On • Infotainment center display blank • Engine no start unless the key transmitter is placed near the start button • Interior lights do not illuminate • DTC P2507:00 - PCM, PCM POWER SYSTEM: (LOW INPUT) stored. • DTC U0156:00 - PCM, CAN communication system, Communication error with CMU (Connectivity Master Unit).
SA-020-24b2024-10-04. Service bulletin. ELECTRICAL SYSTEM; LANE DEPARTURE: WARNING; ENGINE; LANE DEPARTURE: BLIND SPOT DETECTION; FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL. The CX-70 and CX-90 have new and revised features that are different from previous models and may be difficult to understand. This Service Alert provides valuable information to support potential dealer and customer concerns.
SA-062-242024-09-04. Service bulletin. ELECTRICAL SYSTEM. For improvement of electrical diagnosis, the SKYACTIV® Wiring Terminal Test Kits has been delivered all the dealers. The terminal test kit enables you: To check pin fit drag of all PCM terminals used in SKYACTIV® vehicles and compare suspect terminal drag with a known good terminal. To measure the voltage/resistance avoiding any terminal damage.
SA-060-242024-09-04. Service bulletin. STEERING. Before judging a steering wheel as having premature wear or a defect, first clean the steering wheel as explained in the repair information. Some vehicles may have steering wheel stains caused by chemicals such as hand lotions.

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.