Service bulletins for the 2022 Lincoln Aviator
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
201 on file from NHTSA, as of 2026-10-19.
By type
By component
By trouble code
| SSM 51032 | 2022-08-22. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION; ENGINE AND ENGINE COOLING. Some 2020-2022 Explorer/Aviator vehicles may exhibit automatic transmission fluid (ATF) contamination in the engine cooling system due to the transmission cooler. If the cooling system becomes contaminated with ATF, the system must be flushed clear of the contamination after the source of the contamination has been repaired. It is generally not necessary to replace the following components due to ATF contamination in the cooling system: radiator, heater core, de-gas bottle, water pump, auxiliary water pump, coolant control valves, temperature sensors, thermostat, turbocharger, heat exchangers, tubes, gaskets/O-rings/seals (unless removed), or rubber coolant hoses (unless swollen). |
|---|---|
| SSM 50975 | 2022-08-02. Service bulletin. ELECTRICAL SYSTEM. Some 2017-2022 Ford/Lincoln customers may experience a notification in the FordPass®/LincolnWay® app indicating Vehicle Has Entered Deep Sleep Mode. This occurs when the vehicle has not been started for 14 consecutive days, battery voltage is at/below 9.5 volts or the body control module (BCM) 12 volt battery state of charge (SOC) drops below 50%. A warning may also set if the telematic control unit (TCU) has received an over the air update. The TCU powers down all communication when in this mode and app features are disabled. Manually start the vehicle to wake if from mode. More information is located in the app under: Account > Help > search 'Deep Sleep' in the entry box. If the condition remains, check the BCM 12v SOC. If the SOC does not change after charging the battery or after BMS reset is performed, continue with normal battery and/or BMS sensor diagnostics. |
| SSM 50967 | 2022-08-02. Service bulletin. LATCHES/LOCKS/LINKAGES:DOORS:LATCH. Some 2020-2022 Aviator vehicles may exhibit a door ajar or door fault warning message present in the message center with diagnostic trouble codes (DTCs) B1175:19, B1176:19, B11C0:19 and/or B11C1:19 present in door latch control module E (DCME), door latch control module F (DCMF), door latch control module G (DCMG) and/or door latch control module H (DCMH). This may be due to low battery voltage and DTC thresholds being too low and not a fault in the door latch assembly. To correct the condition, reprogram and re-configure the the affected module using the latest level of the Ford Diagnosis and Repair System (FDRS). For claiming use causal part 54264A27 and applicable labor times found in Section 10 of the Service Labor Time Standards (SLTS) Manual. |
| SSM 50959 | 2022-07-29. Service bulletin. EQUIPMENT:ELECTRICAL. Some 2019-2022 Edge/Nautilus, 2018-2022 Expedition/Navigator, 2020-2022 Explorer/Aviator vehicles equipped with a family entertainment system may experience the audio is not synchronized with the video display when using the vehicle speakers. To correct this condition, contact the VOXX Customer Service Department at 1-866-869-7888. For claiming, refer to the Warranty and Policy manual for Ford Licensed Accessories. |
| TSB 22-2262 | 2022-07-08. Service bulletin. EQUIPMENT:ELECTRICAL. Some 2020-2022 Explorer/Aviator vehicles may exhibit a lack of audio and/or a water leak in the rear liftgate area and/or water in the spare tire area. The customer may indicate that this concern is more noticeable after a car wash or rainfall. To correct the condition, follow the Service Procedure to identify the leak path. |
| SSM 50900 | 2022-07-06. Service bulletin. POWER TRAIN. Some 2020-2022 Explorer/Aviator/Police Interceptor Utility vehicles may exhibit a rear differential that is venting rear axle fluid. This may result in a noise, smell, or leak noticed by the customer. Inspect the rear of the vehicle for signs of rear differential fluid venting in the right rear wheel well (oil staining in the wheel well liner and/or oil residue on the wheel end assembly below) or leaking from the rear differential. If signs of fluid leaks are found from any seals, repair as necessary. Refer to Workshop Manual (WSM), Section 205-02. If no seal leaks are found but fluid is venting, drain the rear differential and re-fill with fresh rear differential fluid. Remove the vent tube and use compressed air to verify that the fluid vent tube is clear. Reinstall the vent tube. Engineering is investigating, monitor OASIS for updates. |
| TSB 22-2254 | 2022-07-01. Service bulletin. BACK OVER PREVENTION:SOFTWARE. Some 2019-2020 Edge/F-150/Fusion/Continental/MKZ/Nautilus, 2019-2021 Mustang/Ranger/Transit Connect, 2020-2021 EcoSport/Escape/Expedition/Explorer/F-Super Duty/Aviator/Corsair/Navigator, 2021 Bronco Sport and 2020-2022 Explorer/Aviator vehicles with SYNC 3 may experience various SYNC performance related concerns. This may be due to the SYNC Software. To correct the condition, follow the Service Procedure to update the accessory protocol interface module (APIM) software. |
| SSM 50885 | 2022-06-30. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. 2020-2022 Explorer/Aviator and 2021-2022 F-150 hybrid vehicles equipped with a 10R80 MHT require the Transmission Strategy Download application in the Ford Diagnosis and Repair System (FDRS) to be run after certain transmission or module repairs. The Transmission Strategy Download routine is failing in FDRS levels 32.5.3 and 32.5.4. The FDRS development team is working to resolve this in a future release of FDRS. In the meantime, uninstall FDRS from the computer using the select all function to remove all data and recordings. Reinstall the older FDRS version 31.6.5 using this url - http://www.fordservicecontent.com/Ford_Content/IDS/FDRS/FDRS_31.6.5.exe Once 31.6.5 is installed, download and run the Transmission Strategy Download application. |
| SSM 50882 | 2022-06-30. Service bulletin. EQUIPMENT:APPLIANCE:TV/RADIO/SPEAKERS. Some 2020-2022 Explorer/Aviator vehicles may exhibit a concern of inoperative, rattling, crackling and/or distorted sound from one or more speakers. In order to correct the condition, make sure to completely follow the diagnostics in Workshop Manual (WSM), Section 415-00, Pinpoint Test D for vehicles without SYNC 3, and WSM, Section 415-00B, Pinpoint Test E for vehicles equipped with SYNC 3. If the diagnostics point towards speaker replacement, remove and re-center the speaker, making sure to tighten to the specified torque and retest. Refer to WSM, Section 415-00. |
| SSM 50873 | 2022-06-30. Service bulletin. ELECTRICAL SYSTEM. Some 2017-2022 Ford and Lincoln vehicle owners may experience a condition of missing authorization, command and control, battery charging details or phone-as-a-key setup buttons/selections in their FordPass or LincolnWay App. This condition is due to an error within the FordPass or LincolnWay App and not due to a concern on the vehicle. Verify that the customers FordPass or LincolnWay App is at the latest version. Replacement or reprogramming of the telematics control unit (TCU)/gateway module (GWM)/remote function actuator (RFA) will not resolve this condition. If the condition persists, utilize the FordPass Guides or Lincoln Way Concierge teams. |
| SSM 50872 | 2022-06-30. Service bulletin. INTERIOR LIGHTING. Some 2020-2022 Aviator vehicles may exhibit an issue transitioning to night mode in low ambient light conditions. This may be due to accessory protocol interface module (APIM) software. Inform customers that engineering is currently working on a solution for this condition and will be released via an over the air (OTA) software update expected in July 2023. Software will update automatically if the vehicle is connected to LincolnWay. Monitor OASIS for additional information. Schedule a service appointment for customers that are not connected to LincolnWay once the repair becomes available. |
| SSM 50745 | 2022-06-30. Service bulletin. POWER TRAIN. Some 2020-2022 Explorer/Aviator/Police Interceptor Utility vehicles may exhibit erratic transfer case operation and/or noise. This may be due to water intrusion between the transmission and the transfer case. The transfer case installation procedure has been updated in Workshop Manual (WSM), Section 307-07B to prevent this concern from reoccurring. Follow the updated WSM procedure to make sure the top of the transfer case is sealed upon installation. |
| SSM 50868 | 2022-06-29. Service bulletin. SEATS. Some 2020-2022 Explorer/Aviator vehicles may exhibit a second row folding seat that is inoperative or requires excessive effort to fold. This may be due to tension built up within the seat and seat track that leads to more force required to manually fold the seat. To correct the condition, the second row seat frame will need to be unbolted from the floor and tightened in the correct sequence. Additionally, the sliding tracks of the seat should be inspected for proper alignment when tightening the bolts. It is important to note that the bolts should be started by hand before tightening to the correct torque. This sequence is outlined in Workshop Manual (WSM), Section 501-10. The WSM has been updated to reflect the updated bolt installation procedure. |
| TSB 22-2176 | 2022-06-27. Service bulletin. FUEL SYSTEM, GASOLINE. Some 2020-2022 Escape/Corsair vehicles built on or before 3-Jan-2022, 2020-2022 Explorer vehicles built on or before 14-Feb-2022, 2020-2022 Aviator vehicles built on or before 07-Feb-2022 and 2021-2022 Bronco Sport vehicles built on or before 3-Dec-2021 may exhibit a slow fuel fill and/or spit back condition during refueling. This may be due to the design of the fuel tank filler pipe. To correct the condition, follow the Service Procedure to replace the fuel tank filler pipe. |
| SSM 50845 | 2022-06-17. Service bulletin. ELECTRICAL SYSTEM. Some 2020-2022 Corsair/Nautilus/Navigator/Aviator, 2021-2022 Mustang Mach-E vehicles equipped with Phone-as-a-Key may exhibit Phone-as-a-Key concerns and have diagnostic trouble code(s) (DTC) U200D:15, U200E:15, U200F:15, B15**:31, B15**:49 and/or B15A5:56 stored in the remote function actuator (RFA) module. If the vehicle is exhibiting other symptoms outside of Phone-as-a-key concerns, address those first. If any of these DTCs are detected during diagnostics, clear the DTCs, reflash RFA to the latest software level and start a new Ford Diagnosis and Repair System (FDRS) session. Verify that DTCs are no longer present. If only the B15**:31, B15**:57 and/or B15A5:56 DTC(s) returns in the RFA after a self test, follow normal Workshop Manual (WSM) diagnostics, Section 419-01C. |
| SSM 50841 | 2022-06-17. Service bulletin. ELECTRICAL SYSTEM. Some 2018-2022 F-150, Expedition, Navigator, Transit, Aviator and Explorer vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0627, P025A, P025B, P00C6, P008A and/or U0109 stored in the powertrain control module (PCM). This may be due to an intermittent or partial disconnect of the harness to the fuel pump control module (FPCM) connector, connector pin push-outs, damaged pins/terminals, or loose/corroded grounds. Inspect FPCM connector, applicable grounds (F-150 - G401, Expedition/Navigator - G403, Transit - G401, 2018-2019 Explorer G302, 2020-2022 Explorer/Aviator - G407) and confirm FPCM connector (F-150 - C4336, Expedition/Navigator - C433, Transit - C433, 2018-2019 Explorer - C3239, 2020-2022 Explorer/Aviator - C4033) is fully seated prior to performing PC/ED diagnostics or replacing any components. |
| SSM 50811 | 2022-06-01. Service bulletin. VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM. Some 2020-2022 Explorer/Aviator vehicles may exhibit the A/C blowing warm air with DTCs P0645, P2CFC, and/or P2CFD present in the heating ventilation and air conditioning (HVAC) module. This may be due to spread terminal/terminal pushout in wire harness 14290 and on the corresponding pins to the body control module C (BCMC). Before replacement of the BCMC, disconnect all connectors from the BCMC and check the BCMC pins and wire terminals for damage. Refer to Workshop Manual (WSM), Section 419-10. If spread terminals or terminal pushout is present, repair as necessary. Refer to Wiring Diagram, Cell 005 for repair procedures. Reconnect all connections to the BCMC as indicated by the procedure in the WSM. Test the function of the A/C to verify that it is blowing cold air. |
| SSM 50810 | 2022-06-01. Service bulletin. STRUCTURE:BODY:HATCHBACK/LIFTGATE. Some 2020-2022 Explorer/Aviator vehicles may exhibit an inoperative power liftgate when using intelligent access (IA) features such as the hands free liftgate or when using the outside control button on the liftgate handle when the doors are locked. This may be due to a poor wiring connection at connector C4332 for the rear keyless entry antenna. If these symptoms are present, inspect C4332 (below the liftgate striker) for a poor connection, loose terminals, or improper pin-fit. |
| SSM 50804 | 2022-06-01. Service bulletin. ELECTRICAL SYSTEM. Some 2013-2023 Ford or Lincoln vehicles with modems activated through FordPass or LincolnWay may experience 12 volt battery drain symptoms when the customer uses non-Ford/Lincoln phone applications as an alternate channel to access vehicle commands such as door lock/unlock, remote start, vehicle location, etc. The battery drain may be caused by excessive calls for data through the vehicle network keeping it in an activated state. Recommend that the customer uninstall the app to ensure this is not contributing to battery symptoms experienced. Advise the customer that unaffiliated third-party app developers do not work directly with Ford to adhere to security, vehicle communication, and privacy requirements. |
| SSM 50800 | 2022-05-24. Service bulletin. ELECTRICAL SYSTEM. Some 2020-2022 Aviator/Explorer Hybrid vehicles may experience a low battery warning message displayed in the message center with diagnostic trouble code B11D9 present in the body control module (BCM). Refer to Workshop Manual, Section 414-01, Pinpoint Test C for diagnosis and repair. If the 125 amp fuse on the 14300 wire harness at the auxiliary battery is open, it is not necessary to replace a complete wire harness to obtain this fuse. Service part number JU5Z-14526-A is now available separately for service. |
| TSB 22-2190 | 2022-05-16. Service bulletin. ELECTRICAL SYSTEM; AIR BAGS:SRS MALFUNCTION WARNING LAMP/LIGHT. Some 2020-2022 Explorer/Aviator and 2021-2022 Bronco vehicles may exhibit an illuminated airbag warning indicator with diagnostic trouble code (DTC) B1404:13 and/or B1407:13. This may be due to contamination and relative movement in the connection between the wiring harness and the side airbag. To correct the condition, follow the Service Procedure to replace the affected connector with a service pigtail and the affected side airbag. |
| SSM 50770 | 2022-05-16. Service bulletin. SEATS. Some 2022 Explorer/Aviator vehicles may exhibit an intermittent passenger seat massage function with no diagnostic trouble codes (DTCs). This may be due to the software and configuration of the seat control module G (SCMG) and seat control module H (SCMH). To correct the condition, download and run the SCMG and SCMH software update application using the latest software level of the Ford Diagnosis and Repair System (FDRS). For claiming, use causal part 14F548 and applicable labor times found in Section 10 of the Service Labor Time Standards (SLTS) Manual. |
| SSM 50748 | 2022-05-14. Service bulletin. ENGINE; ENGINE AND ENGINE COOLING. Some 2020-2022 Explorer/Aviator/Police Interceptor Utility vehicles may exhibit erratic shifting and/or a transmission fluid venting condition. If during the preliminary inspection the transmission fluid is found to be a foamy pink color this may indicate possible cross contamination of engine coolant and transmission fluid due to an internally leaking transmission fluid cooler assembly. When repairing or replacing the transmission assembly for an internally leaking transmission fluid cooler assembly, use causal part 7869 and applicable labor operations in Section 07 of the Service Labor Time Standards (SLTS) Manual. |
| SSM 50651 | 2022-05-04. Service bulletin. COMMUNICATION:MANUFACTURER TELEMATICS; EQUIPMENT. In various 2017-2022 Ford and Lincoln vehicles, customers may receive a message in the FordPass or LincolnWay App stating "Feature Unavailable. Since this is a fleet vehicle, it cannot access the (SYNC Connect) FordPass or LincolnWay app through the TCU Embedded Modem. If this message appears, the vehicle may be equipped with a fleet telematics module. Replacement of the TCU or TCU related repairs will not prevent this message from appearing. Please refer the customer to in app FordPass Guides or LincolnWay Concierge Teams to aid with fleet telematics removal. Open app, select Account > Help > CHAT or CALL option |
| SSM 50733 | 2022-05-03. Service bulletin. TIRES:SIDEWALL. Some 2021 and 2022 Ford and Lincoln vehicles may experience a tire sidewall wavy/indentation appearance in the radial direction on one or both sidewalls. Sidewall wavy/indentation appearance is a common cosmetic characteristic of radial tire construction and will not affect the performance of the tire. |
The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.