WenmarOpen by Wenmar Pro

Service bulletins for the 2016 GMC Sierra

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

2266 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

By topic

Only bulletins with component: Electrical system are shown. Show all

Bulletins, newest first
PIT5195H2024-08-13. Service bulletin. ELECTRICAL SYSTEM. This Preliminary Information communication provides information to the technician about vehicles that the speedometer needle appears to be inaccurate. Dealer should advise the customer the specification for speedometer needle accuracy is +/- 2 MPH at any given speed when looking straight at the needle.
18-NA-1252024-06-28. Service bulletin. ENGINE; ELECTRICAL SYSTEM. This service bulletin provides information for engine oil life monitor operation calculation.
24-NA-0982024-06-25. Service bulletin. ELECTRICAL SYSTEM. This service bulletin provides information for dealers/technicians on Service Programming System (SPS) Error Codes E4398, E4399, E4401, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491, E4492, or E6961 and resolution information.
18-NA-1252024-06-08. Service bulletin. ENGINE; ELECTRICAL SYSTEM. This service bulletin provides information for engine oil life monitor operation calculation.
18-NA-2362024-05-24. Service bulletin. ELECTRICAL SYSTEM; FUEL/PROPULSION SYSTEM. This bulletin provides information for dealers/technicians on the Lithium-Ion battery section and small pack exchange procedure.
13-08-116-001J2024-05-16. Service bulletin. ELECTRICAL SYSTEM. The intent of this service bulletin is to identify aftermarket ALDL or DLC interface devices as potential sources for causing multiple customer concerns that do not have other diagnostic methods to identify them.
20-NA-1322024-04-23. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM. This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
20-NA-1322024-04-05. Service bulletin. ELECTRICAL SYSTEM; ELECTRICAL SYSTEM:12V/24V/48V BATTERY; ELECTRICAL SYSTEM:SOFTWARE; EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL; EQUIPMENT. This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
10-08-45-001H2024-04-05. Service bulletin. ELECTRICAL SYSTEM. This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.
PIT5387B2024-04-01. Service bulletin. VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM; EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.; ELECTRICAL SYSTEM. Radio HVAC IPC Blank Out When Operating A Snow Plow.
18-NA-1802024-02-23. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM. This Warranty Administration service bulletin provides Lithium-Ion battery Exchange Process and Transaction Submission information.
18-NA-1802024-02-17. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM. This Warranty Administration service bulletin provides Lithium-Ion battery Exchange Process and Transaction Submission information.
PI0592I2024-02-02. Service bulletin. ELECTRICAL SYSTEM. This preliminary information (PI) provides information om Service Programming System (SPS) Error Codes (E4398, E4399, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491 or E6961).
PIT5386J2024-01-29. Service bulletin. BACK OVER PREVENTION; ELECTRICAL SYSTEM. This Preliminary Information communication provides information to the technician about vehicles that are found to have a back-up alarm inoperative during the Pre-Delivery Inspection. On trucks equipped with the Back Up Alarm (RPO 8S3), the alarm will be intentionally left disconnected from the assembly plant. Technician will reroute the harness and plug it in.
PIT5962A2024-01-29. Service bulletin. ELECTRICAL SYSTEM:HAND HEATER:WIRING HARNESS; UNKNOWN OR OTHER. This Preliminary information communicates a GM part number for reflective high temperature heat or insulating tape when repairing wiring harnesses.
PIT5359D2024-01-29. Service bulletin. ELECTRICAL SYSTEM. This Preliminary Information communication provides information to the technician about vehicles that may have a radio backlighting will stay on even after the ignition has been turned off and the key has been removed for several minutes, eventually the battery will drain. Technician may find following fuses F23DL F22DL F30DL F31DL F32DL with the ignition key in the off position to have voltage. Technician should not replace the Transfer Case Control Module. Technician will need to install a diode, part number 12112422, across the coil of the solenoid. It is important that the striped end of the diode be connected to the positive terminal of the coil and the other end of the diode be connected to ground.
18-NA-1802024-01-19. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM. This Warranty Administration Bulletin Provides High Voltage Battery Exchange Process Information.
18-NA-1802024-01-13. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM. This Warranty Administration Bulletin Provides High Voltage Battery Exchange Process Information.
228602024-01-08. Service bulletin. ELECTRICAL SYSTEM:WIRING; SERVICE BRAKES. Harness Trapped Under MBEC
158012024-01-08. Service bulletin. ELECTRICAL SYSTEM. Emergency Vehicle Reduced Power
PIT5698D2023-12-26. Service bulletin. ELECTRICAL SYSTEM. This Preliminary information communicates additional information on how a LIN bus operates and diagnostic tips when working on a LIN bus.
PIP5700E2023-12-18. Service bulletin. ELECTRICAL SYSTEM. This Preliminary information communicates to the dealer technician that the part numbers for the internal wiring harnesses for the 8 speed RWD transmissions are not listed in the Electronic Parts Catalog. Technicians are to refer to the information provided in this document to obtain the internal wiring harness part numbers by application.
20-NA-1322023-12-15. Service bulletin. ENGINE AND ENGINE COOLING; EQUIPMENT; ELECTRICAL SYSTEM. This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
23-NA-0652023-11-10. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT. This service bulletin provides repair information to correct a customer concern of OnStar Inoperative after Importing Vehicle from Canada to the United States.
07-08-49-020R2023-10-18. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT; ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER. This informational bulletin provides information for the IPC odometer programming method quick reference guide.

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.