WenmarOpen by Wenmar Pro

Service bulletins for the 2005 Ford F-150

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

95 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

Only bulletins with component: Engine are shown. Show all

Bulletins, newest first
DOR-N3Z7B-032020-03-30. Service bulletin. ENGINE AND ENGINE COOLING. This SKU is an Oil Dipstick. The customer communication requested return of unsold inventory to inspect the dipstick tube. The dipstick tube inner diameter may be small enough that it prevents installation of the OE dipstick.
SSM 473312018-07-23. Service bulletin. EQUIPMENT; ENGINE. Various vehicles equipped with a 4.6L, 5.4L, 6.8L modular 3 valve engine built on or before 8-Jan-2016 may exhibit symptoms that may include upper end engine noise, rough running, misfire and/or engine damage. If diagnosis leads to only camshaft/camshaft roller follower(s) requiring replacement, replace all of the camshaft roller followers on both banks/cylinder heads with part number 3L3Z-6564-A, not just the faulty roller follower(s). When replacing the camshaft roller followers, refer to Workshop Manual (WSM), Section 303-01.
SSM 460852017-08-01. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE); ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER; ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS; ENGINE AND ENGINE COOLING; ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY; ENGINE; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV); ENGINE AND ENGINE COOLING:COOLING SYSTEM; ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER; ENGINE AND ENGINE COOLING:ENGINE:DIESEL; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM; ENGINE AND ENGINE COOLING:ENGINE:GASOLINE; ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS; ENGINE AND ENGINE COOLING:ENGINE; ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN. The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
TSB-14-01142014-09-17. Service bulletin. ENGINE. LINCOLN/FORD: WHEN DRIVING FROM IDLE UP TO 1200 RPM, THERE MAY BE AN INTERMITTENT RATTLE NOISE COMING FROM ENGINE. 2004-2013 F-150, F-250, F-350, EXPEDITION, MARK LT, NAVIGATOR. *PE
TSB-12-8-12012-12-12. Service bulletin. ELECTRICAL SYSTEM:12V/24V/48V BATTERY; ENGINE. FORD/LINCOLN/MERCURY: MAY HAVE SLUDGE BUILDUP IN THROTTLE BODY LEADING TO LESS AIRFLOW OR ENGINE IDLING RPM FLUCTUATION AND HARD STARTS OR BATTERY DISCONNECT OR DEAD BATTERY AFTER KEEP ALIVE MEMORY (KAM) CLEAR. MODELS 2003-05 THUNDERBIRD, 05-06 MUSTANG, 06-08 FUSION, 04-05 EXPLORER, 05-06 EXPEDITION, 05-07 F-150; 2003-06 LS, 06 ZEPHYR, 05-06 NAVIGATOR; 06-08 MILAN. *PE
TSB-12-7-42012-08-28. Service bulletin. ENGINE. FORD/LINCOLN/MERCURY: IF BATTERY WAS DISCONNECTED OR DEAD, VEHICLES/TRUCKS MAY EXPERIENCE HARD STARTS AND ENGINE IDLE RPM FLUCTUATION AND EXHIBIT DIAGNOSTIC TROUBLE CODES (DTCS) P0505, P0506, P2111 AND P2112. *PE
TSB-08-18-22009-06-26. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM). FORD/MERCURY/LINCOLN: VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING SYMPTOMS: DRIVE AWAY HESITATION, LOSS OF RPM ON DECELERATION, DIFFICULTY STARTING, AND/OR IDLE RPM LESS THAN DESIRED. THE F53 MOTORHOME CHASSIS IS INCLUDED. *PE
202282008-06-03. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER. 1999-2008 7.3L/6.0L/6.4L/4.5L DIESEL F-SUPER DUTY - CLEAN THE CHARGE AIR COOLER (CAC) SYSTEM AFTER CERTAIN TURBO OR ENGINE FAILURES - SERVICE TIP. *NJ
072122008-02-21. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
061522007-02-27. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. SPARK PLUG REMOVAL INSTRUCTIONS - 5.4 3V. *KB
0619122007-01-16. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. DIAGNOSTIC TROUBLE CODES (DTC) P0340, P0344, P0345, P0349. ARE FOUND. *KB
052552006-03-14. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. 5.4L 3V WITH P030X AND/OR P0316 ACCOMPANIED BY SPARK KNOCK. *TT
0510152006-01-25. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. 5.4L 3V WITH P030X AND/OR P0316 ACCOMPANIED BY SPARK KNOCK. *TT
0416012006-01-13. Service bulletin. ENGINE AND ENGINE COOLING. WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT
0517132005-12-15. Service bulletin. ENGINE AND ENGINE COOLING. COOLANT DEGAS BOTTLE OVERFLOW. *TT
051022005-12-08. Service bulletin. ENGINE AND ENGINE COOLING. MALFUNCTION INDICATOR LAMP (MIL) ON AND/OR VARIOUS DRIVEABILITY CONDITIONS - 5.4L 3-VALVE ENGINE - VEHICLES BUILT BEFORE 4/20/2005. *TT
188842005-12-01. Service bulletin. ENGINE AND ENGINE COOLING. HARD START, NO START AND/OR OTHER SYMPTOMS CAUSED BY A HIGH PRESSURE OIL SYSTEM LEAK - SERVICE TIP. *TT
052152005-12-01. Service bulletin. ENGINE AND ENGINE COOLING. BUCK/JERK OR SURGE - 6.0L VEHICLES BUILT BEFORE 8/22/2005. *TT
051892005-12-01. Service bulletin. ENGINE AND ENGINE COOLING. MIL ON-VARIOUS DRIVEABILITY CONDITIONS-5.4L 3-VALVE ENGINE-VEHICLES BUILT BEFORE 4/20/2005. *TT
051322005-10-13. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. DIAGNOSTIC TROUBLE CODE (DTC) P0340 AND OR P0344-5.4 3V ENGINE. *SC
051342005-10-08. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. HARD START/LONG CRANK, ROUGH IDLE, ENGINE IDLE MISFIRE-MIL-DTCS P0300 THROUGH P0308, P0171, P0172, P0174, P0175, P0316, P2195, P2196, P2197, P2198. *SC
185122005-05-05. Service bulletin. ENGINE AND ENGINE COOLING. INTERMITTENT CONCERNS OF MIL ON WITH VARIOUS DTCS HARD START LONG CRANK RUNS ROUGH AND OR NO CRANK. *EH OASIS APRIL 2005. *TT
185072005-05-05. Service bulletin. ENGINE AND ENGINE COOLING. FAST IDLE AFTER COLD START. *EH
05432005-05-05. Service bulletin. ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN. COOLING FAN CLUTCH NOISE - VEHICLES BUILT PRIOR TO 10/1/2004 - 5.4L AND 4.6L ENGINES. *TT
184492005-05-05. Service bulletin. ENGINE AND ENGINE COOLING. ENGINE VIBRATION DURING NETURAL RUN UP. *EH

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.