Service bulletin 05189
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 10017802 |
| Published by NHTSA | 2005-12-01 |
| Manufacturer's number | 05189 |
| Manufacturer's date | 2005-10-03 |
| Replaces | 05191 |
| NHTSA component | ENGINE AND ENGINE COOLING |
NHTSA's summary
MIL ON-VARIOUS DRIVEABILITY CONDITIONS-5.4L 3-VALVE ENGINE-VEHICLES BUILT BEFORE 4/20/2005. *TT
The document
No address for NHTSA's copy can be built for this communication. Ask the dealer for it by the manufacturer's number.
Components
Engine
| FORD F-150 | 2005 |
|---|---|
| LINCOLN MARK LT | 2006 |
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| DOR-N3Z7B-03 | 2020-03-30. Service bulletin. This SKU is an Oil Dipstick. The customer communication requested return of unsold inventory to inspect the dipstick tube. The dipstick tube inner diameter may be small enough that it prevents installation of the OE dipstick. |
|---|---|
| SSM 47331 | 2018-07-23. Service bulletin. Various vehicles equipped with a 4.6L, 5.4L, 6.8L modular 3 valve engine built on or before 8-Jan-2016 may exhibit symptoms that may include upper end engine noise, rough running, misfire and/or engine damage. If diagnosis leads to only camshaft/camshaft roller follower(s) requiring replacement, replace all of the camshaft roller followers on both banks/cylinder heads with part number 3L3Z-6564-A, not just the faulty roller follower(s). When replacing the camshaft roller followers, refer to Workshop Manual (WSM), Section 303-01. |
| SSM 46085 | 2017-08-01. Service bulletin. The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information. |
| TSB-14-0114 | 2014-09-17. Service bulletin. LINCOLN/FORD: WHEN DRIVING FROM IDLE UP TO 1200 RPM, THERE MAY BE AN INTERMITTENT RATTLE NOISE COMING FROM ENGINE. 2004-2013 F-150, F-250, F-350, EXPEDITION, MARK LT, NAVIGATOR. *PE |
| TSB-12-8-1 | 2012-12-12. Service bulletin. FORD/LINCOLN/MERCURY: MAY HAVE SLUDGE BUILDUP IN THROTTLE BODY LEADING TO LESS AIRFLOW OR ENGINE IDLING RPM FLUCTUATION AND HARD STARTS OR BATTERY DISCONNECT OR DEAD BATTERY AFTER KEEP ALIVE MEMORY (KAM) CLEAR. MODELS 2003-05 THUNDERBIRD, 05-06 MUSTANG, 06-08 FUSION, 04-05 EXPLORER, 05-06 EXPEDITION, 05-07 F-150; 2003-06 LS, 06 ZEPHYR, 05-06 NAVIGATOR; 06-08 MILAN. *PE |
| TSB-12-7-4 | 2012-08-28. Service bulletin. FORD/LINCOLN/MERCURY: IF BATTERY WAS DISCONNECTED OR DEAD, VEHICLES/TRUCKS MAY EXPERIENCE HARD STARTS AND ENGINE IDLE RPM FLUCTUATION AND EXHIBIT DIAGNOSTIC TROUBLE CODES (DTCS) P0505, P0506, P2111 AND P2112. *PE |
| TSB-08-18-2 | 2009-06-26. Service bulletin. FORD/MERCURY/LINCOLN: VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING SYMPTOMS: DRIVE AWAY HESITATION, LOSS OF RPM ON DECELERATION, DIFFICULTY STARTING, AND/OR IDLE RPM LESS THAN DESIRED. THE F53 MOTORHOME CHASSIS IS INCLUDED. *PE |
| 20228 | 2008-06-03. Service bulletin. 1999-2008 7.3L/6.0L/6.4L/4.5L DIESEL F-SUPER DUTY - CLEAN THE CHARGE AIR COOLER (CAC) SYSTEM AFTER CERTAIN TURBO OR ENGINE FAILURES - SERVICE TIP. *NJ |
| 07212 | 2008-02-21. Service bulletin. SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE |
| 06152 | 2007-02-27. Service bulletin. SPARK PLUG REMOVAL INSTRUCTIONS - 5.4 3V. *KB |