WenmarOpen by Wenmar Pro

Service bulletin B840625

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

The communication, as NHTSA indexes it (as of 2026-10-19)
TypeService bulletin
NHTSA id11024211
Published by NHTSA2025-10-09
Manufacturer's numberB840625
Manufacturer's date2025-10-03
NHTSA componentELECTRICAL SYSTEM

NHTSA's summary

In some situations, an emergency call may be triggered in the vehicle without either the customer pressing the SOS Call button, or an airbag deployment event. In some cases, the customer may not even be inside the vehicle.

The document

The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.

Components

Electrical system

Vehicles listed
BMW 230I2023, 2024, 2025
BMW 330I2024, 2025
BMW 430I2024, 2025, 2026
BMW 530I2023, 2024, 2025
BMW 740I2023, 2024, 2025
BMW IX2024, 2025
BMW IX XDRIVE452026
BMW M32023, 2024, 2025
BMW M42024, 2025, 2026
BMW M52025
BMW X12024, 2025, 2026
BMW X22024, 2025, 2026
BMW X32023, 2024, 2025
BMW X52024, 2025, 2026
BMW X62023, 2024, 2025
BMW X72024, 2025, 2026
BMW XM2023

Listing a model year does not mean every vehicle of it is concerned: the document says which.

Recalls for the same vehicles and component
26V0960002026-02-19. ELECTRICAL SYSTEM:WIRING
26V0560002026-01-30. ELECTRICAL SYSTEM:STARTER ASSEMBLY
25V6430002025-09-25. ELECTRICAL SYSTEM:WIRING:POWER DISTRIBUTION MODULE/IPDM; ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES
25V3950002025-07-23. ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION MOTOR:CONTROLLER:SOFTWARE
25V4700002025-07-16. ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY
20251682025-04-01. Electrical
25V2020002025-04-01. ELECTRICAL SYSTEM:STARTER ASSEMBLY; ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
20250962025-02-21. Electrical
25V1090002025-02-21. ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES
23V7000002023-10-18. ELECTRICAL SYSTEM:ADAS:DRIVER MONITORING:CAMERA/SENSOR

A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.

Other bulletins for the same vehicles and component
B6112262026-10-02. Service campaign. The BCP controls several vehicle functions, including the windscreen wipers and air conditioning actuators. Low current flow may cause excessive current in parts of the BCP circuit board and damage the unit. If a fault occurs, the wipers or air flap controls may operate incorrectly or fail. A wiper failure is indicated by a yellow warning light and the “Windscreen wiper fault” Check Control message.
B6305262026-09-28. Service bulletin. After programming the vehicle via ISTA/RSUto I-level …26-03-5xx, customer may reportsome of the interior ambient lighting strips(arrows) may begin to fail sporadically after adeep sleep cycle. This concern is temporary and the interiorambient lighting will be restored on its ownafter the vehicle is locked/unlocked or colorselection setting is changed.
B6118262026-09-28. Service bulletin. Due to unfavorable software, the Storage Management Electronics (SME) will not show fault codes that trigger the Malfunction Indicator Lamp (MIL) when performing ISTA Service Function "Display Permanent SAE Fault Codes." As a result, workshops will have to identify SME-specific permanent SAE (emission related) Diagnostic Trouble Codes (DTCs) stored in the vehicle during diagnosis or when preparing a vehicle for a State Emission Inspection and Maintenance through a workaround procedure.
B6116262026-08-28. Service campaign. In vehicles equipped with the Roof Function Center “FZD‑21” variant, a quiescent‑current violation mayoccur if the system fails to enter sleep mode. When this sleep error is present, a remote software upgrade(RSU) may be aborted and the FZD can become degraded. The following Check Control Messages (CCMs) may be displayed: “Energy Management — Increased Energy Consumption While Parked.” “Software Upgrade Failed — Workshop Visit Required.”
B6115262026-08-28. Service campaign. In vehicles equipped with the Roof Function Center “FZD‑21” variant, a quiescent‑current violation mayoccur if the system fails to enter sleep mode. When this sleep error is present, a remote software upgrade(RSU) may be aborted and the FZD can become degraded. The following Check Control Messages (CCMs) may be displayed: “Energy Management — Increased Energy Consumption While Parked.” “Software Upgrade Failed — Workshop Visit Required.”
B6408252026-08-27. Service campaign. A faulty electric auxiliary heater may have been installed in the certain vehicles. This could result in thefailure of the electric auxiliary heater, utlized for the vehicle interior.
B6305262026-08-27. Service bulletin. After programming the vehicle via ISTA/RSUto I-level …26-03-5xx, some of the interiorambient lighting strips (arrows) may begin tofail sporadically after a deep sleep cycle.
B3401242026-08-27. Service campaign. After replacement of the Integrated Braking system (IB)/Power Brake the total distance covered might belower than when handed over to the workshop for the repair.
B6520262026-07-31. Service bulletin. The Central Information Display (CID) side of the Multifunction Display (MFD) may flicker intermittently. Theflickering manifests itself in three phases: The image is distorted The central information display turns black (black screen) The image is OK again The complete flickering episode with all the above-mentioned three phases only lasts about half a second intotal each time.
B6519262026-07-31. Service bulletin. Activation of the BMW Intelligent Personal Assistant voice is not possible via the Multifunction Steering Wheel (MFL) button and/or via the Central Information Display (CID). Intelligent voice control via the wake-up word “Hey BMW” is possible.