WenmarOpen by Wenmar Pro

Service bulletin PIC6089B

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

The communication, as NHTSA indexes it (as of 2026-10-19)
TypeService bulletin
NHTSA id10234207
Published by NHTSA2023-04-17
Manufacturer's numberPIC6089B
Manufacturer's date2023-03-08
NHTSA componentPOWER TRAIN; STRUCTURE; ELECTRICAL SYSTEM; EXTERIOR LIGHTING

NHTSA's summary

This Preliminary Information communication provides information to the technician about vehicles that may have a Battery Saver Message or red Battery Indicator displayed in the Driver Information Center. Technician may find Diagnostic Trouble Code P0AF8 set in history. Technician will need to the 12 volt battery using the GR8 Battery tester. The technician will need to perform the Direct current Power Conversion Test published in Global Service Information to check for maximum current and voltage output. This test requires the use of a Carbon Pyle load tester. In addition, the technician can select the 14V Power Module Control Function in the Engine Control Module and Accessory Power Module Setpoint in the Body Control Module by using the Scan Tool in order to check that the system is able to respond to current loads. If the test fails, if there were low voltage Diagnostic Trouble Codes or P0AF8 was set, the technician should confirm that the 200 amp fuse located in the X50D Fuse Block is torqued to correct specification. Technician should check the voltage on both sides of the 200 amp Fuse while there is a load applied and comparing the voltage readings. Voltage drop can be checked from the positive battery post to the Accessory Power Module side of the 200 amp fuse as well. If the Accessory Power Module will output current under a load but the voltage is low on both sides of the fuse when compared to the voltage output at the Accessory Power Module, check the following Service Information for any other Diagnostic Trouble Codes that may have led to the low voltage condition, Accessory Power Module output terminal is clean and torqued to specification, The Accessory Power Module output cable ring terminal is properly seated to the Accessory Power Module output terminal post and its condition, and test the voltage drop on the ground cables to the engine block, transmission, body and chassis to ensure they are within specification.

The document

The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.

Components

Body and frame, Electrical system, Lighting, Transmission and driveline

Trouble codes named

P0AF8

Vehicles listed
CADILLAC ELR2014, 2015, 2016
CHEVROLET SPARK EV2014, 2015 (the catalog's model; the bulletin names a series or trim of it)
CHEVROLET VOLT2011, 2012, 2013, 2014, 2015

Listing a model year does not mean every vehicle of it is concerned: the document says which.

Recalls for the same vehicles and component
20224772022-08-25. Structure
20183202018-06-14. Powertrain
16V4220002016-06-10. ELECTRICAL SYSTEM:SOFTWARE; EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
20162922016-06-08. Electrical
20161912016-04-28. Electrical
16V2570002016-04-28. ELECTRICAL SYSTEM:SOFTWARE; EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
20152792015-06-25. Electrical
15V1450002015-03-13. ELECTRICAL SYSTEM:IGNITION; ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
20144222014-09-30. Structure
20114122011-11-23. Lights And Instruments

A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.

Other bulletins for the same vehicles and component
18-NA-1802025-10-16. Service bulletin. This Warranty Administration service bulletin provides Lithium-Ion battery Exchange Process and Transaction Submission information.
18-NA-1802025-09-26. Service bulletin. This Warranty Administration service bulletin provides Lithium-Ion battery Exchange Process and Transaction Submission information.
PI0281L2025-06-12. Service bulletin. This preliminary informational (PI) bulletin provides information to dealership personnel that may be helpful when addressing underbody component corrosion with customers.
25-NA-0872025-05-02. Service bulletin. This service bulletin provides information on the proper Reflective High Temperature Heat and/or Insulating Tape to use for certain repairs, such as Wiring Harness Repairs.
23-NA-0012025-04-28. Service bulletin. This service bulletin provides information for dealers/technicians on OnStar Module 2G Sunset Information.
13-08-116-001K2025-04-25. Service bulletin. The intent of this service bulletin is to identify aftermarket ALDL or DLC interface devices as potential sources for causing multiple customer concerns that do not have other diagnostic methods to identify them.
24-NA-0982025-04-24. Service bulletin. This service bulletin provides information for dealers/technicians on Service Programming System (SPS) Error Codes E4398, E4399, E4401, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491, E4492, or E6961 and resolution information.
15-06-03-001F2025-04-15. Service bulletin. This service bulletin provides information to diagnose batteries that have set for a long period of time and/or cold weather climates and testing those batteries.
05-08-51-001L2025-03-08. Service bulletin. This informational bulletin provides a procedure on how to remove the paint stain that may present itself under the shipping film.
21-NA-0432025-02-12. Service bulletin. This bulletin advises the dealers to maintain the vehicle stock on hand by doing a full inspection on the vehicles before being sold (prepping) to the customer.