Service bulletin NCUVS2KRUMPE
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 10205440 |
| Published by NHTSA | 2021-12-20 |
| Manufacturer's number | NCUVS2KRUMPE |
| Manufacturer's date | 2021-11-03 |
| NHTSA component | EQUIPMENT; FUEL SYSTEM, GASOLINE |
NHTSA's summary
Update Fuel System Control Unit
The document
The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.
Components
Equipment and accessories, Fuel system
| MERCEDES-BENZ METRIS | 2016, 2017, 2018, 2019, 2020 |
|---|
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| 25V463000 | 2025-07-11. EQUIPMENT:ELECTRICAL:INFOTAINMENT:VIDEO (TOUCH)SCREEN/MONITOR/UNIT; BACK OVER PREVENTION: SENSING SYSTEM: CAMERA |
|---|---|
| 22V134000 | 2022-03-08. FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| 2022103 | 2022-03-07. Fuel System |
| 19V545000 | 2019-07-24. EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL |
| 18V837000 | 2018-11-29. FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| 2018654 | 2018-11-28. Fuel System |
| 2017119 | 2017-03-08. Accessories |
A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.
| LI49.10-N-080528 | 2026-07-02. Service bulletin. OM642 DPF Filter Cracked or Broken Complaint Vehicle will not start or exhibits noisy exhaust. Check Engine Lamp (CEL) is on. Multiple control unit communication and system faults may be present, including but not limited to: 134800, 134900, 11B300, 11EC00, 15E100, 155700, 162500. Additional events codes may include: 134300, 102200, 163400, 16CE00. In many cases, multiple unrelated faults are stored due to electrical disruption from wiring damage rather than indivi-dual component failure. Cause The DPF filter is cracked, broken, or leaking, allowing hot exhaust gas to escape from the exhaust system. Depending on the location of the break or leak, hot exhaust gas may be directed toward the main wiring harness and/ or the SCR (Selective Catalytic Reduction) dosing valve assembly. This heat exposure can result in: • Internal melting of wiring insulation within the harness • Short to ground conditions and loss of communication between control units • Damage to the dosing valve and/or heated AdBlue line Damage to the wiring harness may not be visible externally, as the outer tape can remain intact while the internal wires are melted and fused together. Remedy Inspect the DPF assembly for cracks, separation, or leakage. Do not proceed with further diagnosis or component replacement until the exhaust leak source has been identified and confirmed. If any damage is found, replace the DPF filter assembly. Based on the location of the failure, inspect all components in the path of the exhaust leak, including the dosing valve assembly and main wiring harness. The wiring harness must be opened in any area exposed to the exhaust leak to visually inspect the individual wires. External inspection alone is not sufficient to determine harness condition. Repair or replace any damaged wiring in accordance with approved repair procedures. Replace any dosing system components that show signs of heat damage. Failure to identify and repair all heat-affected components will result in repeat faults or no-start conditions. |
|---|---|
| LI47.50-N-072080_4 | 2026-06-02. Service bulletin. Check engine light on and FC P146264 stored in engine and fuel pump control units Complaint Check engine light active and FC P146264 Temp. and pressure sensor B4/15 is stored in Engine control unit and Fuel pump control unit. Cause Software parameter in Fuel pump control unit. Remedy Update fuel pump control unit (FSCU) to software version A0009024488 A0009030664. Clear fault codes and check for any additional symptoms. |
| LI07.70-N-078824 | 2025-03-04. Service bulletin. Complaint Fault code P06DA00 is found current or stored in engine control unit. Check engine light may be activated. Cause Various causes Remedy Up to Model year 2018: Fault code P06DA00 can be disregarded if not activating the check engine light, unless otherwise specified in the gui- ded test. The vehicle continues to operate as designed. Further causes should be investigated if complaint of check engine light is received. Model year 2019 and later: Fault code P06DA00 will activate check engine light as of model year 2019. No driveability concerns will be observed, only illumination of the CEL. This fault code indicates high resistance or open in the circuit to Y130 oil pump control valve. Perform guided test for component Y130 under list of tests in ME. Diagnose location of high resistance or open in Y130 circuit and repair as necessary. Warranty claims submitted without supporting guided test results may be subject to debit. |
| LI82.85-N-074054 | 2023-08-02. Service bulletin. The connection of the customer's smartphone connected via the original USB cable is disconnected after an undefined period of time for no apparent reason. The Apple iPhone 12 and subsequent models are primarily affected by this. Hardware for radio control unit (Audio) (N87/15) Modification to hardware for radio control unit (Audio) (N87/15). Note: In isolated cases, the replacement chain is not depicted correctly in XENTRY Parts Information (XPI). Please ensure that one of the following replacement part numbers (suitable for the vehicle equipment) is ordered: • Audio30 - A4479002421 • Audio40 - A4479002721 Note: Please refer to this LI in the "Notes" section of the warranty claim |
| 2015110005 | 2023-05-08. Service bulletin. Service Campaign |
| 2017030012 | 2023-05-08. Service bulletin. Pursuant to Part 579.5, we have no Sprinter or Metris Service and Warranty Bulletins for the month of January, 2017. |
| 2017010005 | 2023-05-08. Service bulletin. Recall Campaign bulletin |
| 2017030016 | 2023-05-08. Service bulletin. Recall Campaign bulletin |
| MB Initial NCU-P | 2022-10-24. Service bulletin. (RC)Replace Tire Loading Information Label and Inspect Tires |
| Recall Informati | 2022-08-08. Service bulletin. (RC)Replace and Update Rear View Camera |