WenmarOpen by Wenmar Pro

Service bulletins for the 2005 Volkswagen Passat

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

273 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

Only bulletins with component: Brakes are shown. Show all

Bulletins, newest first
TT4513012023-07-10. Service bulletin. WHEELS; SERVICE BRAKES, AIR:ANTILOCK:CONTROL UNIT/MODULE; BACK OVER PREVENTION; ELECTRICAL SYSTEM; STEERING; STEERING:STEERING WHEEL /HANDLE BAR:YAW/ANGLE SENSOR. After replacing a Bosch 5.7 ABS module, refer to the table below to determine correct module coding value based on vehicle PR codes. Listed login code must be entered under Access/authorization before coding is attempted. After completing coding, G85 steering angle sensor basic settings must be performed before cycling key. To perform G85 basic settings manually in Vehicle self-diagnosis (VAS PC) or Control Module OBD (ODIS), start by entering access/authorization code 40168. After code is accepted, turn steering wheel 1 turn left and back to center, one turn right, and then center steering wheel. Select basic settings and enter group 1. Once display changes to ?Sensor OK? or ?Calibration OK?, basic settings have been completed. Cycle key OFF and then back ON. Clear faults to verify repair.
TT4509032023-07-10. Service bulletin. AIR BAGS; STEERING; SERVICE BRAKES, HYDRAULIC:POWER ASSIST:ELECTRIC:CONTROL MODULE; ELECTRICAL SYSTEM; STEERING:RACK AND PINION:RACK. If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. If the test plan fails to clear the fault, follow the direction below using Vehicle Self Diagnosis in Address Word 44 - Steering Assistance
TT4508022023-07-10. Service bulletin. SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:WHEEL SPEED SENSOR/TONE RING; UNKNOWN OR OTHER. Fault code 02543 000 ?Brake Vacuum Sensor no Display? may be encountered in the ABS module. This may be caused by the hydraulic brake boost function (HBV) in adaptation value 61 being turned off (value = 0). All Passat Wagons (including 4motion) and 3.6L equipped sedans with front drive should have this function turned on (value = 1). Change the adaptation value and verify the fault has cleared. Additionally, it may be necessary to lock the vehicle and allow the modules to go to sleep to clear the fault.
TT2113012023-07-05. Service bulletin. PARKING BRAKE. If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger.
TT 00 16 02-42020-11-05. Service bulletin. SERVICE BRAKES; STEERING; ENGINE. Mandatory fastener.
TT 45 09 05-62020-10-06. Service bulletin. SERVICE BRAKES; EQUIPMENT. Antilock brake function test direction.
TT 45 09 052020-10-06. Service bulletin. SERVICE BRAKES, AIR:ANTILOCK; EQUIPMENT. Antilock brake function test direction.
TT45-13-012016-06-13. Service bulletin. SERVICE BRAKES. SUMMARY TO BE PROVIDED ON A FUTURE DATE.
P 9-66C82008-09-17. Service bulletin. STRUCTURE:FRAME AND MEMBERS; SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM. VOLKSWAGEN: 2001-2005 MODELS: SERVICE AIR PLENUM AREA TO IMPROVE DRAINAGE AND INSTALL IMPROVED POLLEN FILTER SEAL. WATER COULD LEAK INTO THE PASSENGER COMPARTMENT. 2002 MODELS COULD HAVE LEAKS INTO THE BRAKE BOOSTER. *PE
05172005-08-19. Service bulletin. SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE. ANTI-LOCK BRAKE SYSTEM (ABS) CONTROL MODULE WARRANTY REPAIR PROCESS. *TT

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.