WenmarOpen by Wenmar Pro

Service bulletins for the 2021 Toyota Highlander

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

231 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

Only bulletins with component: Electrical system are shown. Show all

Bulletins, newest first
TSB0085232023-12-26. Service bulletin. ELECTRICAL SYSTEM. TSB: Some 2016 ? 2023 model year Toyota vehicles may exhibit a hybrid system warning lamp occurring in below-freezing temperatures (below 32°F or 0°C). After performing a Health Check, one or both of the following Diagnostic Trouble Codes (DTCs) may be present: ?P1C8449 ? (High Voltage Power Resource Circuit Short during Ready ON) ?P300449 ? (High Voltage Power Resource Circuit Short during Pre-Charge) Follow the Repair Procedure in this bulletin to address this condition.
22TC01 Technical2023-11-27. Service bulletin. ELECTRICAL SYSTEM. TI: TECHNICAL INSTRUCTIONS FOR 22TC01 DATA COMMUNICATION MODULE (DCM) REPROGRAMMING CERTAIN 2021 MODEL YEAR C-HR, RAV4 PRIME, TUNDRA CERTAIN 2021-2022 4RUNNER, HIGHLANDER, HIGHLANDER HV, PRIUS PRIME, SEQUOIA, TACOMA CERTAIN 2022 PRIUS
TSB0059232023-10-16. Service bulletin. SERVICE BRAKES; ELECTRICAL SYSTEM; AIR BAGS. TSB: Some drivers of 2020 ? 2022 model year Highlander Hybrid vehicles may be sensitive to the momentary transition from regenerative braking to hydraulic braking under certain driving conditions, such as while driving downhill, or turning with light brake pedal application. The brake actuator control module can be updated to improve brake feeling for this condition. Follow the Repair Procedure in this bulletin to address this condition.
22TE09-12023-06-26. Service bulletin. ELECTRICAL SYSTEM:WIRING; ENGINE AND ENGINE COOLING. TI: TECHNICAL INSTRUCTIONS FOR CUSTOMER SUPPORT PROGRAM 22TE09 HV FLOOR UNDER WIRE HARNESS AND REAR TRACTION MOTOR CABLE CORROSION CERTAIN 2020 ?2022 MODEL YEAR HIGHLANDER HYBRID AWD
22TE092023-06-26. Service bulletin. ELECTRICAL SYSTEM:WIRING; ENGINE AND ENGINE COOLING. DP: Although the HV Floor Under Wire Harness and Rear Traction Motor Cable is covered by Toyota?s New Vehicle Limited Warranty for 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to excessive corrosion to the wire harness connections at the Rear Motor Generator. Excessive corrosion can cause AM Radio Static during certain drive cycles, or, following certain warning indicators, the vehicle may not start.
T-SB-0021-232023-06-26. Service bulletin. VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM; ELECTRICAL SYSTEM. TSB: Some 2020 ? 2022 model year Highlander and RAV4 vehicles, and 2022 model year Tundra vehicles equipped with a start/stop switch may exhibit water entry to the vehicle from the HVAC drain hose being disconnected from the air conditioning radiator assembly and/or a grease/oil odor emitting from the vents. This condition may be caused by paraffin wax leaking from the evaporator.
T-SB-0049-21 Rev2023-01-17. Service bulletin. ELECTRICAL SYSTEM; FUEL SYSTEM, GASOLINE. TSB: Some 2020 ? 2022 Highlander and Highlander Hybrid and 2021 ? 2022 Sienna Hybrid vehicles may exhibit a MIL ON condition with Diagnostic Trouble Codes (DTCs) P0087 (Fuel Rail/System Pressure ? Too Low) and/or P107A2A (Fuel Rail Pressure Sensor (Low) Signal Stuck in Range) present. This condition may occur when the vehicle is operated at high altitude and high temperature; typically, above 3,300 feet (1,000 meters) and ambient temperature above 85°F (30°C). The Engine Control Module (ECM) (SAE term: Powertrain Control Module/PCM) logic has been modified to reduce the possibility of this condition occurring. Follow the Repair Procedure in this bulletin to address this condition
T-TT-0708-222022-10-17. Service bulletin. ENGINE AND ENGINE COOLING; ELECTRICAL SYSTEM. TT: Some Model Year 2018-2022 vehicles equipped with A25A-FKS or A25A-FXS engines may experience a MIL ON condition with the following DTCs: P043F00, P043E00, P24007E, P24007F, P24187E
TTT0698222022-10-17. Service bulletin. ELECTRICAL SYSTEM. TT: Some 17-22MY Highlander and 17-20MY Sienna vehicles may experience a MIL ON condition with DTC(s) P042000, and/or P043000. This issue could involve deteriorated catalyst material from the bank 1 or bank 2 catalytic converter.
TSB0055222022-10-17. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT. TSB: Some 2020 ? 2022 Highlander and Highlander Hybrid, and 2021 ? 2022 model year Venza Hybrid vehicles equipped with the 12.3-in. Premium Audio system may exhibit an abnormal multi-display operation, including but not limited to: an intermittent blank screen (reverse camera still operable), rebooting (Toyota logo present, audio still playing), touch screen inputs intermittently inoperative, or intermittent screen freezing. An updated integration control module is available to address these conditions. Follow the Repair Procedure in this bulletin to address this condition
T-SB-0055-22 Rev2022-09-15. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.. TSB: Some 2020 ? 2022 Highlander and Highlander Hybrid, and 2021 ? 2022 model year Venza Hybrid vehicles equipped with the 12.3-in. Premium Audio system may exhibit an abnormal multi-display operation, including but not limited to: an intermittent blank screen (reverse camera still operable), rebooting (Toyota logo present, audio still playing), touch screen inputs intermittently inoperative, or intermittent screen freezing. An updated integration control module is available to address these conditions. Follow the Repair Procedure in this bulletin to address this condition.
Service Campaign2022-09-15. Service bulletin. ELECTRICAL SYSTEM. DL: Due to improper programming of the Data Communication Module (DCM), which provides cellular communication in various situations, including emergencies, the driver and Safety Connect operator may not be able to hear each other?s voices during a Safety Connect call
22TC012022-06-21. Service bulletin. ELECTRICAL SYSTEM. TECHNICAL INSTRUCTIONS FOR 22TC01 DATA COMMUNICATION MODULE (DCM) REPROGRAMMING CERTAIN 2021 MODEL YEAR C-HR, RAV4 PRIME, TUNDRA CERTAIN 2021-2022 4RUNNER, HIGHLANDER, HIGHLANDER HV, PRIUS PRIME, SEQUOIA, TACOMA CERTAIN 2022 PRIUS
T-SB-0110-20 Rev2022-06-13. Service bulletin. ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY; EQUIPMENT. TSB: This bulletin includes basic procedures for performing a rescue charge at battery on high voltage (HV) Ni-MH and Li-ion batteries. This bulletin should be used in conjunction with the applicable model and model year Repair Manual while performing the battery rescue charge. The GRX-5100 should be used wherever the Repair Manual references the Toyota Hybrid System (THS) charger
22TC01 Technical2022-05-16. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM. TECHNICAL INSTRUCTIONS FOR 22TC01 DATA COMMUNICATION MODULE (DCM) REPROGRAMMING CERTAIN 2021 MODEL YEAR C-HR, RAV4 PRIME, TUNDRA CERTAIN 2021-2022 4RUNNER, HIGHLANDER, HIGHLANDER HV, PRIUS PRIME, SEQUOIA, TACOMA CERTAIN 2022 PRIUS
T-TT-0694-222022-05-16. Service bulletin. ELECTRICAL SYSTEM. TT: After jump-starting, the vehicle may experience a no-start condition and multiple DTCs including U010087. Upon investigation, it is found that the engine ECU has been damaged and needs to be replaced (Fig 1). In several cases, it was found that the cause of the ECU damage was improper jump starting. Further investigation found that ECU damage may occur if the jumper cables are hooked up on or around the engine ECU or ECU mounting bracket
T-TT-0687-222022-04-18. Service bulletin. ELECTRICAL SYSTEM:12V/24V/48V BATTERY. TT: When customers have a concern about a discharged battery, no start, or general battery concern, the DCA-8000 is the only appropriate tool to use for diagnosis
22TC01 Team Memb2022-04-18. Service bulletin. AIR BAGS; ELECTRICAL SYSTEM; SEAT BELTS. SSC: SPECIAL SERVICE CAMPAIGN 22TC01 Over-the-Air (OTA) pilot program. This pilot program would enable you to complete Special Service Campaign 22TC01 for DCM (Data Communication Module) Reprogramming for Safety Connect, which includes your vehicle. With your active telematics account, you are encouraged to complete this campaign using this Over-the-Air (OTA) update by following these steps: 1) To complete this update, each Team Member will use the Toyota/Lexus App installed on their phone. 2) Within a few days of this E-Mail, we will send a notification to your Toyota/Lexus app to schedule and install the update on your vehicle. 3) Click on either the notification on your lock screen or the tile in the app to review the update and then continue in the App to approve the update. 4) The night after you approve the update, the telematics module will perform the update, and you will receive a confirmation notification through the app.
T-TT-0599-20 Rev2022-04-18. Service bulletin. ELECTRICAL SYSTEM. TT: Vehicle control apps might not operate as expected at times due to preconditions (normal operating parameters) not being established, vehicle settings and/or network/cellular coverage concerns
22TC01 Technical2022-03-14. Service bulletin. ELECTRICAL SYSTEM. TI: TECHNICAL INSTRUCTIONS FOR 22TC01 DATA COMMUNICATION MODULE (DCM) REPROGRAMMING CERTAIN 2021 MODEL YEAR C-HR, RAV4 PRIME, TUNDRA CERTAIN 2021-2022 4RUNNER, HIGHLANDER, HIGHLANDER HV, PRIUS PRIME, SEQUOIA, TACOMA CERTAIN 2022 PRIUS
22TC01 Region Le2022-03-14. Service bulletin. ELECTRICAL SYSTEM. RL: Due to improper programming of the Data Communication Module (DCM), which provides cellular communication in various situations, including emergencies, the driver and Safety Connect operator may not be able to hear each other?s voices during a Safety Connect call.
22TC01 Dealer Le2022-03-14. Service bulletin. ELECTRICAL SYSTEM; AIR BAGS. DL: Due to improper programming of the Data Communication Module (DCM), which provides cellular communication in various situations, including emergencies, the driver and Safety Connect operator may not be able to hear each other?s voices during a Safety Connect call
T-SB-0003-222022-02-14. Service bulletin. ELECTRICAL SYSTEM:WIRING. TSB This Service Bulletin includes guidelines meant to help determine whether to repair or replace a wire harness assembly based on damage type. This Service Bulletin should be used in conjunction with the applicable model and model year Electronic Wiring Diagram (EWD) and/or Repair Manual.
T-TT-0593-20 Rev2022-02-14. Service bulletin. ELECTRICAL SYSTEM:ADAS:DRIVER MONITORING:SOFTWARE; ELECTRICAL SYSTEM. TT: Some customers may experience the inability to activate Remote Connect or Remote Connect becoming inoperative when attempting to send commands to the vehicle. To simplify the diagnosis of this system and prevent the unnecessary replacement of parts, please refer to the procedure below.
T-SB-0043-21 Rev2022-02-14. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE; EQUIPMENT:ELECTRICAL:AUX AUDIO JACK/PLUG; EQUIPMENT; ELECTRICAL SYSTEM:SOFTWARE. TSB: Some 2020 model year vehicles equipped with Audio Plus (version 1060) or Premium Audio (version 1060) or earlier may exhibit the following condition: ?Distorted screen when using Apple CarPlay® while making a hands-free phone call. Some 2020 model year vehicles equipped with Audio Plus (version 1021) or Premium Audio (version 1021) or earlier may exhibit one or more of the following conditions: ?Barge in function defaulted to OFF. ?Limited phone book grammar. ?Difficult Hand Free operation. ?Abnormal Electronic Owner?s Manual operation. ?Music does not automatically resume when using Android Auto?. ?Cover art is not displayed. ?Vehicle position is not sent to Destination Assist server. ?System inoperative after using the return button when using voice recognition. Some 2020 model year vehicles equipped with Audio Plus (version 1035) or Premium Audio (version 1035) or earlier may exhibit one or both of the following conditions: ?Abnormal screen play while using Apple CarPlay® (primarily during phone calls). ?Poor sound quality during phone calls while using Apple CarPlay®. Some 2020 model year vehicles equipped with Audio Plus (version 1047) or Premium Audio (version 1047) or earlier may exhibit one or more of the following conditions: ?USB audio does not resume after ignition cycle. ?Intermittent rebooting. ?Bluetooth disconnecting during a phone call when using Apple CarPlay®. ?Intermittent screen freezing. ?Navigation intermittently will not boot up. ?Home Screen Audio widget is blank after a Destination Assist call. ?Song, artist, or album data missing. ?Abnormal clock operation. ?Apple CarPlay® intermittently inoperative. ?Radio takes a long time to boot up. A software update is now available to address these conditions. Follow the Software Update Procedure in this bulletin to update the software.

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.