Service bulletins for the 2016 Ram 2500
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
463 on file from NHTSA, as of 2026-10-19.
By type
By component
By trouble code
By topic
Only bulletins with component: Electrical system are shown. Show all
| 08-111-15 | 2019-05-20. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM. RA1 Radio Enhancements This bulletin involves updating the software on the RA1 Radio. A customer may experience, one or more of the following conditions: ? Radio may reset, turn itself off and then back on again. All Symptom Listed Below Are For 2013 Vehicles Only: ? Radio may be muted. Any of DTCs B1400-92-Front Left Audio Speaker Output - Performance Incorrect Operation and/or B1404-92- Front Right Audio Speaker Output - Performance Incorrect Operation and/or B1408-92-Rear Left Audio Speaker Output - Performance Incorrect Operation and/or B140C-92-Rear Right Audio Speaker Output - Performance Incorrect Operation, maybe active or stored. ? Radio display screen may turn off. ? Radio will stay on after the vehicle is turned off with remote. (Applies to vehicle with Mopar remote start add on package only). ? Radio will stay on for 20 minutes after ignition is turned off and the only way to turn off the radio is by pressing the power button on the radio. Software was updated to have the radio shut off based on the cluster accessory delay setting. |
|---|---|
| 56041380A | 2018-11-26. Service bulletin. ELECTRICAL SYSTEM:12V/24V/48V BATTERY. Battery Please call Bob Horn at cell (248) 231-3315 prior to replacing any battery. Please identify battery with the last 8 VIN digits along with the 15 digit Medtronic code from the GR-8 tester. If no response in 15 minutes, continue with the repair. Battery needs to be held and not turned in for core charges. |
| 08-028-16 | 2018-06-25. Service bulletin. EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.; EQUIPMENT; EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM); ELECTRICAL SYSTEM:SOFTWARE. RE2 RE6 RB5 RB6 Radio Software Enhancements This bulletin involves updating the radio software and navigation if equipped. A customer may experience one or more of the following conditions: · Radio display screen will lock up and reset intermittently. · Incorrect routing directions to fuel stations when using Travel Link. · Unable to turn on heated seats; icon is greyed out. · Navigation screen goes blank. · Navigation system freezes/locks up. · Vehicles with Mopar special edition radio will update radio?s splash screen. · Navigation icon shows the vehicle going backward when it?s moving forward. |
| Z5091195A$ | 2018-06-11. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM); EQUIPMENT; EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.; EQUIPMENT:ELECTRICAL. RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). The Telematics Module (and associated components) is the system responsible for these features. A power cycle may be required for the hands-free module for proper diagnosis.~ Please reference; 8T - Navigation/Telecommunication Diagnosis and Testing (DIAGNOSIS AND TESTING - HANDS FREE PHONE) |
| 18-023-16 | 2018-06-11. Service bulletin. EXTERIOR LIGHTING; ELECTRICAL SYSTEM. Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination or one or more of the following conditions. Upon further investigation the technician may find the following Diagnostic Trouble Codes (DTCs) set in the PCM memory: |
| 17161 | 2018-06-11. Service bulletin. ELECTRICAL SYSTEM:IGNITION; EQUIPMENT; ELECTRICAL SYSTEM:IGNITION:SWITCH. You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 04685719AI. See attachments for identifying suspect stock. Please return suspect parts back to your facing depot using Return Code 02, before 11 July, 2016. Return any open orders in process too. Direct all questions via email to mopardmail@fcagroup.com. |
| 30657 | 2018-06-11. Service bulletin. ELECTRICAL SYSTEM. R4801865AC Alternator Assy - 220 Amp You have been identified as either having stock, or have stock in transit to your dealership. Please return all stock of part number R4801865AC. Replacement is part number 04801865AE which is in stock and available. Please return suspect parts back to your facing depot using Return Code 02, before 04 April, 2017. |
| 08-044-16 | 2018-06-11. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE; EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.. Flash: Radio Frequency Hub Module (RFHM) Enhancement This bulletin involves updating the RFHM software. Customers may describe the instrument cluster is illuminating by itself after the ignition has been off for an extended period of time (10 minutes or more). |
| 08-008-17 REV. A | 2018-06-04. Service bulletin. ELECTRICAL SYSTEM. Flash: BCM Diagnostic and System Improvements This bulletin involves reprogramming the Body Control Module (BCM) with the latest available software. The customer may describe the headlamps flicker while operating at night. This condition may be more prevalent after the bulb(s) have been replaced with an aftermarket bulb. |
| 08-067-16 | 2018-05-21. Service bulletin. ELECTRICAL SYSTEM. Ignition Node Module Replacement This bulletin involves replacing the ignition node module. Some customers may experience a no start issue when turning the key fob in the ignition node module(Fig. 1). |
| 68184926A$ | 2018-05-21. Service bulletin. ELECTRICAL SYSTEM. Integrated Center Stack If vehicle is found within 50 mile radius of the Detroit Metro area please hold vehicle and contact:~ Contact one of the following:~ Daniel Acciacca CELL (586) 709-1537~ Michael Savich CELL (248) 214-7270~ Ayed Hadaad CELL (248) 941-8707~ Issue: On a 2015 & 2016MY LA (Challenger), LD(Charger) and LX (300), the Integrated Center Stack (ICS) may experience a lock-up/Inop condition (complete loss of functionality) during any vehicle diagnostic session (reading fault codes, clearing fault codes, reflashing of any module, etc.). If this occurs, do not replace the ICS. The module functionality can be restored if it is reset by disconnecting power to it (by removing fuse, battery disconnect or module connector disconnect).~ |
| 05091960A$ | 2018-05-21. Service bulletin. ELECTRICAL SYSTEM. Hands Free Module - CTM ? Peiker For RT, JK and MK bodies only; Before replacing the Hands Free Module (HFM), please contact Gaurav Saxena at cell (248) 260-0583~ IMPORTANT - do not reset the HFM, clear codes or perform a battery reset before calling. Engineering is currently root causing this issue and your assistance is greatly appreciated. Seeking vehicles with HFM in a locked state, inoperative, or offline. If unable to reach this person within 15 minutes, then proceed with the necessary repair. |
| 05066241A$ | 2018-05-21. Service bulletin. ELECTRICAL SYSTEM:12V/24V/48V BATTERY. Battery - Transmitter For vehicles within 12 Months in Service which have a "FOB Battery Low" message within Cluster or DTC B1A10 or B1A11 Active or Stored. Engineering is requesting complete FOB returned unopened (ie, battery not removed or FOB housing opened!). ~ All others, follow normal procedures.~ Please ensure Dealer Technicians are aware of this request to allow for gain in FOB Battery depletion understanding. |
| 08-009-16 | 2017-11-03. Service bulletin. EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.; ELECTRICAL SYSTEM; EQUIPMENT. Radio Software Enhancements This bulletin involves updating the radio's software. A customer may experience one or more of the following: · Radio display screen intermittently may go blank. · Radio display screen may lock up. · Back up display may not turn off. · Loss of radio memory for skipped channels or incorrectly displaying skipped channels in the menu list. · Korean language was not supported (APAC - Korea only). Additional Enhancements: · Removed the charging schedule from showing in the setting menu (FF BEV only). · Adding Korean language support (APAC - Korea only). |
| 05150945A$ | 2017-11-03. Service bulletin. ELECTRICAL SYSTEM; POWER TRAIN; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM). Powertrain Control Module If a PCM/ECM is being replaced due to liquid being present inside of the PCM/ECM electrical connector(s) on a 2015-2016 model year 5.7L Hemi DS, D2, DD, DJ or DX truck, please call Lou Nigro at cell (810) 293-3858. If no response is received within 15 minutes, please continue with repair.~ |
| 08-080-16 REV. A | 2017-11-03. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. Flash: BCM Diagnostic And System Improvements This bulletin involves updating the Body Control Module (BCM) software. The customer may describe the headlamps flicker while operating at night. This condition may be more prevalent after the bulb(s) have been replaced with an aftermarket bulb. |
| 08-046-16 REV. A | 2017-11-03. Service bulletin. ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC); ELECTRICAL SYSTEM. Flash: Air Suspension Control Module (ASCM) System Enhancements This Bulletin involves updating the (ASCM) software. A customer may describe the following: Cluster stays awake after ignition is turned off for 10 minutes or more. False message ?Battery Voltage Low - Start Engine to Change Ride Height? which appears in the Electronic Vehicle Information Center (EVIC). This condition may occur when the vehicle is first started and the suspension is switched from alternate trailer ride height to normal ride height. |
| 08-028-17 REV. B | 2017-11-03. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM:SOFTWARE; EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.. RA3 and RA4 Radio Over The Air Software Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The following improvements are included in this update:Fix for sport mode not working in the performance menu page (2015 LA equipped with 6.4L and 5.7L Sales Codes ESH and EZC Only). Adds Apple Siri® Eyes Free capability for iPhone® owners. Auto Play can now be configured. Adds do not disturb text message feature. The ability to drag and drop icons into the menu bar. Fix for radio locks up/frozen. Fix for stuck on black/blank screen. Human Machine Interface (HMI) improvements. Several navigation improvements. Fix for radio loss of time display. Media devices, phone pairing and Bluetooth usage improvements. Improved tuner performance. Enhanced Voice recognition (VR) performance. Enhancements in Connectivity Apps (Yelp, Pandora, Aha, etc). |
| 23-040-17 | 2017-11-03. Service bulletin. ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL; EQUIPMENT. Gap at Center Stack at the Instrument Panel This bulletin involves rework to the center stack trim at the instrument panel. The customer may notice a large gap where the center stack meets the instrument panelFig. 1.Gap at Center Stack Trim |
| 68210071A$ | 2017-11-03. Service bulletin. ENGINE; ELECTRICAL SYSTEM. Intake Grid Heater Grid Heater Relay 2012 - 2016 6.7L Cummins engines with Intake Heater issues or DTC P2609 and P0542, please replace the Intake Heater Grid and Relay as a set. 68210071A$ (relay) and 05187880A$ (grid). Inspect electrical cable between the heater grid and relay for signs of possible overheating. Replace cable as necessary. |
| 08-073-16 | 2017-11-03. Service bulletin. ELECTRICAL SYSTEM; ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL. Flash: Instrument Panel Cluster (IPC) Enhancement This bulletin involves updating the Instrument Panel software and updating Radio Frequency Hub Module (RFHM) software to latest version. The customer may describe one or more of the following: · Instrument cluster backlighting may start flickering. This usually occurs when the dimming is in the lower settings (high-line instrument panels only). · The cruise control set speed does not match the digital speedometer (BUX vehicles only). |
| 18-081-16 | 2017-11-03. Service bulletin. ELECTRICAL SYSTEM; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM). Flash: Diagnostic And System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with updated software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following DTCs have been set: · **P0335 - Crankshaft Position Sensor Circuit. · P2610 - PCM Internal Engine Off Timer Performance.** · P0456 - EVAP System Small Leak. |
| 18-082-16 | 2017-11-03. Service bulletin. SERVICE BRAKES, HYDRAULIC; ELECTRICAL SYSTEM; POWER TRAIN. Flash: 6.4L Powertrain Diagnostic And System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following DTCs: · **P0335 - Crankshaft Position Sensor Circuit. · P2610 - PCM Internal Engine Off Timer Performance.** · P0456 - EVAP System Small Leak. · P3402 - Cylinder 1 Deactivation Control Performance. · P3426 - Cylinder 4 Deactivation Control Performance. · P3442 - Cylinder 6 Deactivation Control Performance. · P3450 - Cylinder 7 Deactivation Control Performance. · P2610 - PCM Internal Engine Off Timer Performance set in the PCM memory. In addition to the DTCs listed above, the software update will improve: · **Correct an issue related to rounding of the cruise control set speed displayed in the cluster. · Brake Throttle Override calibration has changed to be less sensitive. · Throttle Body supplier change has caused a widening of the minimum and maximum voltage limits · Correct a software issue with oil pressure light function at key-up. · Correct a software issue related to idle timer. · Correct a software issue with inconsistent engine RPM increments/decrements with operator idle speed.(DD/DF/DP ONLY).** · Improved Cruise Control Acceleration mode. · Improved Multi Displacement System operation 6-Speed Automatic 66RFE transmission (Sales Code DFP). · Multi Displacement System function improved while in PTO stationary mode. 6-Speed Auto Aisin AS66RC transmission (Sales Code DF3). · Potential small improvement in fuel economy at higher altitudes. · Potential improvement in high altitude engine idle RPM stability. · EGR monitor status function. |
| 119531 | 2016-10-18. Service bulletin. ELECTRICAL SYSTEM. THIS PRESENTATION IS INFORMING OUR CUSTOMER THAT DUE TO TALC PARTICLE CONTAMINATION (WHICH IS IN INHERENT IN THE PRODUCTION ENVIRONMENT) AT CONTACT PORTION ON FEMALE CONTACT BETWEEN CONTACT AND ELEMENT PAD, NITROGEN OXIDE (NOX) SENSOR MAY EXHIBIT AN INTERMITTENT CONNECTION RESULTING IN A DROP IN HEATER RESISTANCE AND NOISE IN THE NOX SIGNAL. |
| 08-057-16 | 2016-07-14. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. SUBJECT: RA3 RA4 Radio Enhancements OVERVIEW: This bulletin involves inspecting and, if required, updating the radio software. SYMPTOM/CONDITION: A small number of customers may experience one or more of the following: • Navigation failed message is displayed. • Clock not automatically updating to local time. • Poor or no connection to cellular network. • HVAC temperature out of sync with radio display (KL vehicles). • Display goes blank/black. • Radio locks up. • Some Uconnect App remote commands do not execute with the vehicle. |
The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.