WenmarOpen by Wenmar Pro

Service bulletins for the 2024 Peterbilt 537

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

41 on file from NHTSA, as of 2026-10-19.

By type

By component

Only bulletins with component: Electrical system are shown. Show all

Bulletins, newest first
43-0802026-06-17. Service bulletin. ELECTRICAL SYSTEM. "KW: A new recommended repair has been added to verify the software level and close the campaign in SIR.The repair procedure has been updated with additional note boxes for clear instructions. PB: The repair procedure has been updated with additional note boxes for clear instructions."
02-1772026-06-03. Service bulletin. ELECTRICAL SYSTEM. Troubleshooting procedures for 2.1m cab power windows are now available.
24PBE_KWE2026-03-05. Service bulletin. ELECTRICAL SYSTEM. The Parts section has been updated to clarify that freight charges for safety recall orders should not be passed on to the end customer.
46-0242026-01-06. Service bulletin. ELECTRICAL SYSTEM. Certain Battery Electric Vehicles that are subject to California Air Resources Board (CARB) regulations have Vehicle Emissions Control Information (VECI) labels that are missing the CARB Enhanced EV and FCEV Statement.
25KWB/25PBB2026-01-06. Service bulletin. EXTERIOR LIGHTING; ELECTRICAL SYSTEM. A new Recommended Repair has been added. It must be used if safety recall 25PACF is performed prior to or at the same time as this repair since the 25PACF remedy also satisfies this safety recall.
24PBE2025-12-05. Service campaign. ELECTRICAL SYSTEM; POWER TRAIN. The right-hand shift stalk may have an improper wire harness terminal crimp within the wire harness connector. Loss of communication between the right-hand shift stalk and the vehicle may result in the vehicle being disabled after it comes to a stop, thereby increasing the risk of crash or injury. A warning will appear on the dash display when communication is lost, including transmission or engine warnings, “!” next to DNR/DNRP indicator, “-“ in the DNR/DNRP indicator, and/or chimes, depending upon whether you are operating a diesel/gas or battery electric vehicle.
25PBB2025-04-04. Service bulletin. ELECTRICAL SYSTEM; EXTERIOR LIGHTING. Safety Recall The Exterior Lighting Switch (ELS) in certain Model 535, 536, 537, 548, and 567 chassis may not function and can be reset only by a key cycle. This issue may result in non-compliance with FMVSS/CMVSS 101 and 108. Affected chassis must have the Vehicle Soft ware updated.
43-080 PB2025-04-04. Service campaign. ELECTRICAL SYSTEM. As of 03/25/2025, this campaign has resumed. Software updates are now available to complete this campaign.
25PBB2025-03-04. Other. EXTERIOR LIGHTING; ELECTRICAL SYSTEM. "Safety Recall – Interim Notification The Exterior Lighting Switch (ELS) in certain Model 535, 536, 537, 548, and 567 chassis may not function and can be reset only by a key cycle. This issue may result in non-compliance with US Federal Motor Vehicle Safety Standards (FMVSS) or Canadian Motor Vehicle Safety Standards (CMVSS) 101 and 108. This bulletin will be updated when software and programming procedures are available."
25PBA2025-02-06. Service bulletin. ENGINE; VEHICLE SPEED CONTROL; ELECTRICAL SYSTEM. Safety Recall – Interim Notification Certain vehicles may have an oversized magnet carrier in the throttle pedal assembly, which may cause the pedal to stick, and may increase the risk of a crash. Driver may feel sticking or that pedal doesn’t return to idle once released. Pressing the service brake will overcome a stuck throttle pedal and allow the vehicle to stop. This bulletin will be updated once parts and procedures are available. INTERIM Safety Recall start date: 01/29/2025
24PBL2025-02-05. Service bulletin. FORWARD COLLISION AVOIDANCE: WARNINGS; UNKNOWN OR OTHER; ELECTRICAL SYSTEM. Safety Recall Updated software and procedures are now available. Certain Vehicle Model Year 2021-2025 Peterbilt chassis configured for trailer towing require a software update for the Bendix EC80 ABS ECU. Software update procedures for certain Battery-Electric Vehicles (BEV) and EC80 ABS ECU part numbers are not yet available. This bulletin will be updated when software update procedures are available for these chassis. Safety Recall publish date: 1/10/25
R2306 - PB2024-12-03. Service bulletin. ELECTRICAL SYSTEM. TCS case requirements for EMUX software and PACCAR MX Pack 2 injector upfit have been removed. Software has been campaigned for both processes, and software assistance is no longer required. All EMUX jumper harness retrofit procedures have been updated to include a soft reverification step and procedures for 520, 567 car carrier, and 2.1m MD have been updated to include R&R procedures for VECU3. Parts Matrix has been updated – VECU3 has been added to numerous chassis.
51-0172024-05-04. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT; EQUIPMENT:ELECTRICAL:INFOTAINMENT:BLUETOOTH/WIFI; EQUIPMENT:ELECTRICAL:INFOTAINMENT; EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE. Certain Peterbilt 535, 536, 537, 548 chassis may have mis-pinned wires for the Bluetooth system, which may cause Bluetooth to not function properly when the driver tries to make/receive a call.
24PBE2024-04-03. Service bulletin. POWER TRAIN; ELECTRICAL SYSTEM. INTERIM Safety Recall Parts are not currently available for this safety recall. This bulletin will be updated once repair parts are available. The right-hand shift stalk may have an improper wire harness terminal crimp within the wire harness connector. Loss of communication between the right-hand shift stalk and the transmission may result in the vehicle becoming disabled after it comes to a stop thereby increasing the risk of crash or injury. A transmission fault will appear on the dash display if communication is lost.
Fuse Holder2024-03-06. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT. The battery box located directly under the driver's side doorsteps of the cab is equipped with a 50A fuse and fuse holder that is connected directly to the battery for constant power. This fuse powers a 70A relay that is used for the safety systems of the truck and is located on the right rear side of the battery box. Due to the fitment of the battery box lid from the chassis manufacturers, moisture and debris are able to fall through the space between the battery box lid and side of the battery box body. This may lead to corrosion of the fuse and holder, which may result in failure of the fuse, loss of current flow, and ultimately the inability to operate the truck. This quality issue affects Kenworth T380 and Peterbilt 537 chassis on Jarco propane bobtail units produced from January 2023 until January 2024.

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.