WenmarOpen by Wenmar Pro

Service bulletins for the 2019 Kenworth T680

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

62 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

Bulletins, newest first
51-0132022-03-04. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM. Due to major data carriers phasing out 3G networks, chassis currently utilizing first generation Peoplenet Mobile Gateway (PMG001) will experience severe 3G service degradation as early as January of 2022. Chassis currently utilizing 3G antennas as a primary antenna may experience this degradation
T0122022-01-06. Service bulletin. POWER TRAIN. Non-Safety Campaign: Drivers of vehicles equipped with PACCAR TX-12 transmissions may experience harsh shifts and gear grinding noise. Premature Main Drive Gear damage may occur due to clutch housing and main case countershaft bearing bore wear.
26-0382022-01-06. Service bulletin. POWER TRAIN. Non-Safety Campaign: Eaton Endurant transmissions may experience premature Main Drive Gear damage due to clutch housing and main case countershaft bearing bore wear. A Clutch Housing Front Cover Kit will be installed to address the issue.
03-0742021-12-03. Service bulletin. ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC). Non-Safety Campaign - The TPMS ECU is not communicating properly with TPMS sensors. The result is a delay or failure of communication between the TPMS ECU and the TPMS sensors , causing inaccurate TPMS readings. A firmware update resolves the issue.
42-0592021-12-02. Service bulletin. ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN; ENGINE AND ENGINE COOLING. Non-Safety Campaign â“ Vehicles with a Cummins X15 engine and Horton fan drive may set Diagnostic Trouble Code (DTC) 6637 and/or 3838 due to fan speed that results in the fan remaining activated until the power is cycled. A new controller will resolve the issue.
43-0712021-10-05. Service bulletin. FUEL SYSTEM, DIESEL. Fix-As-Fail – Due to undersupply issues, only a limited supply of Diesel Exhaust Fluid (DEF) sensors are available. As a temporary solution, after PACCAR confirms a DEF sensor is not available, a temporary software update will allow a vehicle to continue operation with a failed DEF sensor by disabling the DEF sensor diagnostics.
21KWD2021-07-06. Service bulletin. ENGINE AND ENGINE COOLING. Information Only – C hassis equipped with MY2021 B EPA emission s standards will be shipped through atleast the end of the 2021 calendar year without particulate matter (PM) sensors installed .
E2652021-06-02. Service bulletin. ENGINE AND ENGINE COOLING. Selected engines have been identified to receive a camshaft inspection and an update for improved camshaft lubrication.
02-1602021-03-10. Service bulletin. VISIBILITY; EQUIPMENT; EQUIPMENT ADAPTIVE/MOBILITY; VISIBILITY:WINDSHIELD WIPER/WASHER. Information Only – Windshield washer pumps have a high No Trouble Found rate. Washer pumps may fail to spray due to a clogged filter.
32-0182021-03-10. Service bulletin. ENGINE AND ENGINE COOLING. Non-Safety Campaign – Chassis with the City Horn option may generate unexpected alerts. A VECU software update is available to resolve the issue.
32-0172021-03-10. Service bulletin. ELECTRICAL SYSTEM. Non-Safety Campaign – The batteries may drain quickly due to the VECU not going to sleep. Updated VECU software is available to resolve the issue.
51-0082021-02-01. Service bulletin. EQUIPMENT. T680 predictive cruise control(PCC) incompatibility with cummins engine.
26-0372021-01-06. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE; POWER TRAIN; EQUIPMENT ADAPTIVE/MOBILITY. Fix-As-Fail - Prior versions of Eaton Endurant transmission software may be prone to setting Linear Clutch Actuator (LCA) fault codes leading to possible LCA hardware replacement.
26-0352021-01-06. Service bulletin. POWER TRAIN; EQUIPMENT ADAPTIVE/MOBILITY; EQUIPMENT. Non-safety campaign: Vehicles equipped with an Eaton Endurant 12 speed transmission may experience transmission service lamp activation, no gear engagement from neutral, and/or DTC 511 FMI 7 or 10 is set. Resolution is to update the transmission software and calibrations.
T0102021-01-06. Service bulletin. EQUIPMENT ADAPTIVE/MOBILITY; EQUIPMENT; ELECTRICAL SYSTEM:SOFTWARE; POWER TRAIN. Non-Safety Campaign – Vehicles with PACCAR transmissions may experience transmission service lamp activation, no gear engagement from neutral, and/or DTC 511 FMI 7 or 10 is set. Transmission software and shift calibration updates are available to resolve
32-0142020-11-05. Service bulletin. ELECTRICAL SYSTEM. Fix-As-Fail – The Battery Management System (BMS) may report the incorrect battery condition. Additional diagnostics are available to correctly determine and repair the root cause of the issue.
37-0012020-09-03. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM; ENGINE AND ENGINE COOLING. Fix-As-Fail – The Master Switch Module (MSM) may lose dash switch memory and functionality when the battery disconnect switch is cycled. An improved MSM is available to resolve the issue.
13-0542020-08-05. Service bulletin. SERVICE BRAKES. Fix-As-Fail - Bendix New-Gen Lightweight Steer Axle Drum Brake Spider Cracking
32-0152020-07-03. Service bulletin. ELECTRICAL SYSTEM. Information Only: This bulletin provides dealers with a battery warranty quick reference guide to ensure the appropriate tests for battery warranty are performed in order to prevent battery warranty claims filed with incorrect or incomplete information.
43-0662020-04-07. Service bulletin. STRUCTURE. DEF tank covers may become loose and potentially crack on vehicles built before October 2019 with DEF tank part number M86-6221-003**(TANK-DEF MEDIUM ASSY) and M86-6222-003**(TANK-DEF LARGE, ASSY). Resolution is to resolve the vibration on the tank cover by adding bottom tank washers.
32-0162020-04-03. Service bulletin. EQUIPMENT. Information Only: Proper jump-starting voltage will eliminate high voltage related issues and equipment damage.
32-0132020-02-05. Service bulletin. ELECTRICAL SYSTEM. Information Only: The AutoStart System Test does not recognize the hood opening and closing when running the test on a model 579 or 567 chassis equipped with a VECU software version 9.8 and 9.9. The issue will be fixed on a future VECU software update. This bulletin will be updated when the resolution is available.
03-0712020-01-04. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. Information Only - Vehicles built with NAMUX software from 2013 to present may experience accuracy issues with the tachometer. The issue can be temporarily resolved using any one of the included procedures.
52-0022020-01-04. Service bulletin. EQUIPMENT. Fix-As-Fail - DEA5XX radio may be locked in the ON position or stuck in hi volume. A software update is available to resolve this issue.
A0022020-01-04. Service bulletin. EQUIPMENT ADAPTIVE/MOBILITY; STRUCTURE; EQUIPMENT. Non-Safety Campaign - Chassis may experience vibration and knocking noise due to excessive wear of the rear side gear pinion teeth.

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.