Service bulletins for the 2019 Ford Transit
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
152 on file from NHTSA, as of 2026-10-19.
By type
By component
By trouble code
| TSB-20-2053 | 2020-04-02. Service bulletin. ENGINE AND ENGINE COOLING. Some 2015-2019 Transit vehicles equipped with a 3.5L or 3.7L engine may exhibit a lack of heat or uneven heat from side to side. This condition may be due to deposits from the engine coolant becoming trapped in the heater core. To correct the condition, flush the cooling system and replace the heater core. |
|---|---|
| TSB-20-2020 | 2020-04-02. Service bulletin. ENGINE AND ENGINE COOLING. Some 2015-2019 Transit vehicles equipped with a 3.2L engine, 2018-2019 F150 vehicles equipped with a 3.0L engine, 2017-2019 Super Duty vehicles equipped with a 6.7L engine built on or after 13-May-2017 may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P2002 stored in the powertrain control module (PCM). This may be due to a crack in the diesel particulate filter (DPF) substrate. To correct the condition, follow the Service Procedure steps to replace the DPF. |
| SSM 48558 | 2020-03-03. Service bulletin. ELECTRICAL SYSTEM. SSM 48558 - 2017-2020 Various Vehicles Equipped With Telematics Control Unit (TCU) - Various FordPass/LincolnWay Mobile App Concerns Some 2017-2020 Ford and Lincoln vehicles equipped with a TCU may exhibit inoperative remote features via Ford Pass/Lincoln Way mobile app, incomplete user authorization and/or no modem electronic serial number (ESN) displayed. To correct this condition prior to programming, remove the TCU fuse for 5 minutes then reinstall. Delete all previous session files for the vehicle. Verify that the electronic serial number (ESN) is now displayed. Start a new IDS/FDRS session. Program the TCU to the latest IDS/FDRS version level. Make sure you are connected to the internet before retesting. If the concern is still present, follow normal diagnostics in Workshop Manual(WSM), Section 415-00. Refer to PTS OASIS home page for TCU version identification. For claiming, use causal part 14G229 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual. |
| 20M02 | 2020-03-03. Service bulletin. ENGINE AND ENGINE COOLING. This program extends the warranty coverage of the reductant heater and sender assembly to 11 years of service or 120,000 miles from the warranty start date of the vehicle, whichever occurs first. This program DOES NOT apply to vehicles that qualify for repairs under the New Vehicle Limited Warranty. Repairs for vehicles covered by New Vehicle Limited Warranty should be claimed using applicable Labor Operation Codes for the Workshop Manual procedure. Additionally, this program may be used multiple times as long as the vehicle is within time and mileage limits of the program. Once the program has expired, SPW and ESP may be eligible. If a vehicle has already exceeded either the time or mileage limits, this extended warranty coverage will last through October 31, 2020. Coverage is automatically transferred to subsequent owners. |
| SSM 48543 | 2020-03-03. Service bulletin. ENGINE AND ENGINE COOLING. SSM 48543 - 2015-2019 Transit - 3.2L Diesel - Overheat Due To Coolant Loss Without An External Coolant Leak Some 2015-2019 Transit vehicles equipped with a 3.2L diesel engine may exhibit an overheat condition due to coolant loss without any external coolant leaks. This may be due to an internally leaking exhaust gas recirculation (EGR) cooler. To correct this condition, install revised EGR cooler CK4Z-9U433-B. Refer to Workshop Manual (WSM), Section 303-08. Use causal part 9U433 and applicable labor operations from Section 09 of the Service Labor Time Standards (SLTS) Manual. |
| SSM 48443 | 2020-02-04. Service bulletin. ELECTRICAL SYSTEM. Some 2019-2020 Transit Connect vehicles may exhibit an inoperative electrical AC power outlet socket built on or after 28-May-2018. This may be due to a body control module (BCM) software missing a signal to the alternating current to direct current (AC/DC) inverter control module. To correct the condition, reprogram the BCM with the latest level of the appropriate Ford diagnostic scan tool. For claiming use causal part 14A068 and applicable labor operations in Section 03 of the Service Labor Time Standards (SLTS) Manual. |
| TSB 19-2376 | 2020-02-03. Service bulletin. WHEELS. Some 2019 Transit vehicles built on 1-Oct-2018 and through 31-Jul-2019 with aluminum alloy single rear wheels (SRW) may exhibit broken rear wheel stud(s). This may be due to variation in the axle flange to wheel mating surface of the axle shafts. To correct the condition, follow the Service Procedure steps to replace both rear axle shafts and all rear lug nuts. |
| SSM 48423 | 2020-01-08. Service bulletin. POWER TRAIN. Some 2015-2020 Ford and Lincoln vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0011, P0012, P0014, P0015, P0016, P0017, P0018, P0019, P0021, P0022, P0024 and/or P0025. This may be due to small debris causing the VCT solenoid to stick. Before attempting any component diagnosis or replacement of the VCT solenoid, refer to Powertrain Control and Emissions Diagnosis (PC/ED) pinpoint test HK11 to cycle the affected VCT solenoid 10 times to attempt to clear the debris. For claiming, use causal part 6M280 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual. |
| TSB 19-2388 | 2020-01-07. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER. Some 2015-2019 Transit vehicles may exhibit poor air conditioning (A/C) performance. If the cause of this is found to be a refrigerant leak from the evaporator, this may be due to build up of contaminates inside the evaporator housing. To correct this concern, replace only the evaporator housing and install a cabin air filter as opposed to replacing the entire climate control housing assembly. |
| SSM 48340 | 2019-12-05. Service bulletin. ELECTRICAL SYSTEM. Some 2016-2019 vehicles equipped with SYNC 3 may experience a map displayed on the left half of the SYNC screen with no other information/soft buttons present after updating to the latest version of V3.0 software. This issue occurs when the SYNC 3 system has been previously modified using an aftermarket device to display the Ford GT welcome screen/HMI Theme. To correct this issue, please contact the Technical Hotline Assistance Center to have the vehicle restored back to its original state. |
| SSM 48135 | 2019-09-09. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER. Some 2013-2020 vehicles equipped with an EVDC air conditioning (A/C) compressor may exhibit poor A/C performance/improper climate function. To support the proper diagnosis of this compressor, the EVDC control valve tester has been provided to each U.S. dealership (339-EVDC100). Ensure the A/C system has a full charge prior to any compressor diagnostics. To support the proper diagnosis of this compressor, the EVDC compressor tool must be used, and the results recorded in the Technician comments field with the warranty claim. This tester will help reduce the potential for misdiagnosis and unnecessary compressor replacement. Refer to the Rotunda catalog for a video and user manual which provide detailed operating instructions. |
| SSM 48130 | 2019-09-06. Service bulletin. VISIBILITY:GLASS, SIDE/REAR; VISIBILITY. Some 2010-2020 vehicles may exhibit distorted glass with a subtle orange peel pattern or streaking etched into the surface. This is caused by hydrofluoric acid which is used in some car wash solutions as a cleaning agent. Hydrofluoric acid can attack the glass and cause visual distortion and/or discoloration on the outer surface which cannot be removed by further cleaning. If this type of distortion is found, inspect the area of the glass that is covered by the cowl and/or molding. The portion of glass that is covered by the cowl or molding will not be affected by the acid. Hydrofluoric acid damage is not a defect in material or workmanship and is not a warrantable condition. |
| 19B15 | 2019-07-08. Service bulletin. ENGINE AND ENGINE COOLING. Customer Satisfaction Program 19B15: Certain 2019 Model Year F150, Expedition, Navigator and Transit Vehicles Equipped with a 3.5L EcoBoost Engine - Cam Cover Torque |
| SSM 48053 | 2019-07-08. Service bulletin. ELECTRICAL SYSTEM. Some 2016-2019 Ford and Lincoln vehicles equipped with SYNC 3 not at the latest software level may exhibit Various Performance Related concerns such as Display Operation, Navigation, Voice Recognition, Phone Pairing, Applink, Travel Link, Slow System Response, etc. Check for SYNC software update under the OASIS Tab SYNC selection. If an update is available refer to WSM,Section 415-00 and update the APIM software. After Installation, complete pop-up appears, remove USB flash drive and install into IDS tool to update Ford database. Perform a complete ignition cycle by turning the key off for 5 minutes which is critical for a successful installation. If no updates are available or a blue or black screen is present after an update refer to WSM, Section 415-00 for diagnosis or SYNC 3 intermittent blank screen GSB for tips. For claiming, use causal part 14G371 and applicable labor operations in section 10 of the SLTS manual. Section |
| SSM 48030 | 2019-07-08. Service bulletin. POWER TRAIN. Some 2015-2019 Transit vehicles may exhibit a concern where there is no 4th, 5th, or 6th gear engagement and MIL with DTC P07AA. If diagnostics lead to teardown, make sure to inspect the intermediate shafts mating splines in the rear planetary gear set for worn down/stripped splines. Refer to the Workshop Manual (WSM) diagnostics section 307-01 > DTC P07AA > Diagnosis By Symptom > Only gears R,1,2,3 > Overdrive clutch does not apply > Intermediate shaft. If the planetary splines are worn/stripped, replace as necessary. |
| SSM 48018 | 2019-07-08. Service bulletin. ELECTRICAL SYSTEM; VISIBILITY:POWER WINDOW DEVICES AND CONTROLS. Some 2015-2019 Transit vehicles may exhibit inoperative power door locks and/or power windows due to water intrusion in the door to body harness connector C339 (left) or C340 (right). If corrosion is found, service pigtails JU2Z-14S411-RA (gray) and JU2Z-14S411-PA (black) are released to service the body harness (female) side of the connector, without replacing the entire 14401 body harness. Service the pigtail(s) and replace the door harness as needed, while making sure the door to body accordion grommet ends and surrounding body plugs are properly seated to prevent future water intrusion. For claiming use causal part 14631 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual. |
| TSB 19-2166 | 2019-07-03. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER. Some 2015-2019 Transit vehicles may exhibit poor air conditioning (A/C) performance. If the cause of this is found to be a refrigerant leak from the evaporator, it is recommended to replace only the evaporator case as opposed to the entire climate control housing assembly. Follow the Service Procedure steps to correct the condition. |
| SSM 48000 | 2019-06-07. Service bulletin. EXTERIOR LIGHTING. 2015-2019 Transit vehicles equipped with dual rear wheels (DRWs) have a high mount rear marker lamp that does not illuminate with the stop lamps. This lamp assembly may appear to be a stop lamp but is intended to illuminate with the parking lamps only. This information is available in Workshop Manual Section 417-01. The JDDAB feature code description found under OASIS additional information is common between Single Rear Wheel and DRW vehicles, and incorrectly reflects STOP functionality when applied to DRW units. |
| SSM 47976 | 2019-06-07. Service bulletin. POWER TRAIN. On vehicles equipped with an automatic transmission it is imperative that the converter pilot hub be greased with Motorcraft Multi-Purpose Grease Spray XL-5-A even if grease was not applied from the factory. Also verify that the engine/transmission alignment dowel pins are present as well as the engine crankshaft dowel pin, if equipped, when installing the transmission. Failure to adequately lubricate the converter hub greatly increases the likelihood of the flexplate cracking in the future. Missing dowels may cause a misalignment issue also resulting in a premature failure. Refer to Workshop Manual (WSM), Section 307-01. |
| SSM 47967 | 2019-06-06. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER. Some 2013-2019 vehicles equipped with a EVDC air conditioning (A/C) compressor may exhibit poor A/C performance/improper climate function and/or a diagnostic trouble code (DTC) P06A0 in the powertrain control module (PCM). To support the proper diagnosis of this compressor, the EVDC control valve tester has been developed and is available from Rotunda (339-EVDC100). A tester has been provided to each U.S. dealership free of charge with shipments completed 19-Apr-2019 (reference EFC07013 on FMCDealer.com). This tester will help reduce the potential for misdiagnosis and unnecessary compressor replacement. Make sure that this tester is used for warranty repairs and document the test results in the Technician Comments field. Refer to the Rotunda catalog for a video and user manual which provide detailed operating instructions. |
| SSM 47964 | 2019-06-06. Service bulletin. VISIBILITY; VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR. Some 2019 Transit vehicles equipped with power folding mirrors may exhibit the mirror housing vibrating while driving, moving freely, or not moving to the desired position. This may be due to the mirrors being inadvertently folded (manually) during transportation, going through a car wash, being bumped in a parking lot or found during pre-delivery inspection (PDI). Refer the operator to the Loose Mirror detail found in the Windows and Mirrors section of the Owner's Manual to reset the power-fold feature and correct the condition. Transit vehicles equipped with power folding mirrors contain a symbol representing the folding motion, on the mirror switch bezel. |
| SSM 47926 | 2019-05-07. Service bulletin. FUEL SYSTEM, GASOLINE; ELECTRICAL SYSTEM. SSM 47926 - 2018-2019 F-150/Expedition/Navigator/Transit/Explorer - Illuminated MalfunctionIndicator Lamp (MIL) With Diagnostic Trouble Code (DTC) P025A Some 2018-2019 F-150, Expedition, Navigator, Transit and Explorer vehicles may exhibit an illuminated MIL with DTC P025A stored in the powertrain control module (PCM). This may be due to an intermittent or partial disconnect of the harnessto the fuel pump driver module (FPDM) connector. Confirm FPDM connector (F-150 C4336, Expedition/Navigator C433, Transit C433, Explorer C3239) is fully seated prior to performing PC/ED diagnostics or replacing any components. APPLICABLE VEHICLES |
| SSM 47903 | 2019-05-07. Service bulletin. POWER TRAIN. SSM 47903 - 2018-2019 F-150/F-Super Duty/Transit - Rear Axle Pinion Seal Fluid Leak/Seepage Some 2018-2019 F-150, F-Super Duty, and Transit vehicles may exhibit the appearance of a fluid leak or seepage from the rear axle pinion seal. The appearance of a fluid leak or seepage on a vehicle with less than 500 miles or less than 3 months in service may not be due to a failed rear axle pinion seal. The appearance of fluid around the seal may be from the axle assembly being shipped to the vehicle assembly plant with the pinion facing down. To determine if a leak is present, clean the seal area of any residual lubricant and visually inspect the pinion seal for leaks or damage in the seal contact area or dust slinger on the pinion flange dust shield. If no concerns are found, run the vehicle on a hoist in DRIVE at idle speeds for 10 minutes to allow the fluid to circulate and recheck for signs of leakage. |
| SSM 47948 | 2019-05-07. Service bulletin. ENGINE. SSM 47948 - 2010-2019 Various Vehicles - Turbocharged Engines - Oil Supply Filter Replacement When Replacing The Turbocharger Or The Turbocharger Oil Supply Tube For 2010-2019 vehicles equipped with turbocharged engines, when diagnosing and/or replacing turbo related concerns, all steps within the Workshop Manual (WSM) procedure must be followed including replacement of all mandatory discarded parts. When specified in the WSM, the turbocharger oil supply filter must be replaced whenever the turbocharger or the turbocharger oil supply tube are replaced. Turbocharger bearing failure may occur if oil starvation occurs due to a restricted filter. |
| SSM 47850 | 2019-05-07. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT:APPLIANCE:AIR CONDITIONER. Some 2013-2019 vehicles equipped with a EVDC air conditioning (A/C) compressor may exhibit poor A/C performance/improper climate function and/or a diagnostic trouble code (DTC) P06A0 in the powertrain control module (PCM). To support the proper diagnosis of this compressor, the EVDC control valve tester has been developed and is available from Rotunda (339-EVDC100). A tester has been provided to each U.S. dealership free of charge with shipments completed 19-Apr-2019 (reference EFC07013 on FMCDealer.com). This tester will help reduce the potential for misdiagnosis and unnecessary compressor replacement. Make sure that this tester is used for warranty repairs and document the test results in the Technician Comments field. Refer to the Rotunda catalog for a video and user manual which provide detailed operating instructions. |
The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.