WenmarOpen by Wenmar Pro

Service bulletins for the 2004 Ford F-150

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

149 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

Only bulletins with component: Transmission and driveline are shown. Show all

Bulletins, newest first
TSB16-01082017-02-21. Service bulletin. POWER TRAIN. SOME 2004-2014 F-150 AND 2006-2008 MARK LT VEHICLES EQUIPPED WITH FOUR-WHEEL DRIVE (4WD) MAY EXHIBIT NOISY OR ENGAGED FRONT HUBS WHEN OPERATING IN TWO-WHEEL DRIVE (2WD) MODE. FOLLOW THE SERVICE PROCEDURE STEPS TO CORRECT THE CONDITION.
CSP-092408CS-012009-12-16. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM). FORD TRUCK SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. IN THE CASE OF THE ROUSHCHARGER FOR THE F-150, THE TRUCKS CALIBRATION ENHANCEMENTS HAS BEEN DEVELOPED TO BETTER ACCOMMODATE REGIONAL VARIATIONS IN PREMIUM FUEL QUALITY. EVEN THOUGH NOT ALL F-150 ROUSHCHARGED TRUCKS WILL BE AFFECTED BY THESE VARIATIONS. CSC LETTER WAS REC'D. *PE UPDATED 4/12/10. *PE
TSB-08-18-22009-06-26. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM). FORD/MERCURY/LINCOLN: VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING SYMPTOMS: DRIVE AWAY HESITATION, LOSS OF RPM ON DECELERATION, DIFFICULTY STARTING, AND/OR IDLE RPM LESS THAN DESIRED. THE F53 MOTORHOME CHASSIS IS INCLUDED. *PE
08-5-132008-05-30. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM). 4.6L/5.4L--MIL P0506 AND/OR P0505--HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM. *NJ
0611122006-08-04. Service bulletin. POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT. 4X4 FRONT DIFFERENTIAL BRACKET REPAIR. *TT
06452006-05-17. Service bulletin. POWER TRAIN. NEUTRAL TOW CAPABILITY - SERVICE KIT REQUIREMENTS. *TT
0526112006-01-25. Service bulletin. POWER TRAIN:DRIVELINE:DRIVESHAFT. DRIVESHAFT SLIP-BUMP ON DECELERATION OR ACCELERATION FROM A STOP. *TT
056182005-12-07. Service bulletin. POWER TRAIN:AXLE ASSEMBLY. REAR AXLE NOISE REPAIR. *TT
0521182005-12-01. Service bulletin. POWER TRAIN. SERVICE PROCEDURE FOR REPAIR OR REPLACEMENT OF COLUMN SHIFT CABLE. *TT
184662005-05-05. Service bulletin. POWER TRAIN:AXLE ASSEMBLY. AXLE WHINE HOWL. THIS INCLUDES 1997-05 FORD VEHICLES. *EH
042662005-04-29. Service bulletin. POWER TRAIN:DRIVELINE. A DRIVELINE CLUNK OR BUMP WHEN STARTING FROM A STOP. *TT
042582005-04-29. Service bulletin. POWER TRAIN:DRIVELINE. 1ST ORDER VIBRATION FROM THE DRIVELINE AT HIGHWAY SPEEDS. *TT
062162005-04-28. Service bulletin. POWER TRAIN:AXLE ASSEMBLY. LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS. *TT
0421072005-04-28. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM). GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
042172005-04-15. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM). GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT
182502004-12-08. Service bulletin. POWER TRAIN. INTERMITTENT CLUNK ON 3-2 DOWNSHIFT DURING COASTDOWN/TIP-IN. OASIS. TO INCLUDE 2005 F-150, E-SERIES AND EXPEDITION. *TT
182092004-12-07. Service bulletin. POWER TRAIN. HARSH/SLIPPING SHIFTS AND/OR HARSH/DELAYED ENGAGEMENT INTO DRIVE OR REVERSE. *TT
179312004-09-24. Service bulletin. POWER TRAIN:AXLE ASSEMBLY. ENGINEERING IS CURRENTLY INVESTIGATING A REAR AXLE WHINE CONDITION. *TT
179052004-09-23. Service bulletin. POWER TRAIN:AXLE ASSEMBLY. MULTIPLE VEHICLES USING FEHP REAR AXLE FLUID. FLUID USAGE CHANGE. *TT
174402004-07-27. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. CAN NOT SHIFT TRANSMISSION OUT OF PARK CAUSED BY AN OPEN FUSE F2.14. *TT
173722004-07-26. Service bulletin. POWER TRAIN:AXLE ASSEMBLY. HERITAGE F-150 4X2 WITH 8.8 INCH REAR AXLE - WHINE/HOWL NOISE FROM REAR AXLE. *MJ
177022004-07-24. Service bulletin. POWER TRAIN:AXLE ASSEMBLY. AXLE WHINE 40-60 MPH. *TT
04162004-06-16. Service bulletin. POWER TRAIN:DRIVELINE. DRIVELINE CLUNKING/GRUNTING NOISE OR SHUDDER SENSATION DURING LIGHT TO MODERATE ACCELREATION AND/OR BRAKING. *TT
174662004-06-10. Service bulletin. POWER TRAIN:AXLE ASSEMBLY. CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION FROM LIMITED SLIP REAR AXLE DURING LOW SPEED TURNS. *TT
173052004-01-21. Service bulletin. POWER TRAIN. SOME VEHICLES BUILT BEFORE 9/16/03 EQUIPPED WITH A 4.6L/5.4L ENGINE AND 4R75E TRANSMISSION MAY EXHIBIT THE TRANSMISSION CONCERN INDICATOR LAMP (TCIL) ON WITH DIAGNOSTIC TROUBLE CODE P0733 (3RD GEAR RATIO ERROR) AND/OR P0734 (4TH GEAR RATIO ERROR). *TT

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.