Service bulletin 18209
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 10010727 |
| Published by NHTSA | 2004-12-07 |
| Manufacturer's number | 18209 |
| Manufacturer's date | 2004-10-01 |
| NHTSA component | POWER TRAIN |
NHTSA's summary
HARSH/SLIPPING SHIFTS AND/OR HARSH/DELAYED ENGAGEMENT INTO DRIVE OR REVERSE. *TT
The document
No address for NHTSA's copy can be built for this communication. Ask the dealer for it by the manufacturer's number.
Components
Transmission and driveline
| FORD F-150 | 2004 |
|---|---|
| FORD F-250 | 2004 |
| FORD F-350 | 2004 |
| FORD F-450 SD | 2004 (the catalog's model; the bulletin names a series or trim of it) |
| FORD F-550 SD | 2004 (the catalog's model; the bulletin names a series or trim of it) |
| FORD F-650 SD | 2004 (the catalog's model; the bulletin names a series or trim of it) |
| FORD F750 | 2004 |
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| SSM 51909 | 2023-10-04. Service bulletin. When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all versions of MERCON SP and can be used going forward. Mixing MERCON LV and MERCON SP in the same transmission is acceptable. After 30-Jun-2023, MERCON SP ATF will no longer be manufactured and will only be available until inventory depletes. |
|---|---|
| RFI20210210_624- | 2021-03-15. Service bulletin. This SKU is a Transmission Line. The customer communication requested return of unsold inventory to inspect the connector. The transmission line connector may have an incorrect thread size, which will prevent it from being installed. |
| TSB16-0108 | 2017-02-21. Service bulletin. SOME 2004-2014 F-150 AND 2006-2008 MARK LT VEHICLES EQUIPPED WITH FOUR-WHEEL DRIVE (4WD) MAY EXHIBIT NOISY OR ENGAGED FRONT HUBS WHEN OPERATING IN TWO-WHEEL DRIVE (2WD) MODE. FOLLOW THE SERVICE PROCEDURE STEPS TO CORRECT THE CONDITION. |
| ASI-44534 | 2014-10-01. Service bulletin. FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. *PE |
| ASI-44404 | 2014-06-24. Service bulletin. FORD: ON SOME TRUCKS, THERE IS A NO CRANK SITUATION AND IF VOLTAGE ON TRANSMISSION RANGE SENSOR AT PIN 21, IS LESS THAN 5 VOLTS, DISCONNECT THE ENGINE COOLING FAN CLUTCH, ELECTRONICALLY, AND RECHECK VOLTAGE. MODEL 2003-2007 F SUPER DUTY, 2004-2010 E SERIES, 2003-2005 EXCURSION. |
| CSP-092408CS-01 | 2009-12-16. Service bulletin. FORD TRUCK SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. IN THE CASE OF THE ROUSHCHARGER FOR THE F-150, THE TRUCKS CALIBRATION ENHANCEMENTS HAS BEEN DEVELOPED TO BETTER ACCOMMODATE REGIONAL VARIATIONS IN PREMIUM FUEL QUALITY. EVEN THOUGH NOT ALL F-150 ROUSHCHARGED TRUCKS WILL BE AFFECTED BY THESE VARIATIONS. CSC LETTER WAS REC'D. *PE UPDATED 4/12/10. *PE |
| TSB-08-18-2 | 2009-06-26. Service bulletin. FORD/MERCURY/LINCOLN: VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING SYMPTOMS: DRIVE AWAY HESITATION, LOSS OF RPM ON DECELERATION, DIFFICULTY STARTING, AND/OR IDLE RPM LESS THAN DESIRED. THE F53 MOTORHOME CHASSIS IS INCLUDED. *PE |
| 08-5-13 | 2008-05-30. Service bulletin. 4.6L/5.4L--MIL P0506 AND/OR P0505--HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM. *NJ |
| 20052 | 2008-01-23. Service bulletin. 1999-2008 F250-F550 SUPER DUTY 4X4 WITH ELECTRONIC SHIFT TRANSFER CASE NOT ENGAGING 4X4. *NJ |
| 061112 | 2006-08-04. Service bulletin. 4X4 FRONT DIFFERENTIAL BRACKET REPAIR. *TT |