WenmarOpen by Wenmar Pro

Service bulletins for the 2017 Chevrolet Bolt EV

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

1055 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

By topic

Bulletins, newest first
PIP5540G2021-04-19. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:PRESSURE/TEMPERATURE SENSOR. This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related components. That any of the listed DTC's may set with or without poor engine performance.
PIP5725A2021-04-19. Service bulletin. EQUIPMENT. This Preliminary information communicates the use of Winter grade fuel during the warm months of 2020 and the potential rivability issues that it can cause. The ongoing Coronavirus (COVID-19) pandemic has caused significant reductions in driving and fuel use. Due to the surplus of winter grade fuel sitting in storage (pipelines/stations) the EPA is waiving the fuel vapor requirement. This will extend the use of winter fuel into the summer months. The drivability concerns should not be single events but should be multiple occurrences associated with hot days.
150603002H2021-04-16. Service bulletin. ELECTRICAL SYSTEM:12V/24V/48V BATTERY; EQUIPMENT ADAPTIVE/MOBILITY; EQUIPMENT. Original Equipment Batteries Part Number and ACDelco Replacement Battery Approved Warranty Part Numbers Correct battery cold cranking amperage (CCA) ratings and type are critical for proper test results when using the EL-50313. Access to the battery specification label, which contains the OEM part number and CCA rating and type, may be difficult without component removal. Refer to the table below for the original equipment ratings and part numbers used to set up a proper battery test. There has been some confusion as to the correct ACDelco battery warranty replacement. Refer to the table below for the correct battery warranty replacement. The correct ACDelco battery warranty replacement in the catalog is designated by the "Original Equipment Replacement" note in the description field.
150089005A2021-04-16. Service bulletin. EQUIPMENT ADAPTIVE/MOBILITY; EQUIPMENT. Essential Tools that Include Consumable Parts (U.S. Only)
150089004B2021-04-16. Service bulletin. SUSPENSION:FRONT:SHOCK ABSORBER; SUSPENSION:FRONT:MACPHERSON STRUT; SUSPENSION:REAR:SHOCK ABSORBER. Information Regarding the Differences Between Fluid Leakage and Seepage This bulletin is intended to help identify the differences between what is considered a fluid leak and what is considered seepage. Improper diagnosis may lead to unnecessary component replacement. Use the following information to determine if the condition is normal acceptable seepage or a defective component
17-NA-3412021-04-16. Service bulletin. ELECTRICAL SYSTEM:PROPULSION SYSTEM:CHARGING:CABLE/CORD:ONBOARD. 120V Portable Charge Cord is Inoperative or Charges Vehicle Intermittently Condition Some customers may comment that the 120V portable charge cord does not work or that the vehicle does not charge completely or may charge intermittently. Cause The cause of the condition may be the customer’s power outlet is faulty. Correction Test the 120V Portable Charge Cord.
070849020M2021-04-16. Service bulletin. ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER:SENSOR/SENDING UNIT; EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL. IPC Odometer Programming Method Quick Reference Guide
17-NA-3282021-04-15. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. Malfunction Indicator Lamp (MIL) Illuminated - DTC P1AE6 Set Important: Stable battery voltage is critical during programming. Any fluctuation, spiking, over voltage or loss of voltage will interrupt programming. Install the EL-49642 SPS Programming Support Tool to maintain system voltage. If not available, connect a fully charged 12 V jumper or booster pack disconnected from the AC voltage supply. DO NOTconnect a battery charger. Refer to Hybrid Powertrain Control Module 2 Programming and Setup in SI.
17-NA-3202021-04-15. Service bulletin. EQUIPMENT; STRUCTURE:BODY:DOOR:HANDLE:EXTERIOR; LATCHES/LOCKS/LINKAGES:DOORS:LOCK. Condition Information on Outside Door Handle or Lock Cylinder Cover Loose, Falling Off Some customers may comment on any of the following: • Outside door handle loose. • Outside door handle pulls out of door. • Outside door handle fell off. • Outside door handle lock cylinder cover fell off. • Outside door handle lock cylinder cover loose. Cause The cause of the condition may be either of the following issues: 1. Door handle bracket fracture due to the door lock cylinder cover assembly not being fully seated during assembly. 2. Fastener not being torqued to proper specification.
17-NA-3182021-04-15. Service bulletin. EQUIPMENT; STRUCTURE:BODY:DOOR; EQUIPMENT ADAPTIVE/MOBILITY. Door Trim Panel Gap Along Top After Front or Rear Trim Panel Installation Some customers or technicians may comment on seeing a gap between the top pad trim (1) and support panel (2) on a front or rear door trim panel. The condition is most common after the trim panel has been installed during a repair The cause of the condition may be that during a repair, the door pad top trim piece can become unseated when the door pad is pulled off of the clips that secure the door trim panel to the door. Do not replace the door panel for this condition. The gap can be eliminated by firmly pressing down and fully seating the top trim on the door panel.
16-NA-4072021-04-14. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT; EQUIPMENT ADAPTIVE/MOBILITY. Information on Chassis Control Module (CCM) Receives Invalid Data and Sets DTC U0422 The Technician may find DTCs U0422 set. The Technician may also find the following DTCs set. • U1534 • U1538 Information Based on analysis with the BCM team, during vehicle startup (on occasion) the PEPS module arbitration along with high bus traffic leads to the BCM setting the door open switch virtual device availability (VDA) to unavailable. The BCM does not update the VDA back to Available until the door switch changes state (this signal is event based as opposed to periodic). The ICCM sets the U0422 DTC after 1 second of either the door ajar VDA or door open VDA being unavailable. Correction Ignore CCM U0422 DTC (no service necessary) unless it is a current/active code or is accompanied by associated BCM faults U1534 or U1538.
16-NA-407 42021-04-14. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM). Information on Chassis Control Module (CCM) and Hybrid Powertrain Control Module (HPCM) Receives Invalid Data and Sets DTC U0422 The technician may find DTC U0422 set. The technician may also find the following DTCs set: • U1534 • U1538 Based on analysis with the BCM and Hybrid Powertrain Control Module (HPCM) teams, during vehicle startup (on occasion) the PEPS module arbitration along with high bus traffic leads to the BCM or HPCM setting the door open switch virtual device availability (VDA) to unavailable. The BCM or HPCM does not update the VDA back to Available until the door switch changes state (this signal is event based as opposed to periodic). The ICCM and HPCM sets the U0422 DTC after 1 second of either the door ajar VDA or door open VDA being unavailable
16-NA-3962021-04-14. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT ADAPTIVE/MOBILITY; EQUIPMENT. Intermittent Operation of Key Fobs, Door Unlock Inoperative “No Remote Detected” Message with Possible TPM MIL Some customers may comment on intermittent loss of Key Fob and/or Passive Entry, Passive Start functions. This may be accompanied with a “No Remote Detected” message on the DIC. Other symptoms may include: • Passive Locking system locking keys in vehicle • Push button start system failure to respond (cannot “start” or “stop”) with “no remote detected” message • Passive entry system not responding to Lock/Unlock commands • System not responding to active FOB key press – lock, unlock, hatch/trunk, remote start and panic all inoperative • Tire pressure monitor indicator illuminated with DTC's C0750, C0755, C0760 and C0765 with Symptom :29 – Too Few Pulses. Cause This may be due to issues internal to the Remote Control Door Lock Receiver.
16-NA-1752021-04-13. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:INTERNAL:GEARS; EQUIPMENT ADAPTIVE/MOBILITY; EQUIPMENT. SHAKE AND/OR SHUDDER DURING LIGHT THROTTLE ACCELERATION BETWEEN 40 AND 128 KM/H (25 AND 80 MPH) AT A STEADY STATE.
150089004C2021-03-08. Service bulletin. SUSPENSION:FRONT:MACPHERSON STRUT; SUSPENSION:FRONT:SHOCK ABSORBER; POWER TRAIN:AUTOMATIC TRANSMISSION:FLUID/LUBRICANT. This service bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.
21NA0262021-03-08. Service bulletin. EQUIPMENT; STRUCTURE; EQUIPMENT ADAPTIVE/MOBILITY. This service bulletin provides information for dealers/technicians on accessory all-weather floor liners and flat mats warped or misshapen.
040089015V2021-03-01. Service bulletin. EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL. This bulletin provides information on Warranty Administration ? Required Operating Procedures - 8 Points (U.S. Only).
010601011L2021-03-01. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION; EQUIPMENT. This informational bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.
20NA1702021-02-22. Service bulletin. ENGINE AND ENGINE COOLING. This service bulletin provides a procedure to correct a customer concern of a Clicking Type Noise Heard Near Brake Pedal and/or I-Booster Under the Hood.
20NA1592021-02-22. Service bulletin. TIRES. This Warranty Administration bulletin is for information on General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only).
18NA3062021-02-22. Service bulletin. EQUIPMENT. This Warranty Administration bulletin provides information for dealers/Service advisors on when and how to submit a Pre-Repair Authorization (PRA).
040089015V2021-02-01. Service bulletin. EQUIPMENT. This bulletin provides information on Warranty Administration ? Required Operating Procedures - 8 Points (U.S. Only).
010601011L2021-02-01. Service bulletin. ENGINE AND ENGINE COOLING; EQUIPMENT. This informational bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.
20NA1702021-02-01. Service bulletin. EQUIPMENT ADAPTIVE/MOBILITY; SERVICE BRAKES; EQUIPMENT; STRUCTURE. This service bulletin provides a procedure to correct a customer concern of a Clicking Type Noise Heard Near Brake Pedal and/or I-Booster Under the Hood.
20NA1592021-02-01. Service bulletin. TIRES. This Warranty Administration bulletin is for information on General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only).

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.