Service bulletins for the 2022 Western Star 5700
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
61 on file from NHTSA, as of 2026-10-19.
By type
By component
| WI21-008 | 2021-04-23. Service bulletin. EQUIPMENT. Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown. The updated times will be applied to repair orders opened on or after April 5, 2021. |
|---|---|
| DT12 Trans Chafe | 2021-04-08. Service bulletin. EQUIPMENT; EQUIPMENT ADAPTIVE/MOBILITY; POWER TRAIN. DTNA received a field notification on multiple units regarding diagnostic fault codes that were found to be causing issues to the After Treatment Control Module (ACM). These fault codes indicated that the ACM communication message was not received by the Motor Control Module (MCM) which in certain cases, led to a 25% engine de-rate situation. Further diagnosis revealed that the DT12 wiring harness was chafing and contacting the transmission TCU case. To reduce potential chafing areas, the proposed short-term containment was to route the wiring harness using additional tie straps. This communication applies to Freightliner and Western Star vehicles built with DT12 transmissions. |
| WP60-100 | 2021-03-25. Service bulletin. EQUIPMENT. Updated Western Star Parts Technical Bulletin for Universal Design Floor Mats. This bulletin replaces the version dated February 12, 2021. Information about parts notes in the Paragon system have been added and the trimming instructions are revised. Universal floor mat designs fit multiple cab configurations and may require trimming. Trim lines displaying size options are scored into the pad side of the mat; use an existing floor mat as a guide for optimal results. The new mat should not interfere with safety-critical equipment, such as foot pedals. |
| SBW54-057 | 2021-03-25. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM. Western Star Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter. When troubleshooting powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeter is the only Daimler-approved tool for troubleshooting vehicle Powernet issues. |
| WP21-007 | 2021-03-24. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM. Warranty Policy Letter for battery tags. DTNA determined that since adopting the AutoMeter BCT-460DTNA Powernet Assessment Tool (AutoMeter) as the required powernet system tester, not all battery tags have to be retained support Warranty-related claims. |
| 21OEM-06 | 2021-03-01. Service bulletin. ENGINE AND ENGINE COOLING. Starting on November 23, 2020, DiagnosticLink 8.13 (Build 4527) was made available. Current subscribers of DiagnosticLink 8.11 or 8.12 may upgrade to DiagnosticLink 8.13 at no cost. All DTNA Service shops & OEM locations are required to maintain the latest version of software on each of their stations. |
| 20TS-07REV | 2021-03-01. Service bulletin. ENGINE AND ENGINE COOLING. Revised Technical Service Letter for Cold Weather Faults on GHG17/21 DD13 with MCM Software Version 14. Due to colder weather, there may be an increase in the frequency of faults, noted below, on GHG17/21 DD13 trucks built after June 5th 2019. This is due to a calibration issue in the current MCM software (14.1.1.5 or 14.2.1.3). New software is scheduled for release in the first quarter of 2021 that will address these faults. |
| ICI21-003 | 2021-02-26. Service bulletin. EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL. Superseding Letter to an Important Campaign Information Letter to announce a reimbursement available to dealers for travel to a customer's location to perform a recall or field service campaign. Potential travel reimbursement applies to DTNA truck dealers and Detroit Diesel distributors. Thomas Built Buses will be addressed separately. This letter supersedes ICI20-022R. |
| WI21-006 | 2021-02-26. Service bulletin. ELECTRICAL SYSTEM; ENGINE AND ENGINE COOLING; EQUIPMENT ADAPTIVE/MOBILITY; EQUIPMENT. Warranty Information Letter for Detroit NOx Sensor Circuit Fault Codes - Claim Guidelines. |
| WI20-014R | 2021-02-25. Service bulletin. EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL. Revised Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance. In the spirit of continuous improvement, DTNA reviewed sublet-related policies and procedures. The goal was to improve language clarity and optimize processes. Revisions are in blue font. |
| 21TS-02 | 2021-01-28. Service bulletin. EQUIPMENT; ENGINE AND ENGINE COOLING; EQUIPMENT ADAPTIVE/MOBILITY. Technical Service Letter for GHG17 DD16 Vehicles Equipped with Global Aftertreatment (GATS). some GHG17 DD16 powered vehicles will be equipped with the Global Aftertreatment System (GATS), instead of a 1-Box aftertreatment. |
The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.