Service bulletins for the 2021 Toyota RAV4
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
308 on file from NHTSA, as of 2026-10-19.
By type
By component
By trouble code
Only bulletins with component: Throttle and cruise control are shown. Show all
| T-SB-0005-24 | 2024-03-18. Service bulletin. ENGINE AND ENGINE COOLING; VEHICLE SPEED CONTROL:THROTTLE. TSB: Some 2021 model year Avalon, 2020 ? 2022 model year Camry, and 2019 ? 2022 model year RAV4 vehicles equipped with an A25A-FKS engine may exhibit reduced engine power and/or a MIL ON condition with one or more of the following throttle body Diagnostic Trouble Codes (DTCs) present in freezing temperatures: ?P01201C: Throttle / Pedal Position Sensor / Switch ?A? Circuit Voltage Out of Range. ?P210015: Throttle Actuator ?A? Control Motor Circuit Short to Battery or Open. ?P210019: Throttle Actuator ?A? Control Motor Circuit Current Above Threshold. ?P211172: Throttle Actuator ?A? Control System Actuator Stuck Open. The Engine Control Module (ECM) (SAE term: Powertrain Control Module/PCM) logic and the fuel pump assembly have been modified to address these conditions. Follow the Repair Procedure in this bulletin to address these conditions |
|---|---|
| 22TE09 | 2023-10-16. Service bulletin. VEHICLE SPEED CONTROL:CABLES; ENGINE AND ENGINE COOLING. TI: TECHNICAL INSTRUCTIONS FOR CUSTOMER SUPPORT PROGRAM 22TE09 HV FLOOR UNDER WIRE HARNESS AND REAR TRACTION MOTOR CABLE CORROSION CERTAIN 2019 ?2022 MODEL YEAR RAV4 HYBRID AWD (Amendment) |
| TSB003220 | 2023-10-16. Service bulletin. VEHICLE SPEED CONTROL; AIR BAGS; EQUIPMENT. TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2023 model year vehicles may be available provided the requests meet the criteria listed in this Service Bulletin. Follow the Procurement Procedure in this bulletin to request a replacement certification label or VIN plate. |
| T-SB-0084-21 Rev | 2022-04-18. Service bulletin. BACK OVER PREVENTION; VEHICLE SPEED CONTROL. TSB: Some 2019 ? 2022 model year RAV4 and RAV4 Hybrid and 2021 ? 2022 model year RAV4 Prime vehicles may exhibit a sloshing or splashing noise from inside one or more door panels when driving, opening and/or closing a door, and/or braking. This condition is caused by a cavity wax/debris/substance that may block door drain holes and restrict water from draining properly. Follow the Repair Procedure in this bulletin to address this condition |
| T-SB-0005-21 | 2021-02-16. Service bulletin. STEERING; ELECTRICAL SYSTEM; POWER TRAIN; LANE DEPARTURE; VEHICLE SPEED CONTROL; PARKING BRAKE; WHEELS. TSB: Some 2021 model year RAV4 Prime vehicles may exhibit a condition in which the steering wheel controls are inoperative after the ignition switch has been turned off for two minutes. Some examples where customers may notice this condition include: ?Unable to select the Charge Now function after the charging cable is plugged in, with a charging schedule set. ?Unable to turn the Power Back Door Master Switch on, when the power back door button is pressed with the power back door system turned off. ?Unable to dismiss warning messages such as ?door open? or ?window open.? The combination meter logic has been modified to reduce the possibility of this condition. Follow the Repair Procedure in this bulletin to address this condition. |
The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.