Service bulletins for the 2021 Toyota RAV4
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
308 on file from NHTSA, as of 2026-10-19.
By type
By component
By trouble code
Only bulletins with component: Electrical system are shown. Show all
| T-TT-0678-21 | 2022-01-18. Service bulletin. EQUIPMENT:ELECTRICAL; ELECTRICAL SYSTEM. TT: Some 19CY LG DCM equipped vehicles may not be able to complete the firmware update due to not having an active account or waived services during the trial. Follow the steps below to enable ?Temp DCM Activation?. |
|---|---|
| T-SB-0104-21 | 2022-01-18. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT; ENGINE. TSB: Some 2018 ? 2022 model year Toyota vehicles equipped with an A25A-FKS, A25A-FXS, or M20A-FKS engine may exhibit one or more of the following conditions: ?Milky/Discolored engine oil. ?An ?Oil Pressure Low? warning message on the Multi-information Display (MID). ?A MIL ON condition with Diagnostic Trouble Codes (DTCs) P05202A (Engine Oil Pressure Sensor/Switch "A" Signal Stuck in Range) and/or P052477 (Engine Oil Pressure too low [Severe]). Moisture from blow-by gases condenses and accumulates in the engine oil during short trips in extreme cold weather. When the moisture in the oil freezes, the oil pressure may drop, and the aforementioned warning indicators may display. Follow the procedures in this bulletin to address these conditions. |
| T-SB-0100-21 | 2022-01-18. Service bulletin. ELECTRICAL SYSTEM; STRUCTURE; EQUIPMENT. TSB: Pre-Delivery Service (PDS) is a critical step in satisfying our new car customers. Customer feedback indicates the following areas deserve special attention when performing PDS: ?Careful inspection for paint chips/scratches and body dents/dings. ?Proper operation of electrical accessories (including interior light, clock, and radio reset). ?Interior cleanliness. ?Proper function of mechanical systems. Customer retention and proper maintenance of vehicles are and have always been a major focus for Toyota. To help remind customers that regular service is essential to the proper maintenance of the vehicle, dealers are required to install a service reminder sticker before delivery. By doing this, customers will be reminded to return to your dealership for service. Your current service reminder sticker may be used. (See PDS Check Sheet item 8 of ?Final Inspection and Cleaning.?) This bulletin contains the PDS procedures that apply specifically to 2022 model year RAV4, RAV4 Hybrid and RAV4 Prime vehicles. A universal PDS Check Sheet that contains PDS steps that apply to all 2022 model year Toyota vehicles has been developed. To properly perform a complete PDS, you must complete all procedures contained in this TSB as well as the universal PDS Check Sheet. In addition, if the vehicle is stored for over 30 days, be sure to follow Long-Term Vehicle Storage Guidelines. |
| T-TT-0668-21 | 2021-11-15. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT; POWER TRAIN. TT: Some vehicles may exhibit seat memory switch function inoperative condition if the Seating Position Control ECU is not initialized. The Pre-Delivery Service (PDS) bulletin (link below) instructs technicians to perform this initialization after the D/C Cut Fuse is installed. The Repair Manual (links below) states that when any of the following conditions are met, the seat position information in the position control ECU assembly will be cleared: ?The power switch is turned off with any of the seat switches being operated and the ECU-DCC NO.2 fuse removed. ?The power switch is turned off within 1 second of any of the seat switches being operated with the ECU-DCC NO.2 fuse removed. ?Power supplied to the position control ECU assembly is cut while the seat is moving to the memorized position. |
| 20TE06_Dealer Pa | 2021-09-13. Service bulletin. ELECTRICAL SYSTEM:INSTRUMENT PANEL:FUEL GAUGE; FUEL SYSTEM, GASOLINE. DP: Toyota has received customer reports of certain 2021 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Some customer reports have also noted the ?Distance to Empty? shown on the multi-information display is less than expected. Based on our investigation, Toyota believes these conditions to be primarily related to a variation of fuel tank shape and the potential for the fuel sender gauge to become inclined. These conditions can cause the fuel level to be read incorrectly and may cause the low fuel light to illuminate with more fuel in the tank than usual. Although the fuel tank is covered by Toyota?s New Vehicle Limited Warranty for normal Basic Warranty coverage period, 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to refueling performance concerns. Note: Fuel tanks are covered under the normal California Emissions Control Warranty period, 7 years or 70,000 miles (whichever comes first), for the following states: Connecticut, Delaware, Maine, Maryland, Massachusetts, New Jersey, New York, Oregon, Pennsylvania, Rhode Island, Vermont, and Washington. The following information is provided to inform you and your staff of the program notification schedule and your degree of involvement. |
| 20TE04_Dealer Pa | 2021-09-13. Service bulletin. FUEL SYSTEM, GASOLINE; ELECTRICAL SYSTEM:INSTRUMENT PANEL:FUEL GAUGE. DP: Toyota has received customer reports of certain 2019-2021 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Some customer reports have also noted the ?Distance to Empty? shown on the multi-information display is less than expected. Based on our investigation, Toyota believes these conditions to be primarily related to a variation of fuel tank shape and the potential for the fuel sender gauge to become inclined. These conditions can cause the fuel level to be read incorrectly and may cause the low fuel light to illuminate with more fuel in the tank than usual. Although the fuel tank and fuel sender gauge unit are covered by Toyota?s New Vehicle Limited Warranty for normal Basic Warranty coverage period, 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to refueling performance concerns. Note: Fuel tanks are covered under the normal California Emissions Control Warranty period, 7 years or 70,000 miles (whichever comes first), for the following states: Connecticut, Delaware, Maine, Maryland, Massachusetts, New Jersey, New York, Oregon, Pennsylvania, Rhode Island, Vermont, and Washington. |
| 20TE06_Dealer Pa | 2021-09-13. Service bulletin. ELECTRICAL SYSTEM; FUEL SYSTEM, GASOLINE. DP: Toyota has received customer reports of certain 2021 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Some customer reports have also noted the ?Distance to Empty? shown on the multi-information display is less than expected. Based on our investigation, Toyota believes these conditions to be primarily related to a variation of fuel tank shape and the potential for the fuel sender gauge to become inclined. These conditions can cause the fuel level to be read incorrectly and may cause the low fuel light to illuminate with more fuel in the tank than usual. Although the fuel tank is covered by Toyota?s New Vehicle Limited Warranty for normal Basic Warranty coverage period, 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to refueling performance concerns. Note: Fuel tanks are covered under the normal California Emissions Control Warranty period, 7 years or 70,000 miles (whichever comes first), for the following states: Connecticut, Delaware, Maine, Maryland, Massachusetts, New Jersey, New York, Oregon, Pennsylvania, Rhode Island, Vermont, and Washington. The following information is provided to inform you and your staff of the program notification schedule and your degree of involvement. |
| 20TE04_Dealer Pa | 2021-09-13. Service bulletin. FUEL SYSTEM, GASOLINE; ELECTRICAL SYSTEM. DP: Toyota has received customer reports of certain 2019-2021 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Some customer reports have also noted the ?Distance to Empty? shown on the multi-information display is less than expected. Based on our investigation, Toyota believes these conditions to be primarily related to a variation of fuel tank shape and the potential for the fuel sender gauge to become inclined. These conditions can cause the fuel level to be read incorrectly and may cause the low fuel light to illuminate with more fuel in the tank than usual. Although the fuel tank and fuel sender gauge unit are covered by Toyota?s New Vehicle Limited Warranty for normal Basic Warranty coverage period, 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to refueling performance concerns. Note: Fuel tanks are covered under the normal California Emissions Control Warranty period, 7 years or 70,000 miles (whichever comes first), for the following states: Connecticut, Delaware, Maine, Maryland, Massachusetts, New Jersey, New York, Oregon, Pennsylvania, Rhode Island, Vermont, and Washington. |
| T-TT-0611-20 Rev | 2021-06-21. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM). TT: To assist with the early detection and early resolution of audio related concerns, it may be requested as part of the remanufactured head unit return to recover MMR data from the head unit. The following steps are instructions on how to retrieve the data from the system and are only to be used when requested by audio suppliers, FTS, and/or FPEs. |
| T-SB-0025-21 | 2021-06-21. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM; EQUIPMENT ADAPTIVE/MOBILITY. TSB: Some 2020 ? 2021 model year vehicles equipped with Audio, Audio Plus, or Premium Audio (versions 1784) or earlier may exhibit one or more of the following conditions: ?Intermittent blank screen. ?Navigation map update fails. ?Album art inoperative. ?Pause function intermittently inoperative in CD mode. ?Intermittent DTC B15FE present. ?Abnormal energy flow screen appearance on Hybrid models. ?Abnormal phone call operation during Apple CarPlay®. ??No Information? displayed in Information Screen. ?No audio after voice guidance in Android Auto. ?Abnormal charging scheduling operation on RAV4 Prime models. ?Abnormal XM operation when using Apple CarPlay®. Follow the Multimedia Software Update Procedure in this bulletin to install the latest software version. |
| T-TT-0599-20 Rev | 2021-04-19. Service bulletin. ELECTRICAL SYSTEM; BACK OVER PREVENTION. TT: Vehicle control apps might not operate as expected at times due to preconditions (normal operating parameters) not being established, vehicle settings and/or network/cellular coverage concerns. |
| T-SB-0005-21 | 2021-02-16. Service bulletin. STEERING; ELECTRICAL SYSTEM; POWER TRAIN; LANE DEPARTURE; VEHICLE SPEED CONTROL; PARKING BRAKE; WHEELS. TSB: Some 2021 model year RAV4 Prime vehicles may exhibit a condition in which the steering wheel controls are inoperative after the ignition switch has been turned off for two minutes. Some examples where customers may notice this condition include: ?Unable to select the Charge Now function after the charging cable is plugged in, with a charging schedule set. ?Unable to turn the Power Back Door Master Switch on, when the power back door button is pressed with the power back door system turned off. ?Unable to dismiss warning messages such as ?door open? or ?window open.? The combination meter logic has been modified to reduce the possibility of this condition. Follow the Repair Procedure in this bulletin to address this condition. |
| T-SB-0095-20 Rev | 2021-02-16. Service bulletin. ELECTRICAL SYSTEM:12V/24V/48V BATTERY. TSB: Some 2020 model year Camry, Camry Hybrid, Corolla Hatchback, RAV4, and RAV4 Hybrid vehicles may exhibit one or more of the following conditions: ?Diagnostic Trouble Code (DTC) B15A804 is present in current or history. ?Red SOS LED stays on after bulb check. ?Toyota App does not accept the activation code. ?Toyota App is inoperative. ?SOS call center does not receive the vehicle?s location in a timely manner. ?Toyota App shows an error 42 when trying to execute a command. ?Unable to remote start the vehicle with the key fob (if equipped). ?Unable to subscribe to remote services. ?Unable to activate Wi-Fi. ?Destination Assist is inoperative Some 2020 ? 2021 model year Camry, Camry Hybrid, Corolla Hatchback, RAV4, and RAV4 Hybrid vehicles and some 2021 model year Avalon, Avalon Hybrid, Corolla, Corolla Hybrid, Sienna Hybrid, and Venza Hybrid vehicles may exhibit one or more of the following conditions: ?DTC B15A804 is present in current or history. ?Red SOS LED stays on after bulb check. ?Toyota App is inoperative. ?Unable to subscribe to remote services. ?Unable to activate Wi-Fi. ?Depleted 12V vehicle battery when in IG-OFF. Some 2020 ? 2021 model year Camry, Camry Hybrid, Corolla Hatchback, RAV4, and RAV4 Hybrid vehicles and some 2021 model year Avalon, Avalon Hybrid, Corolla, Corolla Hybrid, Sienna Hybrid, and Venza Hybrid vehicles may exhibit the following condition: ?Depleted 12V vehicle battery when in IG-OFF. A DCM reset and firmware update is now available to address these conditions. Follow the DCM Reset and Firmware Update Procedure in this bulletin to update the firmware. |
| T-SB-0095-20 Rev | 2021-02-16. Service bulletin. ELECTRICAL SYSTEM:12V/24V/48V BATTERY. TSB: Some 2020 model year Camry, Camry Hybrid, Corolla Hatchback, RAV4, and RAV4 Hybrid vehicles may exhibit one or more of the following conditions: ?Diagnostic Trouble Code (DTC) B15A804 is present in current or history. ?Red SOS LED stays on after bulb check. ?Toyota App does not accept the activation code. ?Toyota App is inoperative. ?SOS call center does not receive the vehicle?s location in a timely manner. ?Toyota App shows an error 42 when trying to execute a command. ?Unable to remote start the vehicle with the key fob (if equipped). ?Unable to subscribe to remote services. ?Unable to activate Wi-Fi. ?Destination Assist is inoperative. Some 2020 ? 2021 model year Camry, Camry Hybrid, Corolla Hatchback, RAV4, and RAV4 Hybrid vehicles and some 2021 model year Avalon, Avalon Hybrid, Corolla, Corolla Hybrid, Sienna Hybrid, and Venza Hybrid vehicles may exhibit one or more of the following conditions: ?DTC B15A804 is present in current or history. ?Red SOS LED stays on after bulb check. ?Toyota App is inoperative. ?Unable to subscribe to remote services. ?Unable to activate Wi-Fi. ?Depleted 12V vehicle battery when in IG-OFF. A DCM reset and firmware update is now available to address these conditions. Follow the DCM Reset and Firmware Update Procedure in this bulletin to update the firmware. |
| T-SB-0095-20 Rev | 2021-02-01. Service bulletin. EQUIPMENT:ELECTRICAL; ELECTRICAL SYSTEM. TSB: Some 2020 model year Camry, Camry Hybrid, Corolla Hatchback, RAV4, and RAV4 Hybrid vehicles may exhibit one or more of the following conditions: ?Diagnostic Trouble Code (DTC) B15A804 is present in current or history. ?Red SOS LED stays on after bulb check. ?Toyota App does not accept the activation code. ?Toyota App is inoperative. ?SOS call center does not receive the vehicle?s location in a timely manner. ?Toyota App shows an error 42 when trying to execute a command. ?Unable to remote start the vehicle with the key fob (if equipped). ?Unable to subscribe to remote services. ?Unable to activate Wi-Fi. ?Destination Assist is inoperative. Some 2020 ? 2021 model year Camry, Camry Hybrid, Corolla Hatchback, RAV4, and RAV4 Hybrid vehicles and some 2021 model year Avalon, Avalon Hybrid, Corolla, Corolla Hybrid, Sienna Hybrid, and Venza Hybrid vehicles may exhibit one or more of the following conditions: ?DTC B15A804 is present in current or history. ?Red SOS LED stays on after bulb check. ?Toyota App is inoperative. ?Unable to subscribe to remote services. ?Unable to activate Wi-Fi. ?Depleted 12V vehicle battery when in IG-OFF. A DCM reset and firmware update is now available to address these conditions. Follow the DCM Reset and Firmware Update Procedure in this bulletin to update the firmware. |
| T-SB-0113-20 | 2020-12-21. Service bulletin. ELECTRICAL SYSTEM:WIRING:CONNECTORS/PLUGS:ACCESORY POWER OUTLET/JACK/PORT/USB/SAE/CIGARETTE LIGHTER. TSB: Some 2020 ? 2021 model year C-HR, RAV4, RAV4 HV, Sequoia, Tundra and 2021 model year Avalon, Avalon HV, Prius, Prius Prime, and RAV4 Prime vehicles may exhibit inoperative Apple CarPlay® with all iPhone® 12 models. An updated USB port is available to address this condition. Follow the Repair Procedure in this bulletin to address this condition. |
| T-TT-0634-20 | 2020-12-21. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT. TT: Some vehicles may experience an issue related to the DCM, the following information is consolidating the available diagnostic information in one document. |
| T-SB-0110-20 | 2020-12-21. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM. TSB: This bulletin includes basic procedures for performing an at battery rescue charge on high voltage (HV) Ni-MH and Li-ion batteries. This bulletin should be used in conjunction with the applicable model and model year Repair Manual while performing the battery rescue charge. The GRX-5100 should be used wherever the Repair Manual references the Toyota Hybrid System (THS) charger. |
| T-TT-0629-20 | 2020-11-30. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE; COMMUNICATION. TT: Some 2020 ? 2021 model year C-HR, RAV4, RAV4 HV, Sequoia, Tundra and 2021 model year Avalon, Avalon HV, Prius, Prius Prime, and RAV4 Prime vehicles may exhibit inoperative Apple CarPlay® with only iPhone® 12 devices (iPhone® 12, iPhone® 12 Max, iPhone® 12 Pro, or iPhone® 12 Pro Max). |
| T-SB-0039-20 Rev | 2020-11-30. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. TSB: An initialization procedure is required to activate the Entune? 3.0 App Suite Connect for Audio, Audio Plus, and Premium Audio head units before they are used for the first time on new vehicles. The initialization procedure may also be performed under other circumstances, such as following a head unit replacement or after the customer?s personal settings are erased. The initialization procedure requires between 3 and 15 minutes to complete, depending on file size, cellular connection speed, and other factors. Following the initialization procedure, individual Entune? 3.0 apps may periodically update through an over-the-air update system. Updates are either optional or mandatory. The update procedure will take approximately 1 minute for each app requiring an update. Follow the Initialization/Update Procedure in this bulletin to perform the initialization and app updates. |
| T-TT-0625-20 | 2020-11-23. Service bulletin. ELECTRICAL SYSTEM:12V/24V/48V BATTERY. TT: A 12V Battery Discharged and / or Dead condition can be due to multiple causes. In order to properly diagnose and determine the root cause it?s important to follow a structured process to identify any contributing issues and determine the proper remedy. |
| T-SB-0095-20 | 2020-10-26. Service bulletin. EQUIPMENT ADAPTIVE/MOBILITY; ELECTRICAL SYSTEM; EQUIPMENT. TSB: Some 2020 model year Camry, Camry Hybrid, Corolla Hatchback, RAV4, and RAV4 Hybrid vehicles may exhibit one or more of the following conditions: ?Diagnostic Trouble Code (DTC) B15A804 is present in current or history. ?Red SOS LED stays on after bulb check. ?Toyota App does not accept the activation code. ?Toyota App is inoperative. ?SOS call center does not receive the vehicle?s location in a timely manner. ?Toyota App shows an error 42 when trying to execute a command. ?Unable to remote start the vehicle with the key fob (if equipped). ?Unable to subscribe to remote services. ?Unable to activate Wi-Fi. ?Destination Assist is inoperative. Some 2020 ? 2021 model year Camry, Camry Hybrid, Corolla Hatchback, RAV4, and RAV4 Hybrid vehicles and some 2021 model year Corolla, Corolla Hybrid, and RAV4 Prime vehicles may exhibit one or more of the following conditions: ?DTC B15A804 is present in current or history. ?Red SOS LED stays on after bulb check. ?Toyota App is inoperative. ?Unable to subscribe to remote services. ?Unable to activate Wi-Fi. ?Depleted 12V vehicle battery when in IG-OFF. A DCM reset and firmware update is now available to address these conditions. Follow the DCM Reset and Firmware Update Procedure in this bulletin to update the firmware. |
| T-SB-0056-20 Rev | 2020-09-14. Service bulletin. ELECTRICAL SYSTEM; STRUCTURE; EQUIPMENT. TSB: Pre-Delivery Service (PDS) is a critical step in satisfying our new car customers. Customer feedback indicates the following areas deserve special attention when performing PDS: ? Careful inspection for paint chips/scratches and body dents/dings. ? Proper operation of electrical accessories (including interior light, clock, and radio reset). ? Interior cleanliness. ? Proper function of mechanical systems. Customer retention and proper maintenance of vehicles are and have always been a major focus for Toyota. To help remind customers that regular service is essential to the proper maintenance of the vehicle, dealers are required to install a service reminder sticker before delivery. By doing this, customers will be reminded to return to your dealership for service. Your current service reminder sticker may be used. (See PDS Check Sheet item 8 of ?Final Inspection and Cleaning.?) This bulletin contains the PDS procedures which apply specifically to 2021 model year RAV4, RAV4 Hybrid, and RAV4 Prime vehicles. A universal PDS Check Sheet that contains PDS steps that apply to all 2021 model year Toyota vehicles has been developed. To properly perform a complete PDS, you must complete all procedures contained in this TSB as well as the universal PDS Check Sheet. In addition, if the vehicle is stored for over 30 days, be sure to follow Long-Term Vehicle Storage Guidelines. |
| T-SB-0056-20 Rev | 2020-09-14. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM. TSB: Pre-Delivery Service (PDS) is a critical step in satisfying our new car customers. Customer feedback indicates the following areas deserve special attention when performing PDS: ? Careful inspection for paint chips/scratches and body dents/dings. ? Proper operation of electrical accessories (including interior light, clock, and radio reset). ? Interior cleanliness. ? Proper function of mechanical systems. Customer retention and proper maintenance of vehicles are and have always been a major focus for Toyota. To help remind customers that regular service is essential to the proper maintenance of the vehicle, dealers are required to install a service reminder sticker before delivery. By doing this, customers will be reminded to return to your dealership for service. Your current service reminder sticker may be used. (See PDS Check Sheet item 8 of ?Final Inspection and Cleaning.?) This bulletin contains the PDS procedures which apply specifically to 2021 model year RAV4, RAV4 Hybrid, and RAV4 Prime vehicles. A universal PDS Check Sheet that contains PDS steps that apply to all 2021 model year Toyota vehicles has been developed. To properly perform a complete PDS, you must complete all procedures contained in this TSB as well as the universal PDS Check Sheet. In addition, if the vehicle is stored for over 30 days, be sure to follow Long-Term Vehicle Storage Guidelines. |
| T-TT-0617-20 | 2020-08-24. Service bulletin. ELECTRICAL SYSTEM:12V/24V/48V BATTERY. TT: The all new RAV4 Prime launched in mid-June 2020. An all new high voltage battery was introduced with this model and will require several new SSTs for diagnosis and repair. Some of these tools will be made available via the Toyota Loan Tool Program, while others will be distributed as Essential. These tools will have limited availability at launch and as a result, an Interim Strategy has been developed to make them available to dealers. This Interim Strategy is listed below in the ?Recommendations? section. Estimated timing for the essential tools to be distributed and the loan tools to be permanently available to dealers is September 2020*. An additional communication will be sent to announce when these tools become available. *The GRX-5100 cable is estimated to be available in Q4 2020 |
The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.