WenmarOpen by Wenmar Pro

Service bulletins for the 2021 Toyota Highlander

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

231 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

Only bulletins with component: Engine are shown. Show all

Bulletins, newest first
T-TT-0702-22 Rev2024-03-18. Service bulletin. ENGINE AND ENGINE COOLING. TT: Some 2020-2022 vehicles equipped with North American Produced (NAP) A25A-FKS/FXS engines may experience an oil leak from the head/valve cover gasket. This issue is currently under investigation.
LSB0065232024-01-29. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV); UNKNOWN OR OTHER. TT: Engine Oil Leak between the Lower Oil Pan and Crank Case
TSB0092232023-12-26. Service bulletin. ENGINE AND ENGINE COOLING. Toyota vehicles equipped with an A25A-FKS or A25A-FXS engine may exhibit reduced engine power and/or a MIL ON condition
TSB0051232023-10-16. Service bulletin. ENGINE; UNKNOWN OR OTHER. OBSOLETE NOTICE August 17, 2023: This bulletin is no longer applicable and is now obsolete
T-TT-0726-232023-08-28. Service bulletin. BACK OVER PREVENTION; ENGINE AND ENGINE COOLING. TT: Some 2021 - 2023 Highlander HV, RAV4 HV and Sienna HV vehicles equipped with Rear Motor Generator, MGR (Q610), may duplicate an abnormal noise (Drone, Growl, Humming, and/or other) from the MGR at various vehicle speeds and normal drive conditions. Please contact TAS for diagnostic instructions to aid in resolution of the condition.
TSB-0033-232023-07-31. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL; FUEL SYSTEM, GASOLINE. TSB: Some 2020 ? 2023 model year Highlander Hybrid and 2021 ? 2023 model year RAV4 Hybrid, RAV4 Prime, Sienna Hybrid, and Venza Hybrid vehicles may exhibit a MIL ON condition with one or both of the following Diagnostic Trouble Codes (DTCs) present: ?P24517F ? Evaporative Emission System Switching Valve Actuator Stuck Off. ?P14502A ? Fuel Tank Pressure Sensor Signal Stuck in Range.
T-TT-0694-222023-06-26. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM). TT: After jump-starting, the vehicle may experience a no-start condition and multiple DTCs including U010087. Upon investigation, it is found that the engine ECU has been damaged and needs to be replaced. In several cases, it was found that the cause of the ECU damage was improper jump starting. Further investigation found that ECU damage may occur if the jumper cables are hooked up on or around the engine ECU or ECU mounting bracket
22TE09-12023-06-26. Service bulletin. ELECTRICAL SYSTEM:WIRING; ENGINE AND ENGINE COOLING. TI: TECHNICAL INSTRUCTIONS FOR CUSTOMER SUPPORT PROGRAM 22TE09 HV FLOOR UNDER WIRE HARNESS AND REAR TRACTION MOTOR CABLE CORROSION CERTAIN 2020 ?2022 MODEL YEAR HIGHLANDER HYBRID AWD
22TE092023-06-26. Service bulletin. ELECTRICAL SYSTEM:WIRING; ENGINE AND ENGINE COOLING. DP: Although the HV Floor Under Wire Harness and Rear Traction Motor Cable is covered by Toyota?s New Vehicle Limited Warranty for 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to excessive corrosion to the wire harness connections at the Rear Motor Generator. Excessive corrosion can cause AM Radio Static during certain drive cycles, or, following certain warning indicators, the vehicle may not start.
TTT0702222023-05-01. Service bulletin. ENGINE AND ENGINE COOLING. TT: Some 2020-2022 vehicles equipped with North American Produced (NAP) A25A-FKS/FXS engines may experience an oil leak from the head/valve cover gasket. This issue is currently under investigation.
T-TT-0699-22 Rev2023-04-17. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICAL. TT: Some Model Year 2018-2023 vehicles equipped with A25A-FKS/FXS or M20A-FKS/FXS engines may display the following message ?Engine Maintenance Required Visit Your Dealer? on the combination meter
T-TT-0726-232023-04-17. Service bulletin. ENGINE AND ENGINE COOLING; BACK OVER PREVENTION. TT: Some 2021 - 2023 Highlander HV, RAV4 HV and Sienna HV vehicles equipped with Rear Motor Generator, MGR (Q610), may duplicate an abnormal noise (Drone, Growl, Humming, and/or other) from the MGR at various vehicle speeds and normal drive conditions. Please contact TAS for diagnostic instructions to aid in resolution of the condition.
T-TT-0723-232023-04-17. Service bulletin. ENGINE AND ENGINE COOLING. TT: Some 2021 to 2023 MY vehicles equipped Rear Motor Generator, MGR (Q610) may experience an oil leak concern. This issue is currently under investigation
T-TT-0690-22 Rev2023-04-17. Service bulletin. ENGINE AND ENGINE COOLING. TT: On some 2021-2022MY Highlander HV, RAV4 HV, RAV4 Prime and Venza models, the connector cover for the Under Floor Wire Harness for the Rear Motor Generator may have the appearance of being damaged or missing
T-SB-0115-222023-01-17. Service bulletin. ENGINE AND ENGINE COOLING; FUEL SYSTEM, GASOLINE. TSB: Some 2019 ? 2022 model year Avalon, 2018 ? 2023 model year Camry, 2017 ? 2022 model year Highlander, 2017 ? 2020 model year Sienna, and 2016 ? 2023 model year Tacoma vehicles equipped with a 2GR-FKS engine may exhibit a knocking noise from the vacuum pump at idle. Follow the Repair Procedure in this bulletin to address this condition
T-TT-0699-22 Rev2022-10-17. Service bulletin. ENGINE AND ENGINE COOLING. TT: Some Model Year 2018-2021 vehicles equipped with A25A-FKS/FXS or M20A-FKS/FXS engines may display the following message ?Engine Maintenance Required Visit Your Dealer? on the combination meter.
T-TT-0708-222022-10-17. Service bulletin. ENGINE AND ENGINE COOLING; ELECTRICAL SYSTEM. TT: Some Model Year 2018-2022 vehicles equipped with A25A-FKS or A25A-FXS engines may experience a MIL ON condition with the following DTCs: P043F00, P043E00, P24007E, P24007F, P24187E
TTT0699222022-10-17. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE. TT: Some Model Year 2018-2021 vehicles equipped with A25A-FKS/FXS or M20A-FKS/FXS engines may display the following message ?Engine Maintenance Required Visit Your Dealer? on the combination meter.
T-TT-0694-22 Rev2022-09-15. Service bulletin. ENGINE AND ENGINE COOLING. TT: After jump-starting, the vehicle may experience a no-start condition and multiple DTCs including U010087. Upon investigation, it is found that the engine ECU has been damaged and needs to be replaced (Fig 1). In several cases, it was found that the cause of the ECU damage was improper jump starting. Further investigation found that ECU damage may occur if the jumper cables are hooked up on or around the engine ECU or ECU mounting bracket
TTT0698222022-09-15. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR. TT: Some 17-22MY Highlander and 17-20MY Sienna vehicles may experience a MIL ON condition with DTC(s) P042000, and/or P043000. This issue could involve deteriorated catalyst material from the bank 1 or bank 2 catalytic converter.
T-TT-0702-222022-08-15. Service bulletin. ENGINE AND ENGINE COOLING. TT: Some 2020-2022 vehicles equipped with North American Produced (NAP) A25A-FKS/FXS engines may experience an oil leak from the head/valve cover gasket. This issue is currently under investigation.
TTT0685222022-06-21. Service bulletin. ENGINE AND ENGINE COOLING. TT: Some 17-22MY Highlander, and 17-20MY Sienna vehicles with engine serial numbers that start with F or G may experience an engine oil leak condition from the No.2 Oil pan. This issue is currently under investigation. Please take detailed pictures of the oil pan leak condition before repair. If condition is on applicable vehicles with engine serial numbers that do not start with F or G, disregard, and proceed with normal repair.
TTT0690222022-06-21. Service bulletin. ENGINE AND ENGINE COOLING; EQUIPMENT:ELECTRICAL. TT: On some 2021-2022MY Highlander HV, RAV4 HV, RAV4 Prime and Venza models, the connector cover for the Under Floor Wire Harness for the Rear Motor Generator may have the appearance of being damaged or missing
T-SB-0015-21 Rev2022-06-13. Service bulletin. ENGINE AND ENGINE COOLING. TSB: This Service Bulletin provides a procedure to properly perform the Techstream ?Control the Injection Mode? active test in some 2016 ? 2022 model year Toyota vehicles equipped with an FKS engine
T-TT-0686-222022-04-18. Service bulletin. ENGINE AND ENGINE COOLING. TT: The purpose of this Tech Tip is to provide diagnostic tips to prevent misdiagnosis of the following DTC?s and prevent repeat repairs. One or more of the Heated Oxygen Sensors (O2) or Air Fuel ratio sensor (A/F) DTCs below could set due to a leaking exhaust system. If you encounter a vehicle with any of these DTCs

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.