WenmarOpen by Wenmar Pro

Service bulletin T-TT-0686-22

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

The communication, as NHTSA indexes it (as of 2026-10-19)
TypeService bulletin
NHTSA id10210372
Published by NHTSA2022-04-18
Manufacturer's numberT-TT-0686-22
Manufacturer's date2022-03-08
NHTSA componentENGINE AND ENGINE COOLING

NHTSA's summary

TT: The purpose of this Tech Tip is to provide diagnostic tips to prevent misdiagnosis of the following DTC?s and prevent repeat repairs. One or more of the Heated Oxygen Sensors (O2) or Air Fuel ratio sensor (A/F) DTCs below could set due to a leaking exhaust system. If you encounter a vehicle with any of these DTCs

The document

The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.

Components

Engine

Vehicles listed
TOYOTA AVALON2019, 2020, 2021, 2022
TOYOTA CAMRY2018, 2019, 2020, 2021, 2022
TOYOTA HIGHLANDER2017, 2018, 2019, 2020, 2021, 2022
TOYOTA HIGHLANDER HYBRID2017, 2018, 2019 (the catalog's model; the bulletin names a series or trim of it)
TOYOTA SIENNA2017, 2018, 2019, 2020
TOYOTA TACOMA2016, 2017, 2018, 2019, 2020, 2021, 2022

Listing a model year does not mean every vehicle of it is concerned: the document says which.

Recalls for the same vehicles and component
20V1620002020-03-19. ENGINE; FUEL SYSTEM, GASOLINE:DELIVERY
20200392020-02-06. Engine
20V0640002020-02-06. ENGINE AND ENGINE COOLING
20181482018-03-28. Engine
18V2000002018-03-28. ENGINE AND ENGINE COOLING:ENGINE
17V3560002017-06-01. ENGINE

A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.

Other bulletins for the same vehicles and component
T-SB-0110-20 Rev22026-09-09. Service bulletin. OBSOLETE NOTICE August 20, 2026: This bulletin is now obsolete. Please see T-SB-0051-26.
T-SB-0051-262026-09-09. Service bulletin. This bulletin includes basic procedures for performing a rescue charge at battery on high voltage (HV) Ni-MH and Li-ion batteries.
24TE042026-09-09. Warranty extension. Although the flow shut-off valve is covered by Toyota’s New Vehicle Limited Warranty for 36 months or 36,000 miles (whichever comes first), we at Toyota care about the customers’ ownership experience. Toyota is providing coverage for repairs related to Flow Shut-off Valve Coolant Leak.
T-SB-0023-262026-05-08. Service bulletin. Some customers may experience a rough running engine with a MIL ON P140018 DTC. Upon further inspection, a loose C90/C27 connector pin at the EGR valve may be found. To correct this concern, please reference the repair section of this TSB.
T-SB-0104-21 Rev22026-03-07. Service bulletin. OBSOLETE NOTICE February 27, 2026: This bulletin is no longer applicable and is now obsolete.
T-SB-0009-262026-03-07. Service bulletin. This bulletin includes basic procedures for performing a rescue charge on Ni-MH high voltage (HV) batteries. This bulletin should be used in conjunction with the applicable model and model year Repair Manual while performing a rescue charge. The GRX-5100 should be used wherever the Repair Manual references the Toyota Hybrid System (THS) charger.
T-SB-0119-15 Rev22026-03-07. Service bulletin. OBSOLETE NOTICE February 13, 2026: This bulletin is now obsolete. Please see T-SB-0009-26.
24TE042025-09-09. Service campaign. The specific condition covered by this program is for a small engine coolant leak that can occur from the flow shut-off valve that can allow coolant to drip on other parts of the vehicle. This can cause "Engine Maintenance Required" to be displayed on the instrument cluster or cause the A/C not to function normally. Although the flow shut-off valve is covered by Toyota’s New Vehicle Limited Warranty for 36 months or 36,000 miles (whichever comes first), we at Toyota care about the customers’ ownership experience. Toyota is providing coverage for repairs related to Flow Shut-off Valve Coolant Leak.
T-SB-0112-24 Rev22025-07-10. Service bulletin. Some 2018 – 2021 model year Toyota vehicles equipped with an A25A-FKS, A25A-FXS, or M20A-FKS engine may exhibit a condition in which an “Engine Maintenance Required” message is displayed in the Multi-Information Display (MID). Additionally, the vehicle will exhibit DTC(s) P268111 (Engine Coolant Bypass Valve Circuit Short to Ground) and/or P268115 (Engine Coolant Bypass Valve Circuit Short to Battery or Open).
T-TT-0784-25 Rev12025-07-10. Service bulletin. Some ECUs can set a DTC that is common with other ECUs. This can lead to accidental use of the wrong repair manual when diagnosing these type of DTCs.