Service bulletins for the 2008 Toyota Highlander
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
302 on file from NHTSA, as of 2026-10-19.
By type
By component
By trouble code
By topic
| HR1_Dealer Lette | 2018-04-02. Service bulletin. AIR BAGS. Dealer Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. |
|---|---|
| HR1_Region Lette | 2018-04-02. Service bulletin. AIR BAGS. Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. |
| T-SB-0038-15 OBS | 2018-04-02. Service bulletin. LATCHES/LOCKS/LINKAGES:DOORS:LATCH. TSB: OBSOLETE NOTICE March 17, 2017: This bulletin is now obsolete. Please see T-SB-0191-17. |
| T-SB-0033-14 | 2018-04-02. Service bulletin. ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS. Some vehicles in particular geographic areas may exhibit a condition where the HVAC Evaporator Drain Hose has become obstructed with an insect nest. An insect repellent drain hose tip (ARINIX® Tip) is now available to help minimize future occurrences of this environmental condition. For some models, a new drain hose is required to properly fit the ARINIX® Tip. Follow the procedures in this bulletin for proper handling and installation of this optional service part. |
| T-SB-0191-17 | 2018-04-02. Service bulletin. LATCHES/LOCKS/LINKAGES:DOORS:LATCH. TSB: Some 2008 ? 2013 model year Highlander and Highlander HV vehicles may exhibit a condition where the Power Back Door does not close properly. The Back Door may get to the fully closed position and then reverse to the open position. In other cases, the door may close, but a pop or clunk noise is heard when the door latch reaches the striker. Use the following information to inspect the Power Back Door and address this condition. |
| T-TT-0365-15 Rev | 2018-04-02. Service bulletin. ELECTRICAL SYSTEM:12V/24V/48V BATTERY. TT: A vehicle may arrive to the dealer with a MIL ?ON? condition and P0A80 or P1AC000 stored in the memory. Some cases have been identified with internal modification done to the HV Battery. Modified or altered parts are not covered under warranty. |
| T-SB-0187-12_Rev | 2018-04-02. Service bulletin. TIRES. TSB: REVISION NOTICE February 12, 2018 Rev2: ? Applicability has been updated to include 2015 ? 2018 model year vehicles. January 23, 2014 Rev1: ? Applicability has been updated to include 2013 ? 2014 model year vehicles. Any previous printed versions of this bulletin should be discarded. Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to service. With a conventional tire it is not possible to drive for an extended amount of time with the tire at low pressures as damage to the tire may occur. With run-flat tires, due to reinforced sidewalls, it is possible to drive for up to 100 miles at speeds less than 55 mph with little or no damage to the tire. The U.S. Tire Manufacturers Association (UTSMA) provides guidelines and recommendations for tire repair and replacement. It also provides information related to: ? Basic tire information ? Tire maintenance and safety ? Driver education, tire safety curriculum. |
| ZG4_POL17-04_War | 2018-04-02. Service bulletin. STRUCTURE:BODY:HATCHBACK/LIFTGATE. Warranty Policy Bulletin POL17-04: REVISED March 01, 2017: Toyota has received reports of customer concerns in which the power back door does not close properly. In some cases, the power back door may reach the fully closed position and then reverse to the open position. In certain instances, the power back door closes, but produces a pop or clunking noise. |
| ZG4 POL17-04 War | 2018-04-02. Service bulletin. STRUCTURE:BODY:HATCHBACK/LIFTGATE. Warranty Policy Bulletin POL17-04: Toyota has received reports of customer concerns in which the power back door does not close properly. In some cases, the power back door may reach the fully close position and then reverse to the open position. In certain instances, the power back door closes, but produces a pop or clunking noise. |
| ZG4 Dealer Packa | 2018-04-02. Service bulletin. STRUCTURE:BODY:HATCHBACK/LIFTGATE. Dealer Package: Certain 2008 - 2013 model year Highlander and Highlander Hybrid vehicles may exhibit a condition where the Power Back Door does not close properly. In some cases, the Power Back Door may reach the fully closed position and then reverse to the open position. In other cases, the Power Back Door closes, but produces a pop or clunk noise. |
| ZG4_Dealer Email | 2018-04-02. Service bulletin. STRUCTURE:BODY:HATCHBACK/LIFTGATE. Dealer Email: Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for the Power Back Door on certain 2008 - 2013 model year Highlander and Highlander Hybrid vehicles. |
| ZG4 Region Lette | 2018-04-02. Service bulletin. STRUCTURE:BODY:DOOR. Region Letter: Certain 2008 - 2013 model year Highlander and Highlander Hybrid vehicles may exhibit a condition where the Power Back Door does not close properly. In some cases, the Power Back Door may reach the fully closed position and then reverse to the open position. In other cases, the Power Back Door closes, but produces a pop or clunk noise. |
| ZG4_Region Email | 2018-04-02. Service bulletin. STRUCTURE:BODY:DOOR. Region Email: Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for the Power Back Door on certain 2008 - 2013 model year Highlander and Highlander Hybrid vehicles. |
| T-SB-0304-17_Rev | 2018-04-02. Service bulletin. EQUIPMENT. TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, and T-SB-0144-08. Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, and T-SB-0144-08 are obsolete and any printed versions should be discarded. Be sure to review the entire content of this bulletin before proceeding. REVISION NOTICE January 11, 2018 ? The Supersession Notice has been updated. Any previous printed versions of this bulletin should be discarded. Vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) may be available from Toyota, provided the request meets one of the criteria listed in this Service Bulletin. |
| T-SB-0187-12_Rev | 2018-03-12. Service bulletin. TIRES. TSB: REVISION NOTICE February 12, 2018 Rev2: ? Applicability has been updated to include 2015 ? 2018 model year vehicles. January 23, 2014 Rev1: ? Applicability has been updated to include 2013 ? 2014 model year vehicles. Any previous printed versions of this bulletin should be discarded. Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to service. With a conventional tire it is not possible to drive for an extended amount of time with the tire at low pressures as damage to the tire may occur. With run-flat tires, due to reinforced sidewalls, it is possible to drive for up to 100 miles at speeds less than 55 mph with little or no damage to the tire. The U.S. Tire Manufacturers Association (UTSMA) provides guidelines and recommendations for tire repair and replacement. It also provides information related to: ? Basic tire information ? Tire maintenance and safety ? Driver education, tire safety curriculum. |
| T-SB-0162-13_Rev | 2018-02-21. Service bulletin. HYBRID PROPULSION SYSTEM; ELECTRICAL SYSTEM. TSB: REVISION NOTICE January 05, 2018 Rev1: ? Applicability has been updated to include 2012 ? 2017 Camry HV and Prius C, 2015 ? 2017 Prius V, 2006 ? 2017 Highlander HV, 2010 ? 2016 Prius, and 2016 ? 2017 RAV4 HV model year vehicles. ? The Repair Procedure section has been updated. Any previous printed versions of this bulletin should be discarded. Some 2006 ? 2017 Highlander HV, 2010 ? 2016 Prius, 2012 ? 2017 Camry HV, Prius C and Prius V, and 2016 ? 2017 RAV4 HV model year vehicles used under certain severe operating conditions may exhibit an excessive buildup of dust, lint, or other debris in the HV battery cooling fan, which can reduce the efficiency of the HV battery cooling system. Follow the Repair Procedure in this bulletin to address this condition. |
| T-SB-0134-16_Rev | 2017-11-14. Service bulletin. EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL. TSB: REVISION NOTICE October 30, 2017 Rev1: * Applicability has been updated to include 2018 model year vehicles. SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0012-13. Flash reprogramming allows the Electronic Control Unit (ECU) software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin details the Techstream ECU flash reprogramming process and outlines use of the Technical Information System (TIS) and the Calibration Update Wizard (CUW). Flash calibration updates can only be applied to the vehicle/ECU combination for which they are intended. ECUs have internal security that will not allow them to be programmed with another ECU's information. |
| T-SB-0304-17 | 2017-11-14. Service bulletin. STRUCTURE:BODY:DOOR. TSB: Vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) may be available from Toyota, provided the request meets one of the criteria listed in this Service Bulletin. |
| T-SB-0191-17_Rev | 2017-08-15. Service bulletin. STRUCTURE:BODY:DOOR; STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS; ELECTRICAL SYSTEM. TSB: REVISION NOTICE July 13, 2017 Rev1: The Repair Procedure, Parts Information and Required Tools & Equipment sections have been updated. SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0038-15. The entire bulletin has been updated. Some 2008 - 2013 model year Highlander and Highlander HV vehicles may exhibit a condition where the Power Back Door does not close properly. The Power Back Door may get to the fully closed position and then reverse to the open position. In other cases, the door may close, but a pop or clunk noise is heard when the door latch reaches the striker. |
| T-TT-0414-16 | 2017-08-14. Service bulletin. EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.; EQUIPMENT:ELECTRICAL. TT: Some customers may encounter Bluetooth® connectivity concerns such as: *Difficulty to pair the phone. *Intermittent Bluetooth® failure to connect to the vehicle when first turning on the vehicle. *Various Bluetooth® Audio functions are no longer functioning with customer's phone such as ability to change the track using the steering wheel controls. |
| T-SB-0083-13 Rev | 2017-08-14. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER. TSB: The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts. |
| T-SB-0043-14 Rev | 2017-08-14. Service bulletin. EQUIPMENT:ELECTRICAL. TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to reset a vehicle Immobilizer or Smart Key system. NOTE: There are new security provisions required to obtain a Reset Pass-Code. It is critical that the instructions for this new process are reviewed BEFORE attempting to get a Pass-Code in the new system. |
| T-SB-0101-11 Rev | 2017-08-14. Service bulletin. ELECTRICAL SYSTEM. TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or other compounds that may contaminate electrical contacts, and therefore increase electrical resistance and decrease switch performance. The use of any cleaners or fluids may increase the risk of further damage to electrical components. |
| T-SB-0142-13 Rev | 2017-08-14. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER. TSB: Some 2004 - 2015 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bulletin to minimize the odors experienced. |
| T-TT-0268-13 Rev | 2017-08-14. Service bulletin. EQUIPMENT:ELECTRICAL; EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.. TT: Some customers may encounter Bluetooth® connectivity concerns such as: * Difficulty to pair the phone. * Intermittent Bluetooth® failure to connect to the vehicle when first turning on the vehicle. * Various Bluetooth® Audio functions are no longer functioning with customer's phone such as ability to change the track using the steering wheel controls. These concerns can be caused by changes made on the customer's phone. Make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or if they have restored their phone data/settings recently. |
The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.