WenmarOpen by Wenmar Pro

Service bulletins for the 2015 Ram 5500

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

331 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

Only bulletins with component: Lighting are shown. Show all

Bulletins, newest first
09001222023-01-09. Service bulletin. ELECTRICAL SYSTEM; EXTERIOR LIGHTING. Cummins 6.7L Turbocharger Actuator - X93 Warranty Extension This bulletin involves replacing the turbocharger actuator with an updated actuator. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technicianmay find that one or more of the following Diagnostic Trouble Codes (DTCs) have been set: U010C - Lost Communication With Turbocharger/Supercharger Control Module. P003A - Turbocharger Boost Control Module Position Exceeded Learning Limit. P00AF - Turbocharger Boost Control Module Performance. P0046 - Turbocharger Boost Control Circuit Performance. P0234 - Turbocharger Overboost Condition.
09001222022-10-17. Service bulletin. EXTERIOR LIGHTING; ELECTRICAL SYSTEM. Cummins 6.7L Turbocharger Actuator - X93 Warranty Extension This bulletin involves replacing the turbocharger actuator with an updated actuator. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or more of the following Diagnostic Trouble Codes (DTCs) have been set: U010C - Lost Communication With Turbocharger/Supercharger Control Module. P003A - Turbocharger Boost Control Module Position Exceeded Learning Limit. P00AF - Turbocharger Boost Control Module Performance. P0046 - Turbocharger Boost Control Circuit Performance. P0234 - Turbocharger Overboost Condition.
18113222022-09-26. Service bulletin. ELECTRICAL SYSTEM; EXTERIOR LIGHTING; FUEL SYSTEM, GASOLINE; SERVICE BRAKES, HYDRAULIC; FUEL SYSTEM, DIESEL; BACK OVER PREVENTION. Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. There will be a choice between two calibrations. One for vehicles that utilize an ammonia sensor and one for vehicles that have hadthe ammonia sensor removed. Be sure to select the correct software based on vehicle configuration.Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Uponfurther investigation the technician may find that one or more of the following DTCs have been set: P064F - Unauthorized Software/Calibration Detected. P202E - (Diesel Exhaust Fluid) Reductant Injector Performance. P24A5 - EGR Cooler Bypass Bank 1 Control Stuck. U0001 - Can C Bus. P20EE - Selective Catalytic Reduction (SCR) NOx Catalyst Efficiency BelowThreshold - Bank 1 (For ammonia sensor equipped vehicles). P1C55 - NOx Sensor Intermittent - Bank 1 Sensor 1 (For ammonia sensor deletedsystems only). P218F - Reductant No Flow Detected. P242F - Diesel Particulate Filter Restriction - Ash Accumulation. U110E - Lost Ambient Temperature Message. P205E - (Diesel Exhaust Fluid) Reductant Tank Temperature Sensor CircuitIntermittent (setting when the block heater is plugged in). P20E8 - (Diesel Exhaust Fluid) Reductant Pressure Too Low. U3017 - Control Module Timer/Clock Performance. U1421 - Implausible Ignition Key Off Time Received. P2281 - Air Leak Between MAF And Throttle Body. In addition, the following software enhancements are also available: A/C pressure sensor update. wiTECH engine cooling fan actuation test update. Ambient air temperature improvements. Operational improvement for dual alternators. Selective Catalytic Reduction (SCR) efficiency scan tool test improvement. Fuel filter minder calibration changes. wiTECH Fuel Pressure Override and Fuel System Run Up test improvements. Exhaust Gas Recirculation (EGR) system improvement to help prevent freezeup. Diesel Exhaust Fluid (DEF) system enhancement during stationary regeneration.
0900122REVA2022-09-26. Service bulletin. EXTERIOR LIGHTING; ELECTRICAL SYSTEM. Cummins 6.7L Turbocharger Actuator - X93 Warranty Extension This bulletin involves replacing the turbocharger actuator with an updated actuator. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technicianmay find that one or more of the following Diagnostic Trouble Codes (DTCs) have been set: U010C - Lost Communication With Turbocharger/Supercharger Control Module. P003A - Turbocharger Boost Control Module Position Exceeded Learning Limit. P00AF - Turbocharger Boost Control Module Performance. P0046 - Turbocharger Boost Control Circuit Performance. P0234 - Turbocharger Overboost Condition.
21017192022-09-15. Service bulletin. FUEL SYSTEM, GASOLINE; AIR BAGS; POWER TRAIN; ELECTRICAL SYSTEM; FUEL SYSTEM, DIESEL; EXTERIOR LIGHTING; BACK OVER PREVENTION. Flash: Transmission Control Module (TCM) Updates This bulletin involves reprogramming the TCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the followingDTC has been set:U1111-00 - Lost Odometer Message(DD, DF, and DP with Diesel Engine Only). In addition, the customer may notice one or more of the following conditions: The customer may notice a harsh 2-3 and/or 3-4 shift(2017 MY D2 with ETK 6.7L Diesel and DF2 Transmission Only). 1-2 hard shift. 3-4 flare issue fix. Trans quick learn fix(Gas Engine Only). Transmission oil temperature light illumination during high engine and tow loads. Less than desired towing performance while using cruise control. Harsh engagement while shifting from neutral to drive, neutral to reverse,or park to reverse with vehicle still in motion (rolling garage shift). Engine flare during 2-1 tip in downshift. Less than desired shift quality during 6-5 and 5-4 coasting downshifts. Delayed downshifts in Tow/Haul mode while driving down grades. Less than desired transmission shift performance when transitioning froma low traction to high traction surfaces i.e. ice covered road to clear pavement. Less than desired shift points during light pedal and Wide Open Throttle(WOT) operation or while in Tow/Haul and engine brake modes. 1-2 upshift shudder correction(Diesel engine and DF2 Transmission Only). A harsh 1-2 upshift(DF2 Transmission Only). Excessive gear shifting(DF2 Transmission Only). Harsh 2-1 downshift(DF2 Transmission Only). Delayed engagement when shifting from neutral to drive, neutral to reverse,or park to reverse (garage shifts)(DF2 Transmission Only). Audible squawk noise on 4-3 downshift(DF2 Transmission Only). Poor vehicle acceleration in first gear with vehicle fully loaded(DF2 Transmission Only). MIL illumination with no defect found forDTC P253D - PTO Sense Circuit High(DF2 Transmission Only).
18-073-212022-08-22. Service bulletin. EXTERIOR LIGHTING; FUEL SYSTEM, GASOLINE; FUEL SYSTEM, DIESEL. Diesel Injector Freezing This bulletin involves installing a insulator over the Diesel Exhaust Fluid (DEF) injector. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or more of the following Diagnostic Trouble Codes (DTCs) have been set: P218F - Reductant No Flow Detected. P202E - (Diesel Exhaust Fluid) Reductant Injector Performance. The customer will not notice any drivability issues associated with these DTCs. These DTCs may set when the vehicles is parked for a long time and the ambient temperatures are below -11 °C (12 °F).
0900122 REVA2022-05-31. Service bulletin. ELECTRICAL SYSTEM; ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER; EXTERIOR LIGHTING. Cummins 6.7L Turbocharger Actuator - X93 Warranty Extension This bulletin involves replacing the turbocharger actuator with an updated actuator. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technicianmay find that one or more of the following Diagnostic Trouble Codes (DTCs) have been set: U010C - Lost Communication With Turbocharger/Supercharger Control Module. P003A - Turbocharger Boost Control Module Position Exceeded Learning Limit. P00AF - Turbocharger Boost Control Module Performance. P0046 - Turbocharger Boost Control Circuit Performance. P0234 - Turbocharger Overboost Condition.
124082018-11-26. Service bulletin. EXTERIOR LIGHTING:TAIL LIGHTS. TAILLIGHT.
68174064A2018-11-26. Service bulletin. EXTERIOR LIGHTING:HEADLIGHTS. Headlamp Assembly If the headlamp assembly is being replaced, please also replace the harness attached to the headlamp. Engineering would like to have both parts returned for analysis. Also, please take a picture of the parts and email the picture, a short discription of the issue, and the last 8 digits of the VIN to Brigitte.Wicks@fcagroup.com. Thank you.
08-030-152018-09-24. Service bulletin. EXTERIOR LIGHTING:HEADLIGHTS; EXTERIOR LIGHTING. Auto Headlamp Enhancements This bulletin involves checking Tunnel Detection values and performing a vehicle reconfiguration if needed. The customer may experience when exiting a dark parking structure or dark tunnel the auto headlamps may not turn off. The customer may also experience when driving on an over cast day the auto headlamps may cycle on and off frequently.
18-023-162018-06-11. Service bulletin. EXTERIOR LIGHTING; ELECTRICAL SYSTEM. Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination or one or more of the following conditions. Upon further investigation the technician may find the following Diagnostic Trouble Codes (DTCs) set in the PCM memory:
228432018-06-11. Service bulletin. EXTERIOR LIGHTING:TAIL LIGHTS; EXTERIOR LIGHTING. Inspect and Return: Lamp Assy - Tail Light Rt/L You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of following part numbers: 68110016AC, 68110016AD, 68110016AE, 68110017AD, 68236104AC, 68236105AB. See attachments for identifying suspect stock. Please return suspect parts back to your facing depot using Return Code 02, before 31 August, 2016.
171912018-06-11. Service bulletin. EXTERIOR LIGHTING:HEADLIGHTS; EQUIPMENT. You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 68174065AE. See attachments for identifying suspect stock. Please return suspect parts back to your facing depot using Return Code 02, before 11 July, 2016. Return any open orders in process too. Direct all questions via email to mopardmail@fcagroup.com.
309482018-06-11. Service bulletin. EQUIPMENT; INTERIOR LIGHTING. Molding Assy ?Frt door day light opening Rt/Lt: Return You have been identified as either having stock, or have stock in transit to your dealership. Please return all suspect stock of following part numbers: 57010364AI, 57010365AI, 57010504AJ, 57010505AJ, 68224368AB, 68224369AB. Please return suspect parts back to your facing depot using Return Code 02, before 17 April, 2017.

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.