WenmarOpen by Wenmar Pro

Service bulletins for the 2021 Ram 3500

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

585 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

By topic

Bulletins, newest first
90A Combo Rev12024-07-03. Service campaign. UNKNOWN OR OTHER. Customer Satisfaction Notification 90A Diesel Exhaust Fluid
S1408000384 REV.F2024-07-02. Service bulletin. ELECTRICAL SYSTEM; ENGINE. "Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On "
03-006-242024-07-02. Service bulletin. POWER TRAIN. "Rear Axle Vibration Shudder Or Chatter Customers may experience the following: ● A chatter, shudder, or vibration from the rear axle during turns. NOTE: This may happen more as the vehicle ages, especially if the vehicle is used extensively for towing or hauling heavy loads. The cause of the concern may be due to degradation of the rear axle fluid. It is very important to follow the routine maintenance schedules on these vehicles when it comes to changing the rear axle fluid if the vehicle is used primarily for towing or hauling heavy loads. If you experience a vehicle with the above condition, please perform the proper maintenance procedures for the rear axle and replace the fluid first before replacing any hardware components. NOTE: This service bulletin is only applicable to vehicles that have no history of an axle fluid replacement. If the vehicle usage includes police, taxi, fleet, off-road or frequent trailer towing, regular axle fluid changes are required every 3 years or 30,000 miles (whichever comes first) per the Maintenance Schedule in the vehicle Owner's Manual. This bulletin involves changing the rear axle lube to possibly address a chatter, shudder or vibration."
14-005-242024-07-02. Service bulletin. UNKNOWN OR OTHER. "Diesel Exhaust Fluid (DEF) Fluid Freezing **Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set the following Diagnostic Trouble Code (DTC):** ● P203E-00 - Reductant Level Sensor 1 Circuit Intermittent-Erratic. Customers may also experience one or more of the following: ● Repeated freeze/thaw cycles of the urea tank to cause solid DEF crystals to form and settle on the focus tube, blocking the level sensor signal. ● Rapid temperature swings from below freezing to above freezing causing an incomplete thaw of the DEF tank. When the vehicle is powered on, the diagnostic is enabled due to thawed DEF at the tank bottom surface, but the fluid in the center is still partially frozen. ● Not following the proper DEF fill procedure and overfilling the tank.** This bulletin involves replacing the urea delivery module and grade vent valve and updating the Dosing Control Unit (DCU) software."
960762024-07-02. Other. VISIBILITY/WIPER. MOTOR - WINDSHIELD WIPER & WIPERUNIT - WINDSHIELD WIPER
940062024-06-27. Other. VISIBILITY/WIPER. WIPERUNIT - WINDSHIELD WIPER, BLADE - FRONT WIPER
989272024-06-26. Other. VISIBILITY/WIPER. MOTOR - WINDSHIELD WIPER & WIPERUNIT - WINDSHIELD WIPER
940062024-06-26. Other. STRUCTURE:BODY. WIPERUNIT - WINDSHIELD WIPER, BLADE - FRONT WIPER
988612024-06-25. Other. STRUCTURE:BODY. WIPERUNIT - WINDSHIELD WIPER, BLADE - FRONT WIPER.
S1625000004 REV.A2024-06-05. Service bulletin. ENGINE; UNKNOWN OR OTHER. On Board Diagnosis (OBD) Monitor Readiness Information
S1908000050 REV.A2024-06-05. Service bulletin. ELECTRICAL SYSTEM. Checking Radio Software Level On A VP2 Radio
S2408000015 REV.B2024-06-04. Service bulletin. ELECTRICAL SYSTEM. Remote Keyless Entry (RKE) Button Functions Does Not Work, Intermittent Vehicle Response When Using the RKE, Key Not Programmed
9100338REV12024-06-04. Service bulletin. ENGINE. "GENERATOR Engine Prior to alternator/generator removal: 1. Inspect & check all electrical connections to the alternator a. 2-way connector containing field control circuit & alternator sense voltage circuit. b. Unplug & plug-in the 2-way connector for field & sense circuit. Verify the connection is tight & check for any bent pins in alternator connector or damage to female terminals in connector. c. Check Alternator B+ Stud connection to be sure nut is securing positive cable terminal properly (i.e. nut is clamping terminal & connection is tight). d. Check fuse between the alternator B+ stud & PDC terminal to make sure it is not blown. e. Be sure to follow service manual sections on ALTERNATOR CONTROL CIRCUIT DIAGNOSTIC & ALTERNATOR SENSE CIRCUIT DIAGNOSTIC looking for any opens & shorts (to ground or battery voltage). 2. Check/verify all grounds in the charging system circuit a. Check tightness of mounting bolts securing alternator to engine block. Alternator is a case ground component. b. Check main ground from engine to chassis; connection must be tight. c. Check battery ground cable connections are tight. d. Potentially, loosen alternator mounting bolts, without removing alternator, and re-tighten to torque specifications in service manual. e. After all steps above are complete, re-start engine & check charging system operation. 3. Verify that the Smart Charging System is not the reason for alternator low voltage & current output (Amps). a. Alternator charging can be suspended during engine idle operation because of the Smart Charge strategy. b. Refer to service manual section ""System Operation - Smart Charging System"". c. Refer to Star Case S2008000031 Rev A for low charging voltage & Smart Charge Mode Voltage Range diagram & mode descriptions. d. The alternator has no internal regulator; thus, has no smart circuitry. All alternator control signals come from ECM. 4. If alternator is faulty, remove alternator & mounting bolts. Return alternator with bolts for analysis at QEC."
983232024-05-31. Other. ELECTRICAL SYSTEM. MODULE - TELEMATICS
983542024-05-31. Other. ENGINE. Valve - EGR
981712024-05-31. Other. ENGINE; ELECTRICAL SYSTEM. MODULE - ENGINE CONTROLLER
981052024-05-16. Other. STRUCTURE:BODY. DAMPER - STRUT
08029242024-03-18. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. Radio Over The Air Update from LR34.51 to LR35.41 Software Version Customer may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from LR34.51 to LR35.41. NOTE: National launch for this FOTA update is expected to begin Feburary 19, 2024.
08028242024-03-18. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. Radio Over The Air Update from QR39.82F to QR40.12 Software Version Customer may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from QR39.82F to QR40.12. NOTE: National launch for this FOTA update is expected to begin Feburary 19, 2024.
08026242024-03-18. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. Radio Over The Air Update from QR39.5 to QR40.11 Software Version Customer may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from QR39.5 to QR40.11. NOTE: National launch for this FOTA update is expected to begin Feburary 19, 2024.
08025242024-03-18. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. Radio Over The Air Updating to QR40.12 Software Version Customers may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone, when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from QR39.2 to QR40.11. NOTE: National launch for this FOTA update is expected to begin February 19, 2023.
S22050000022024-03-18. Service bulletin. WHEELS. C003A-2F Right Rear Wheel Speed Sensor, C0037-2F Left Rear Wheel Speed Sensor Diagnostic Trouble Codes (DTCs) Set While Driving With Payload Or Trailer Towing.
S14080003842024-03-18. Service bulletin. ELECTRICAL SYSTEM:12V/24V/48V BATTERY. Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
08252232024-01-16. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE; UNKNOWN OR OTHER. Radio Over The Air Update to LR34.31 to LR35.41 Software Version Customers may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from LR34.31 to LR35.41. NOTE: The National launch for this FOTA update campaign is expected to begin December 04, 2023.
08245232024-01-16. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE; UNKNOWN OR OTHER; EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.. Radio Over The Air Update to Q339.3 to QR39.62 Software Version Customers may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from Q339.3 to QR39.62. NOTE: The National launch for this FOTA update campaign is expected to begin December 04, 2023.

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.