WenmarOpen by Wenmar Pro

Service bulletins for the 2019 Ram 1500

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

1178 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

Only bulletins with component: Engine are shown. Show all

Bulletins, newest first
09-003-20 REV. C2020-06-22. Service bulletin. ENGINE AND ENGINE COOLING; ELECTRICAL SYSTEM; EQUIPMENT ADAPTIVE/MOBILITY. Inspect Throttle Body Assembly This bulletin involves inspecting the Julian date on the throttle body and possibly replacing it. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following Diagnostic Trouble Code (DTC) has been set:P2100 - Electronic Throttle Control Motor Circuit/Open - Bank 1. The customer may also describe the vehicle is in limp home mode.
08-056-202020-06-22. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM; ENGINE. Flash: Battery Pack Control Module (BPCM) Updates This bulletin involves reprogramming the BPCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation, a technician may find thefollowing DTCs have been set:If these codes re-occur after the software update then follow published service information.P0A82-00 - Hybrid/EV Cooling Fan 1 Performance/Stuck Off. P0A97-00 - Hybrid/EV Cooling Fan 2 Performance/Stuck Off. P0AC0-00 - Hybrid Battery Pack Current Sensor 1 Circuit Performance(2019MY Only). P1AEC - MCPA HV Battery Voltage Sensor Circuit Performance(2019 MY Only). If DTCs, P0AA1-00 - Hybrid Battery Positive Contactor Circuit Stuck Closedand P0AC0-00 - Hybrid Battery Pack Current Sensor 1 Circuit Performance is set together, follow the published service diagnostic informationfor P0AA1-00 before proceeding further with this bulletin(2019 MY Only).If DTC, P0AC0-00 is set without P0AA1-00, proceed with the bulletin(2019 MY Only).
S20180000062020-06-22. Service bulletin. FUEL SYSTEM, GASOLINE; ENGINE. Cold start rough idle condition.
S19090000022020-06-22. Service bulletin. EQUIPMENT; ENGINE. Customer complaint may include an overfilled engine crankcase after an oil change.
S20090000022020-06-22. Service bulletin. EQUIPMENT; ENGINE AND ENGINE COOLING:ENGINE:DIESEL; FUEL SYSTEM, DIESEL. Oil Leak From The Front Timing Gear Housing Gasket. (Note: ETL, ETK, ETM, ETN Diesel Engines)
S19250000082020-06-22. Service bulletin. FUEL SYSTEM, GASOLINE; ENGINE AND ENGINE COOLING:ENGINE:DIESEL; EQUIPMENT. Malfunction Indicator Lamp (MIL) Illumination. Diagnostic Trouble Codes (DTCs) P20E8 ? Reductant Pressure Too Low and/or P208B ? Reductant Pump 1 Control Performance Set.
90042572020-06-22. Service bulletin. ENGINE AND ENGINE COOLING; EQUIPMENT. FILTER KIT, Engine Oil When refilling oil on a JT, JL, DT, or RU equipped with a 3.6L Pentastar UPGRADE engine, please be advised that the engine oil capacity is 5 quarts of oil.
09-003-20 REV. B2020-05-26. Service bulletin. ENGINE AND ENGINE COOLING; EXTERIOR LIGHTING; STRUCTURE. Inspect Throttle Body Assembly This bulletin involves inspecting the Julian date on the throttle body and possibly replacing it. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following Diagnostic Trouble Code (DTC) has been set:P2100 - Electronic Throttle Control Motor Circuit/Open - Bank 1. The customer may also describe the following:The vehicle is in limp home mode.
09-003-20 REV. B2020-05-18. Service bulletin. STRUCTURE; ENGINE AND ENGINE COOLING; EXTERIOR LIGHTING. Inspect Throttle Body Assembly This bulletin involves inspecting the Julian date on the throttle body and possibly replacing it. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following Diagnostic Trouble Code (DTC) has been set:P2100 - Electronic Throttle Control Motor Circuit/Open - Bank 1. The customer may also describe the following:The vehicle is in limp home mode.
09-003-20 REV. B2020-04-27. Service bulletin. EQUIPMENT; ENGINE AND ENGINE COOLING. Inspect Throttle Body Assembly This bulletin involves inspecting the Julian date on the throttle body and possibly replacing it. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following Diagnostic Trouble Code (DTC) has been set:P2100 - Electronic Throttle Control Motor Circuit/Open - Bank 1. The customer may also describe the following:The vehicle is in limp home mode.
09-005-202020-04-27. Service bulletin. ENGINE AND ENGINE COOLING. 3.0L Oil Filter Cartridge Identification Differences And Oil Filter Element Servicing Procedure This bulletin outlines the correct procedure for changing an oil filter on a 3.0L diesel to prevent engine damage. The bulletin also highlights the design differences in the oil filter cartridges used in the GEN-2 and GEN-3 3.0L diesel. As well as potential issues that can arise should the incorrect filter be used in each application.
OD61336A2020-01-21. Service bulletin. ENGINE AND ENGINE COOLING. VB1 2014-2019MY DS 3.0L Diesel EGR Cooler (OD61336 Linked Document - Coolant Level Check Tutorial)
OD613362020-01-21. Service bulletin. ENGINE AND ENGINE COOLING. Safety Recall VB1: 2014-2019 DS 3.0L EGR Cooler Customer Handling
90041712020-01-21. Service bulletin. ENGINE AND ENGINE COOLING. COVER, Cylinder Head, Left/Right Prior to replacing the cylinder head cover on ANY 3.6L Pentastar Upgrade Engine, verify that there are no steel dowel pins pressed into the cylinder head. If dowels are present in the cylinder head please remove carefully without touching/damaging the cylinder head sealing surface.
18-089-192019-12-16. Service bulletin. FUEL SYSTEM, GASOLINE; ENGINE. wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK
09-003-192019-12-02. Service bulletin. ENGINE AND ENGINE COOLING. GEN-2 and GEN-3 - 3.0L Oil Filter Cartridge Identification Differences This bulletin highlights the design differences in the oil filter cartridges used in the GEN-2, and GEN-3 3.0L diesel. As well as potential issues that can arise should the incorrect filter be used in each application. Although similar in design, the oil filter cartridges used on the GEN-2 and GEN-3 3.0L diesel engines are different in design. Interchanging them may result in premature engine damage over time.
04-001-192019-10-28. Service bulletin. ENGINE. Pentastar Upgrade Oil Fill Level after an Oil Change This bulletin involves rechecking the oil fill level after filling the engine to the correct specifications. The customer may describe that after an oil change they check their oil fill level and it is showing overfilled on the oil dipstick.
90036802019-10-28. Service bulletin. ENGINE; ENGINE AND ENGINE COOLING. RETAINER, Crankshaft Rear Oil Seal Oil leak from rear engine seal retainer or windage tray/gasket Check for other sources of leaks using dye such as gallery plugs, camshaft cup plug at rear of engine, rear of engine valley for possible MDS solenoid, VVT solenoid, block porosity or transmission leaks. If another source of the leak was identified, proceed with the appropriate repairs. Engineering is looking for assistance in determining root cause and a corrective action on crankshaft rear oil seals and windage tray/gaskets. For concerns related to rear crankshaft seal oil leaks and windage tray gaskets, please send an email to brenton.swank@fcagroup.com. Include the VIN, mileage, and any photos identifying where the leak is coming from using dye, such as: 1. Leak between rear seal and crankshaft (seal rolled during installation) 2. Leak between outer diameter of rear seal and retainer 3. Leak between rear seal retainer and engine block (Please record the 5 retainer bolts residual torque in tightening direction) 4. Leak between rear seal retainer and windage tray/gasket (Please record the oil pan bolts residual torque in tightening direction) If the source of the leak cannot be identified, please contact Brenton Swank at (248) 804-9386 or Brenton.Swank@FCAGroup.com If no response in 15 minutes, proceed with repair.
90039682019-10-28. Service bulletin. ENGINE AND ENGINE COOLING; ELECTRICAL SYSTEM; ENGINE. CONDENSER, Air Conditioning If it is determined that the A/C compressor does not engage due to a refrigerant leak at the receiver/drier plug on the A/C condenser, order the receiver/drier plug kit P/N 68447796A$ and follow the repair instructions included on the instruction sheet.
90041152019-10-28. Service bulletin. ENGINE. SEAL, Crankshaft Oil, Front Front crankshaft oil seal leak: For concern of front crankshaft seal leak please send an email to brenton.swank@fcagroup.com with VIN, Mileage, Photos and indicate where the leak is identified using dye such as: 1. Leak between the outer diameter of the seal to front cover? 2. Leak between the seal and damper 3. Leak through the damper bolt This will help in determining root cause and corrective action. For additional questions, please contact: Brenton Swank: Cell (248) 804-9386 or brenton.swank@fcagroup.com If no response in 15 minutes, proceed with repair.
OD553412019-07-15. Service bulletin. EQUIPMENT; ENGINE. Vehicles Eligible For CSN U07 And V08, V11 or V16 Important Update To U07 Dealer Instructions
549352019-07-15. Service bulletin. ENGINE; EQUIPMENT. Sensor-nitrous oxlde
553112019-07-15. Service bulletin. EQUIPMENT; ENGINE. Damper-Steering
553222019-07-15. Service bulletin. EQUIPMENT; ENGINE. Head-Cylinder
553242019-07-15. Service bulletin. ENGINE. Head-Cylinder

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.