WenmarOpen by Wenmar Pro

Service bulletins for the 2005 Nissan Frontier

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

109 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

Bulletins, newest first
NTB-10-072A2011-01-26. Service bulletin. SUSPENSION:FRONT. NISSAN: FRONT SUSPENSION NOISE. A NOISE (CLUNKING, SQUEAKING, POPPING) CAN BE HEARD WHEN PERFORMING AT LEAST ONE OF THE FOLLOWING ACTIONS: TURNING THE STEERING WHEEL LEFT OR RIGHT, DRIVING OVER SPEED BUMPS, DRIVING ON ROUGH ROADS, ACCELERATING OR DECELERATING AND NOISE IS COMING FROM THE FRONT STABILIZER BAR BUSHING. *PE
NTB-10-1152011-01-22. Service bulletin. STEERING:HYDRAULIC POWER ASSIST:POWER STEERING FLUID. NISSAN: POWER STEERING OIL COOLER SERVICE. IF A POWER STEERING OIL COOLER NEEDS TO BE REPLACED FOR ANY REASON, PLEASE REFER TO THE SERVICE PROCEDURE. *PE
NTB-10-0552010-09-14. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER; ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN. NISSAN: BLOWER MOTOR DOES NOT WORK. THE BLOWER MOTOR FOR HEATER AND AIR CONDITIONER DOES NOT OPERATE. THERE ARE SIGNS OF WATER INTRUSION IN THE BLOWER MOTOR. *PE
NTB-04-0472010-08-12. Service bulletin. POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE). NISSAN: OIL LEAKING FROM TRANSFER CASE. OIL IS LEAKING FROM ONE OR A COMBINATION OF THREE BOLTS AT THE REAR OF THE TRANSFER CASE. IF BOLTS ARE NOT MISSING, DO NOT REPLACE TRANSFER CASE, TRANSFER CONTROL DEVICE; OR TRANSFER CONTROL UNIT FOR THIS INCIDENT, IT SHOULD OCCUR. *PE
NTB-10-0452010-08-12. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE; ELECTRICAL SYSTEM:SOFTWARE. NISSAN: DTC P0420 (TW CATALYST SYS-BI) STORED IN THE ECM. CONFIRM THIS BULLETIN APPLIES-CHECK THE CURRENT ECM PART NUMBER; COMPARE YOUR CURRENT ECM PART NUMBER TO CHART A. REPLACE THE EXHAUST MANIFOLD CATALYST; REPROGRAM THE ECM. *PE
NTB-10-0082010-08-06. Service bulletin. SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY. NISSAN: REAR AXLE SEAL LEAKS. THE REAR AXLE ASSEMBLY IS LEAKING GEAR OIL FROM THE RIGHT AND/OR LEFT HAND AXLE SEAL, AND THE VEHICLE IS EQUIPPED WITH A M226 STYLE AXLE AND NO NOISE OR VIBRATION IS COMING FROM THE REAR FINAL DRIVE GEARS AND SIDE BEARINGS. *PE
NTB-10-0612010-06-22. Service bulletin. EXTERIOR LIGHTING:HEADLIGHTS. NISSAN: XENON HEAD LAMP SERVICE. A XENON HEADLAMP IS NOT FUNCTIONING BECAUSE OF AN ISSUE INSIDE THE HEADLAMP ASSEMBLY (AN INTERNAL ISSUE). IN MOST CASES, REPLACEMENT OF A BULB OR HID CONTROL UNIT WILL SOLVE THE INCIDENT. THIS INCLUDES ALL MODELS WITH XENON HEAD LAMPS. NO MODELS LISTED. *PE
NTB-07-069C2010-04-21. Service bulletin. FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM. NISSAN: FUEL GAUGE ISSUES AND/OR DTC P0461/2/3. THE FUEL GAUGE IS ERRATIC, INACCURATE, OR INOPERATIVE. THE MIL IS ON WITH DTC P0461, P0462, OR P0463 STORED IN SELF DIAGNOSIS. REPLACE THE FUEL LEVEL SENDING UNIT WITH THE ONE FROM THE PARTS INFORMATION SECTION. *PE UPDATED 1/24/11. *PE AMENDMENT UPDATED. 2/28/11. *PE
NTB-09-1292010-04-07. Service bulletin. EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL. NISSAN: VENT CONTROL VALVE REPLACEMENT. WHEN REPLACING THE EVAP CANISTER VENT CONTROL VALVE FOR REASON: USE THE ONE LISTED ON PAGE 2; FOR VENT CONTROL VALVE REPLACEMENT PROCEDURE, REFER TO THE APPROPRIATE SECTION OF THE ELECTRONIC SERVICE MANUALS (ESM; WHEN INSTALLING THE NEW VALVE, DO NOT ADD ANY LUBE TO ITS O RING; FOR FRONTIER (D40 SERIES) ONLY, INSTALL THE PROTECTOR LISTED IN PARTS INFORMATION. *PE INCLUDES 2005-09 FRONTIER. UPDATED 12/8/10. *PE
NTB-03-074-C2010-03-03. Service bulletin. EXTERIOR LIGHTING:TAIL LIGHTS; EXTERIOR LIGHTING; EXTERIOR LIGHTING:FOG LIGHTS; EXTERIOR LIGHTING:HEADLIGHTS:CONCEALMENT DEVICES; EXTERIOR LIGHTING:HEADLIGHTS. NISSAN: EXTERIOR LAMP FOGGING. OCCASIONALLY WATER IS NOTICED IN THE EXTERIOR LAMPS. THIS IS GENERALLY NOT DUE TO A DEFECT. ALL CURRENT EXTERIOR LAMP ASSEMBLIES ARE VENTED TO THE ATMOSPHERE (NOT SEALED). THIS IS NECESSARY TO ALLOW FOR EXPANSION AND CONTRACTION OF AIR FROM TEMPERATURE VARIATIONS (WARMER OR COLDER) WITHOUT DAMAGE TO THE LAMP. MOISTURE IN THE AIR SOMETIMES TRAVELS INTO AND OUT OF THE LAMP ASSEMBLY THROUGH THESE VENTS. CERTAIN ENVIRONMENTAL CONDITIONS MAY CAUSE MOISTURE TO CONDENSE. THE FOGGING/CLOUDINESS SHOULD DISAPPEAR OVER TIME WHEN THE LAMP IS IN A DRY ENVIRONMENT. NO MODELS LISTED. *PE UPDATED 5/7/10. *PE UPDATED 12/9/13. *PE
NTB-09-1012010-01-05. Service bulletin. TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS. NISSAN: TIRE PRESSURE MONITORING SYSTEM (TPMS) WARNING LIGHT ON/FLASHING. NO MODELS OR MODEL YEARS LISTED. *PE UPDATED ON 08-11-2011. *KB
NTB-09-0302009-08-12. Service bulletin. ELECTRICAL SYSTEM:12V/24V/48V BATTERY; ELECTRICAL SYSTEM; ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES. NISSAN: THE 12 VOLT BATTERY IS AN IMPORTANT PART OF THE VEHICLE ELECTRICAL SYSTEM AND IS REQUIRED TO STAY CONNECTED WHEN THE ENGINE IS RUNNING. TO PREVENT DAMAGE TO VEHICLE ELECTRONIC COMPONENTS FOLLOW THE INSTRUCTIONS/CAUTIONS. NO MODEL YEARS LISTED. *PE
NTB-08-055-A2008-08-16. Service bulletin. AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE. NISSAN: SRS PRECAUTIONS DURING SERVICE;IMPROPER MAINTENANCE, INCLUDING INCORRECT REMOVAL AND INSTALLATION OF THE SRS, CAN LEAD TO A SERIOUS INJURY OR DEATH CAUSED BY UNINTENTIONAL ACTIVATION OF THE SRS ON ALL NISSAN MODELS WITH THE SRS SYSTEMS. *PE UPDATED 2/21/14. *PE
NTB08-0622008-06-26. Service bulletin. SEATS. SEAT BACK BOARD REMOVAL/INSTALLATION. *NJ
NTB08-0492008-05-07. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. NISSAN; SPECIAL AUTOMATIC TRANSMISSION FLUID REQUIREMENT. 2004 TO CURRENT NISSAN VEHICLES. *NJ
NTB08-0232008-03-13. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. NISSAN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. VOLUNTARY EMISSIONS RECALL CAMPAIGN - 2003-2005 SENTRA / 2005-2006 FRONTIER ECM REPROGRAMMING. CSC WAS RECEIVED. *NJ UPDATED 6/21/11. *PE
070422007-08-13. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. BUZZING/WHINING NOISE FROM TIMING CHAIN AREA. *KB
030302007-05-10. Service bulletin. EXTERIOR LIGHTING. EXTERIOR LAMP FOGGING. *KB
06063A2006-10-26. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. TICKING NOISE FROM THE ENGINE DURING ACCELERATION. NISSAN. *KB
060462006-07-20. Service bulletin. AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE. DRIVER'S SEAT SIDE AIR BAG OPEN CIRCUIT (DTC B1134). *TT
060302006-04-05. Service bulletin. FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP. SQUEAK FROM FUEL PUMP. *TT
060272006-04-05. Service bulletin. POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT. REAR FINAL DRIVE BREATHER. *TT
060092006-04-05. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. MIL ON WITH DTC U1000 OR U1010 STORED IN ENGINE CONTROL UNIT. *TT
060092006-03-01. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE U1000 OR U1010 STORED IN ENGINE CONTROL UNIT. *AK
050022005-11-14. Service bulletin. STRUCTURE:BODY. SPRAY-IN BEDLINER REPAIR (LEVEL 1). *TT

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.