Service bulletins for the 2025 Hyundai Santa Fe
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
44 on file from NHTSA, as of 2026-10-19.
By type
By component
By topic
| 25-01-052H DN | 2025-10-28. Service campaign. ENGINE. Certain 2025MY Santa Cruz (NXT) and Santa Fe (MX5A) vehicles equipped with the 2.5T-GDI Theta III engine may exhibit coolant residue on the back side (exhaust side) of the engine caused by a crack in the cylinder block. The California Air Resources Board has determined that these vehicles may be releasing air pollutants which exceed Federal and California standards. |
|---|---|
| 25-01-072H DCS | 2025-10-14. Service campaign. POWER TRAIN. Hyundai Motor America is currently investigating an ongoing concern with software GDS event #1306 for certain Hyundai Santa Fe (MX5A) vehicles. The software update is not appearing for some impacted vehicles. In the interim, Technical Service Bulletin (TSB) 25-01-072H will be removed from Hyundai Tech Info. We will provide an update once the issue is resolved and the suspension is lifted. If dealer has already performed the update successfully on an impacted vehicle prior to the suspension, the corresponding campaign claim can be submitted. |
| 25-01-071H/072H DCS | 2025-10-14. Service campaign. POWER TRAIN. Certain Santa Fe (MX5A) and Santa Cruz (NXT) vehicles equipped with 8-speed dual clutch transmissions (8DCT) may set one of the high pressure electric oil pump (HP EOP) DTCs listed below. Technical Service Bulletins (TSB) 25-01-071H (for Santa Fe vehicles) and 25-01-072H (for Santa Cruz vehicles) provide the service procedure to update the Transmission Control Unit (TCU) with improved logic to address these DTCs and enhance operation of the 8DCT. |
| 25-01-072H TSB | 2025-10-13. Service campaign. POWER TRAIN. Certain Santa Fe (MX5A) vehicles equipped with 8-speed dual clutch transmissions (8DCT) may set one of the high pressure electric oil pump (HP EOP) DTCs listed below. This bulletin provides the service procedure to update the Transmission Control Unit (TCU) with improved logic to address the DTCs above and enhance operation of the 8DCT. |
| 25-01-058H OL | 2025-10-03. Service campaign. STRUCTURE:BODY. Hyundai has become aware that some vehicles may exhibit a “pop,” “tick,” or “creak” noise from the right front subframe area while driving. The noise may be caused by a missing weld on the right front subframe mounting stud. |
| 25-BE-020H TSB | 2025-10-03. Service bulletin. ELECTRICAL SYSTEM. This bulletin provides information related to the changes introduced in the 2025 1st Navigation Map and Software Update. The changes may vary depending on vehicle type, model, and navigation system as described in this TSB. |
| 25-01-058H DN | 2025-09-09. Service campaign. STRUCTURE:BODY. Certain Santa Fe (MX5A) and Santa Fe Hybrid (MX5A HEV) vehicles may produce a “pop”, “tick”, or “creak” noise from a missing weld on the mounting stud of the right front subframe while driving. The vehicle’s structural integrity is maintained even with a missing weld; however, drivers may report an abnormal noise coming from the affected area during certain driving scenarios. |
| 25-01-058H TSB | 2025-09-09. Service campaign. STRUCTURE:BODY. Certain Santa Fe (MX5A) and Santa Fe Hybrid (MX5A HEV) vehicles may produce a “pop”, “tick”, or “creak” noise from a missing weld on the mounting stud of the right front subframe while driving. The vehicle’s structural integrity is maintained even with a missing weld; however, drivers may report an abnormal noise coming from the affected area during certain driving scenarios. This bulletin describes the procedure to inspect, and if necessary, repair the missing weld on the mounting stud to eliminate the noise. |
| 25-BE-002H TSB | 2025-06-03. Service bulletin. ELECTRICAL SYSTEM. This bulletin provides information related to the changes introduced in the 2024 2nd Navigation Map and Software Update. The changes may vary depending on vehicle type, model, and navigation system. Refer to the 2024 2nd Navigation Map and Software Update Improvements section in this TSB for a list of specific changes. The software can be downloaded via Navigation Updater (NAU) and updated by USB. The NAU website is https://update.hyundai.com/US/EN/navigationUpdate. For certain models equipped with a relevant Bluelink package, the software may be downloaded and applied via OTA update. |
| 25-01-018H-1 TSB | 2025-05-27. Service campaign. ELECTRICAL SYSTEM. Some vehicles may exhibit a loss of connectivity or interruptions in the middle of using Bluelink functions. This may be due to an occasional disconnection on Verizon’s communication network. Follow the procedures in this bulletin to verify Bluelink Data Communication Unit (DCU) network connection and if needed, reset the DCU in Dealer Mode to resolve the connection. |
| 25-01-028H TSB | 2025-04-30. Service campaign. SEATS. Certain Santa Fe Hybrid (MX5A HEV) vehicles may experience battery drain due to incorrect ECU logic for the Seat Heater Unit – Front (SHU_FRT). This bulletin provides instructions to perform a software update for the Seat Heater Unit – Front to correct the logic. |
| 25-BE-008H TSB | 2025-04-15. Service bulletin. ELECTRICAL SYSTEM. Certain vehicles (See Applicable Vehicles List below) equipped with the 12-inch instrument cluster display and separate Instrument Cluster Module require software verification PRIOR to odometer mileage writing. If the Cluster Module does not have the latest software, the incorrect mileage may be written to the new module. This bulletin provides information to confirm the Instrument Cluster Module is equipped with the latest software version prior to using the GDS tablet to write the odometer mileage. |
| 25-01-025H TSB | 2025-04-01. Service campaign. SEATS. Certain Santa Fe (MX5A) vehicles may experience battery drain due to incorrect ECU logic for the Seat Heater Unit – Front (SHU_FRT). This bulletin provides instructions to perform the software update for the Seat Heater Unit – Front to correct the logic. |
| 25-01-018H TSB | 2025-03-05. Service campaign. ELECTRICAL SYSTEM. Some vehicles may exhibit a loss of connectivity or interruptions in the middle of using Bluelink functions. This may be due to an occasional disconnection on Verizon’s communication network. Follow the procedures in this bulletin to verify Bluelink Data Communication Unit (DCU) network connection and if needed, reset the DCU in Dealer Mode to resolve the connection. |
| 25-BE-003H DN | 2025-02-25. Service bulletin. ELECTRICAL SYSTEM. Hyundai Motor America has noted that several vehicles were impacted by a telecommunications outage that occurred on Sunday, February 9th , resulting in the potential loss of connectivity or interruptions when attempting to use Bluelink functions. Voice Recognition, Sports Media, and Weather will not be available. Dealer stock and retailed vehicles are both affected. If a customer calls in and their vehicle is experiencing issues related to Bluelink, please have them come into the dealership to assist with resetting the Bluelink Data Communication Unit (DCU) and utilize TSB 25-BE-003H posted on Hyundai Tech Info. |
| 25-BE-003H TSB | 2025-02-25. Service bulletin. ELECTRICAL SYSTEM. Some vehicles may exhibit a loss of connectivity or interruptions in the middle of using Bluelink functions. This may be due to an occasional disconnection on Verizon’s communication network. Follow the procedures in this bulletin to reset the Connected Car Data Communication Unit (DCU) in Dealer Mode to resolve the connection. |
| 24-01-092H-1 | 2024-12-21. Service campaign. ELECTRICAL SYSTEM. Certain 2025MY Santa Fe (MX5A) and Santa Fe Hybrid (MX5A HEV) vehicles may have a Bluelink malfunction or not able to have Bluelink setup. This bulletin provides instructions to reset the network in Dealer Mode to prevent the Data Concentrator Unit (DCU) modem from experiencing a "Blue Link Not Open" error. |
| 24-01-092H TSB | 2024-12-11. Service campaign. ELECTRICAL SYSTEM. Certain 2025MY Santa Fe (MX5A) and Santa Fe Hybrid (MX5A HEV) vehicles may have a Bluelink malfunction or not able to have Bluelink setup. This bulletin provides instructions to reset the network in Dealer Mode to prevent the Data Concentrator Unit (DCU) modem from experiencing a "Blue Link Not Open" error. |
| 24-BE-007H-1 | 2024-12-03. Service bulletin. ELECTRICAL SYSTEM. Certain Santa Cruz (NXT), Santa Fe (MX5A), Santa Fe Hybrid (MX5A HEV), and Tucson (NX4A) vehicles may exhibit a display screen flickering or intermittently going blank. This may be due to the shield width of the coaxial cable being too wide, causing a loose connection. Follow the procedures in this bulletin to adjust the width of the shield using a supplied shield adjustment jig. |
The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.