WenmarOpen by Wenmar Pro

Service bulletins for the 2023 Hyundai Santa Fe

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

71 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

By topic

Only bulletins with component: Engine are shown. Show all

Bulletins, newest first
26-01-081H DCS2026-10-14. Service campaign. ENGINE. Certain Santa Fe Hybrid (TM HEV), Santa Fe Plug-in Hybrid (TM PHEV), Tucson Hybrid (NX4 HEV), andTucson Plug-in Hybrid (NX4 PHEV) vehicles may experience intake air line freezing and Exhaust GasRecirculation (EGR) valve corrosion due to excessive condensation accumulating within the EGR system.This condition can lead to drivability concerns related to the following DTCs: - P040400: (Exhaust Gas Recirculation Control Circuit Range) - P049D00: (EGR 'A' Control Position Exceeded Learning Limit) - P047100: (Exhaust Pressure Sensor 'A' Circuit Range/Performance) - P012800: Coolant Thermostat (Coolant Temperature below Thermostat Regulation Temperature) - P262B00: (Control Module Power Off Timer Performance) - P050C00: Cold Start Engine Coolant Temperature Performance - P1DFD00: (EVAP System Purge Pump Target Speed) - P2DFD00: (EVAP System Purge Pump Performance) - P112000: (Inlet Metering Valve – Malfunction) - P033500: (Crankshaft Position Sensor A)
26-EM-016H TSB2026-10-14. Service bulletin. ENGINE. Some vehicles equipped with internal combustion engines may exhibit higher-than-expected engine oil consumption. This bulletin outlines the combustion chamber cleaning procedure for vehicles diagnosed with this condition. All internal combustion engines consume some engine oil during normal operation, depending on driving conditions and mileage, and this procedure should only be performed when deemed necessary based on inspection and diagnosis of the vehicle as outlined in TSB 26-EM-015H, Engine Oil Consumption – Inspection & Repair Guidelines, or the latest revision.
26-EM-015H TSB2026-10-13. Service bulletin. ENGINE. Certain vehicles equipped with internal combustion engines may exhibit higher-than-expected engine oil consumption. This bulletin provides the inspection and repair procedures for vehicles exhibiting this condition. All internal combustion engines consume engine oil as part of normal engine operation. Oil consumption rates may vary based on mileage, operating conditions, driving habits, and maintenance history. Hyundai recommends following the prescribed maintenance schedule and periodically checking the engine oil level using the dipstick to maintain proper engine oil level.
26-01-081H TSB2026-10-09. Service campaign. ENGINE. Certain Santa Fe Hybrid (TM HEV), Santa Fe Plug-in Hybrid (TM PHEV), Tucson Hybrid (NX4 HEV), and Tucson Plug-in Hybrid (NX4 PHEV) vehicles may experience intake air line freezing and Exhaust Gas Recirculation (EGR) valve corrosion due to excessive condensation accumulating within the EGR system. This condition can lead to drivability concerns related to the following DTCs: • P040400: (Exhaust Gas Recirculation Control Circuit Range) • P049D00: (EGR 'A' Control Position Exceeded Learning Limit) • P047100: (Exhaust Pressure Sensor 'A' Circuit Range/Performance) • P012800: Coolant Thermostat (Coolant Temperature below Thermostat Regulation Temperature) • P262B00: (Control Module Power Off Timer Performance) • P050C00: Cold Start Engine Coolant Temperature Performance • P1DFD00: (EVAP System Purge Pump Target Speed) • P2DFD00: (EVAP System Purge Pump Performance) • P112000: (Inlet Metering Valve – Malfunction) • P033500: (Crankshaft Position Sensor A) The bulletin below provides instructions to perform a software update for the Engine Control Module (ECM).
26-01-081H DN2026-10-09. Service campaign. ENGINE. Certain Santa Fe Hybrid (TM HEV), Santa Fe Plug-in Hybrid (TM PHEV), Tucson Hybrid (NX4 HEV), and Tucson Plug-in Hybrid (NX4 PHEV) vehicles may experience intake air line freezing and Exhaust Gas Recirculation (EGR) valve corrosion due to excessive condensation accumulating within the EGR system. This condition can lead to drivability concerns related to the following DTCs: • P040400: (Exhaust Gas Recirculation Control Circuit Range) • P049D00: (EGR 'A' Control Position Exceeded Learning Limit) • P047100: (Exhaust Pressure Sensor 'A' Circuit Range/Performance) • P012800: Coolant Thermostat (Coolant Temperature below Thermostat Regulation Temperature) • P262B00: (Control Module Power Off Timer Performance) • P050C00: Cold Start Engine Coolant Temperature Performance • P1DFD00: (EVAP System Purge Pump Target Speed) • P2DFD00: (EVAP System Purge Pump Performance) • P112000: (Inlet Metering Valve – Malfunction) • P033500: (Crankshaft Position Sensor A)
26-EE-003H TSB2026-04-21. Service bulletin. ENGINE; ELECTRICAL SYSTEM. Some vehicles may exhibit difficulty starting in cold weather. This bulletin provides the procedure to perform an inspection on the starter magnetic switch for potential freezing and, if necessary, replace the starter magnetic switch (solenoid) assembly.
26-EM-005H TSB2026-02-10. Service bulletin. ENGINE. Some Santa Fe (TMA) vehicles may have DTCs P218100, P2181F0, and/or P2181F1 (Cooling System Performance) set in the Electronic Control Unit (ECU), resulting in an illuminated Check Engine warning lamp. Follow the procedure in this TSB to replace the Integrated Thermal Management (ITM) module and update both the Engine Control Module (ECM) and Transmission Control Module (TCM) if applicable. Follow the flowchart in this TSB to update the appropriate modules.
25-EM-002H TSB2025-06-24. Service bulletin. ENGINE. Certain 2020-2022MY Tucson Hybrid and Santa Fe Hybrid vehicles equipped with the 1.6T-GDI Gamma II HEV engine may experience an engine oil leak originating from the Continuous Variable Valve Duration (CVVD) Actuator Oil Seal. Follow the service procedure below to replace the CVVD Oil Seal.
24-FL-004H2024-12-21. Service bulletin. ENGINE. This bulletin provides the procedure to update the Engine Control Module (ECM) and the Transmission Control Module (TCM) for 2021-2023MY Santa Fe (TMa) vehicles to improve operation of the Idle Stop and Go (ISG) system. Under certain circumstances the vehicle may not restart after the ISG system has engaged and requires a manual restart due to the lack of intake manifold pressure recovery.
24-EM-001H2024-08-07. Service bulletin. ENGINE. Certain 20-22MY Sonata (DN8a), 21-23MY Santa Fe (TMa), and 22-23MY Tucson (NX4a) vehicles may experience a warning lamp illumination for a diagnostic trouble code P2181 that is related to the Integrated Thermal Management Module (ITM). Follow the service procedure outlined in this bulletin to replace the ITM.
23-EM-005H2023-12-15. Service bulletin. ENGINE AND ENGINE COOLING. This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.
23-01-084H2023-11-07. Service bulletin. ENGINE AND ENGINE COOLING. Certain 2023MY Santa Cruz (NXT) and Santa Fe (TMA) vehicles may have been produced with a damaged oil level sensor during assembly. Follow the procedure outlined in this TSB to replace the oil level sensor and gasket to complete the service campaign.
23-EE-010H2023-10-02. Service bulletin. ELECTRICAL SYSTEM; ENGINE AND ENGINE COOLING. This bulletin is issued to provide the extended battery diagnosis procedure using GDS-M. This battery diagnosis function displays the various battery-related faults such as: • Internal short circuit • Battery deterioration • Malfunction of electronic parts • Insufficient battery charge • Normal battery • Charging defect Battery diagnosis uses the battery sensor history saved for the last 30 days and ICU diagnostic communication to track battery state of charge (SOC) and current parasitic draw history.
23-AT-009H2023-08-02. Service bulletin. POWER TRAIN; POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL); ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM); POWER TRAIN:AUTOMATIC TRANSMISSION; ELECTRICAL SYSTEM:WIRING:POSITION/LIMIT SENSOR/SWITCH. If you are servicing an 8-speed DCT front-wheel-drive vehicle with the DTC or symptoms listed below, refer to the Service Procedure to diagnose the condition. • DIAGNOSTIC TROUBLE CODES: ➢ P070500 - Transmission range sensor circuit malfunction ➢ P070512 - Transmission range sensor circuit malfunction ➢ P070514 - Transmission range sensor circuit malfunction ➢ P07051C - Transmission range sensor circuit malfunction ➢ P070600 - Transmission range sensor circuit range/performance ➢ P070661 - Transmission range sensor circuit range/performance ➢ P070696 - Transmission range sensor circuit range/performance • SYMPTOMS: ➢ Malfunction Indicator Light (MIL) illuminated ➢ 5th gear fail-safe ➢ Intermittently won’t shift into D or R ➢ Intermittently won’t shift out of P ➢ Intermittent ly no engine crank in “P” or “
23-01-042H2023-06-02. Service bulletin. ENGINE AND ENGINE COOLING. Certain Palisade (LX2) and Santa Fe Plug-In Hybrid (TM PHEV) vehicles may have been produced with engine mounting support bracket fasteners that were not tightened to torque specification. Follow the procedure outlined in this bulletin to retighten the indicated fasteners to the correct specified torque values.
23-01-042H2023-05-05. Service bulletin. ENGINE AND ENGINE COOLING. Certain Palisade (LX2) and Santa Fe Plug-In Hybrid (TM PHEV) vehicles may have been produced with engine mounting support bracket fasteners that were not tightened to torque specification. Follow the procedure outlined in this bulletin to retighten the indicated fasteners to the correct specified torque values.
23-01-035H2023-05-04. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM); ENGINE AND ENGINE COOLING. This bulletin provides information related to the Engine Control Module (ECM) software update for HMMA (5NM) produced 2023MY Santa Fe Hybrid (TM HEV) vehicles to improve the following DTC and symptoms:
23-EE-007H2023-05-04. Service bulletin. ENGINE AND ENGINE COOLING; ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM). This bulletin provides information related to the Engine Control Module (ECM) software update for Santa Fe Plug-in Hybrid (TM PHEV) and Santa Fe Hybrid (TM HEV) vehicles to improve the following DTC and symptoms:
23-AT-003H2023-05-02. Service bulletin. ENGINE AND ENGINE COOLING. If you are servicing an 8-speed vehicle with a “Check Engine” light on and one or more of the DTC listed, follow the service procedure and replace the related solenoid and harness.

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.