WenmarOpen by Wenmar Pro

Service bulletins for the 1997 Ford F-250

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

332 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

Only bulletins with component: Engine are shown. Show all

Bulletins, newest first
072122008-02-21. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
054172005-05-05. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE). INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW. *TT
0321402004-01-12. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. ENGINE BUCK, SURGE OR JERK (ALSO KNOWN AS HITCHING/HESITATION) WHILE THE SPEED CONTROL IS ACTIVE THROUGH ALL ENGINE TEMPERATURES. *TT
0321312004-01-10. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. ROUGH IDLE AND ENGINE MISS DUE TO INJECTOR BORE SCUFFING AT GREEN ENGINE BREAK-IN. *TT
0321262004-01-09. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. MOANING NOISE DURING 1500-2000 RPM ON NEUTRAL ENGINE RUN-UP, OR WHILE DRIVING UNDER LOAD. *TT
0321232004-01-09. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. LOW RPM, NO START, RUNS POORLY, STALL. 7.3L DIT ENGINE. *TT
0321212004-01-09. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. A HIGH NUMBER OF HIGH PRESSURE REXROTH PUMPS AND INJECTION PRESSURE REGULATORS (IPR) ARE BEING REPLACED DUE TO OIL LEAKING, WHEN ALL THAT IS REQUIRED IS A NEW GASKET OR SEAL ON EITHER THE PUMP OR IPR. *TT
0321202004-01-09. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. 7.3L DIT GLOW PLUG START-UP ON-TIME DURING COLD TEMPERATURE - SERVICE TIP. *TT
0321192004-01-09. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. AN ENGINE VIBRATION AND/OR MOANING NOISE AT 2600-3000 RPM. *TT
032132004-01-09. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER. A NO-START OR REDUCED POWER CONDITION MAY OCCUR INTERMITTENTLY. *TT
032112004-01-09. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. LOSS OF POWER AND MALFUNCTION INDICATOR LAMP MAY ALSO ILLUMINATE WITH DIAGNOSTIC TROUBLE CODES 128 AND 845 OR P0236 AND P0238 STORED IN MEMORY. *TT
031032003-09-17. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. VEHICLES WITHOUT THE COOLANT LOCK-OFF MAY EXHIBIT A NO START CONDITION. *TT
012462002-04-18. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE. ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
155702002-04-12. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE. SOME VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS INCLUDING LACKS POWER, HESITATES, HARD TO START, AND/OR MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND PRODUCE POSSIBLE DIAGNOSTIC TROUBLE CODES P0103, P0172 AND P0175. *TT
012052002-02-26. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE. SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
01472001-05-30. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE. SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
143652001-04-18. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS. THIS BULLETIN ADDRESSES CONCERNS A NOISE AT INTIAL ENGINE STARTUP WHEN COLD FROM THE ACCESSORY DRIVE BELT. *JB
144552001-03-02. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. OIL LEAK FROM THE FRONT OR REAR CYLINDER HEAD OIL SUPPLY RAIL END PLUGS. *TT
002382001-03-01. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE. SOME VEHICLES MAY EXHIBIT A NO CRANK / NO START CONDITION IN TEMPERATURES BELOW 12 DEGREES C (10 DEGREES F). *TT
46352001-02-08. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE. COLD ENGINE KNOCK. *TT
9803072001-02-06. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE. VEHICLE STALLS/QUITS WHILE DRIVING. *AK
9851852001-01-29. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE. COLD START ENGINE NOISE
981562001-01-29. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE. EXHAUST LEAK AT EXHAUST MANIFOLDS--VEHICLE EQUIPPED WITH 7.0L 0R 7.5L ENGINE. *AK
52672001-01-16. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE. SUBJECT REGARDING MISFIRE CODES ON ALL ENGINES. *TT
52572001-01-13. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE. INFORMATION ON VEHICLES EXHIBITING COLD ENGINE KNOCK. *TT

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.