WenmarOpen by Wenmar Pro

Service bulletins for the 1995 Ford F-250

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

199 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

Bulletins, newest first
9624121997-06-17. Service bulletin. PARKING BRAKE:CONVENTIONAL:MECHANICAL:LINKAGE AND CABLE. BRAKES - REAR PARKING BRAKE CABLE BINDS - VEHICLES BUILT BEFORE 8/20/96 - ALL CHASSIS CAB VEHICLES ARE EXCLUDED. *TW
962491997-06-17. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER. TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
962461997-06-17. Service bulletin. ELECTRICAL SYSTEM:WIRING. WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
BC03219611011997-06-17. Service bulletin. SUSPENSION:FRONT. POP/CLUNK FROM STEERING LINKAGE OVER BUMPS. *TW
BC08839610041997-04-24. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE. VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT
BC08449610081997-04-24. Service bulletin. POWER TRAIN:MANUAL TRANSMISSION. E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT
BC08209610101997-04-24. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. REVISED EEC CALIBRATION HAS BEEN INCORPORATED IN PCM CALIBRATIONS FOR VEHICLES WHICH DISPLAY LACK OF POWER DUE TO TORQUE CONVERTER ENGAGEMENT SCHEDULING, CATALYTIC CONVERTER FAILURES, ROUGH IDLE OR HARD START ON HOT RESTART. *TT
BC06829610241997-04-24. Service bulletin. POWER TRAIN:DRIVELINE:DRIVESHAFT. VEHICLES MAY EXHIBIT A DRIVELINE VIBRATION OR NOISE WHILE DRIVING AT HIGHWAY SPEEDS ON STEADY CRUISE OR DECEL. *TT
BC06789610251997-04-24. Service bulletin. POWER TRAIN:MANUAL TRANSMISSION. INFORMATION ON AODE/4R7W TRANSMISSION MAIN CONTROL & CASE REPLACEMENT. *TT
2123951996-04-25. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION; POWER TRAIN:DRIVELINE:DRIVESHAFT. BULLETIN APPLIES TO VEHICLES EQUIPPED W/ A 31TH TRANSAXLE. TRANSAXLE SLIPS MOMENTARILY (ENGINE RPM INCREASES/FLARES) DURING LIGHT THROTTLE 2-3 UPSHIFTS.
952121996-04-25. Service bulletin. SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP. THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. IF PETROLEUM-BASED GREASE IS USED TO LUBRICATE ANY PART OF THE DISC BRAKE SYSTEM, IT COULD CAUSE RUBBER PARTS TO SWELL IF LUBRICANT CONTACTS THE RUBBER MATERIAL.
9519141996-04-25. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. SOME E4OD TRANSMISSIONS W/ BUILD DATES 5B03 (FEB. 3, 1995) AND 5E31 (MAY 31, 1995) MAY HAVE A VALVE, IN THE PUMP, THAT RESTRICTS FLUID FLOW (FIG 1). THIS VALVE MAY BECOME STUCK IN THE VALVE BORE AND RESTRICT LUBRICATION. SYMPTOMS MAY INCLUDE HEAT DISTRESS ON THE OVERDRIVE PLANETARY GEARSET , COAST CLUTCH CYLINDER BUSHING AND/OR OVERDRIVE CYLINDER BUSHING.
BC01319601021996-04-25. Service bulletin. POWER TRAIN:AXLE ASSEMBLY. 4X4 FRONT AXLES MUST USE HYPOID 4X4 GEAR OIL P/N F1TZ-19580-A & HIGH TEMP 4X4 FRONT AXLE & WHEEL BEARING GREASE WHEN SERVICING. IT IS NOT RECOMMENDED TO USE HEAVIER WEIGHT LUBES IN THESE FRONT AXLES.
9517141996-04-25. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE. ENGINE- 'KNOCKING' NOISE - WHEN OPERATING ENGINE AT 200-2300 RPM - FD1460 ENGINE
9517131996-04-25. Service bulletin. ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR. GENERATOR-MOTORCRAFT 95AMP-FRONT BEARING CONCERN-FD1060/1460 ENGINES- VEHICLES BUILT BEFORE 7/3/95. *SD
9516161996-04-25. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER. AIR CONDITIONING-LACK OF COOLING AT IDLE-A/C SYSTEM SHUTS OFF DUE TO HIGH SYSTEM PRESSURES-7.3L DI TURBO F-SERIES BUILT BEFORE 4/14/95 AND 7.3L DI TURBO ECONOLINES BUILT BEFORE 4/21/95. *SD
BC14329950901996-04-25. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. ENGINE MOAN AT APPROXIMATELY 1900 RPM DUE TO THE FLYWHEEL DAMPENING OF ENGINE PULSES. *TW
BC43699509061996-04-25. Service bulletin. SUSPENSION:FRONT:SHOCK ABSORBER. 4X4 TRUCKS PRODUCED AT MICHIGAN TRUCK PLANT BETWEEN MAY 15 AND JUNE 6, 1995 MAY EXHIBIT A FRONT SUSPENSION CLUNK OR RATTLE. *TW
BC13519509061996-04-25. Service bulletin. FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS. ROUGH IDLE OR MISS MAY BE DUE TO LOOSE INJECTOR HOLD DOWN BOLT. *TW
BC42251995-11-01. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE; ENGINE AND ENGINE COOLING:ENGINE; POWER TRAIN:AUTOMATIC TRANSMISSION; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM; ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD; VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM; STRUCTURE:BODY:BUMPERS; EQUIPMENT:APPLIANCE:AIR CONDITIONER; ENGINE AND ENGINE COOLING:COOLING SYSTEM; FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM. UNKNOWN
9511121995-11-01. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. REVISED DESIGN TRANSMISSION REAR CASE BUSHING. *TW
BC43369507051995-11-01. Service bulletin. SUSPENSION:FRONT. FRONT SUSPENSION CLUNK. *TW
9510151995-11-01. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM. HYDROMOUNTED CAB - EVAPORATIVE EMISSION LINES RUBBING ON THE FENDER. *TW
9510131995-11-01. Service bulletin. SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER. BRAKES - HYDRAULIC - HYDROMAX BRAKE RESEREVOIR MOUNTING BRACKET SEPARATION. *TW
9510101995-11-01. Service bulletin. VEHICLE SPEED CONTROL. LACK OF ACCELERATOR CONTROL WHEN MOVING OFF THE IDLE POSITION. *TW

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.