WenmarOpen by Wenmar Pro

Service bulletins for the 1997 Ford Expedition

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

373 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

Only bulletins with component: Suspension are shown. Show all

Bulletins, newest first
0506182005-10-07. Service bulletin. SUSPENSION:REAR. REAR AXLE NOISE REPAIR. *SC
04542004-08-04. Service bulletin. SUSPENSION:REAR:SPRINGS:AIR SUSPENSION SYSTEM. AIR SUSPENSION COMPRESSOR NOISE. *TT
03922003-09-17. Service bulletin. SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM. REPEAT AIR SUSPENSION COMPRESSOR DRIER FAILURES. *TT
0307092003-09-10. Service bulletin. SUSPENSION. REPEAT AIR SUSPENSION COMPRESSOR DRIER FAILURES. *TT
156922002-11-07. Service bulletin. SUSPENSION. SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT
160152002-11-06. Service bulletin. SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM. SOME VEHICLES WITH AIR SUSPENSION MAY EXHIBIT AN INITIAL OR REPEAT COMPRESSOR DRYER FAILURE. *TT
156512002-04-19. Service bulletin. SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM. SOME VEHICLES EQUIPPED WITH AIR SUSPENSION MAY EXHIBIT AN AIR LEAK AND/OR OVERNIGHT BLEED DOWN OF THE AIR SUSPENSION. *TT
153622002-04-16. Service bulletin. SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM. SOME VEHICLES MAY EXHIBIT AIR SUSPENSION MALFUNCTION. *TT
155282002-04-12. Service bulletin. SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM. SUBJECT REGARDING AIR SUSPENSION COMPRESSOR QUALITY. *YD
143592001-04-18. Service bulletin. SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM. SUBJECT PERTAINING TO AIR SUSPENSION LEAKS. *JB
9815152000-04-04. Service bulletin. SUSPENSION:FRONT:STABILIZER BAR. A CLUNKING NOISE HEARD FROM FRONT ENDCAUSED BY FRONT STABILIZER BAR CONTACTING THE FRAME. *AK
991571999-12-01. Service bulletin. SUSPENSION. SOME VEHICLES MAY EXHIBIT VIBRATION, SHIMMY AND BODY BOOM AT SPEEDS ABOVE 72 KM/H (45 MPH). *TT
982541999-03-01. Service bulletin. SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM. SOME VEHICLES EQUIPPED WITH AIR SUSPENSION MAY EXHIBIT AN INTERMITTENT CHECK SUSPENSION LAMP ON AND DIAGNOSTIC TROUBLE CODE (DTC) C1770 AND/OR C1845 ILLUMINATED. *YC
9827411999-02-25. Service bulletin. SUSPENSION:FRONT. SOME VEHICLES MAY EXHIBIT A LOW SPEED ( UNDER 35MPH ) CLICKING NOISE. THIS MAY BE CAUSED BY A CAGE NUT ROCKING ON THE COTTOR PIN FOR FRONT AXLE HALF SHAFT SPINDLE. *AK
9803101999-02-23. Service bulletin. SUSPENSION. EXPERIENCING VIBRATION AT CRUISE OVER 50 MPH. *YC
BC1059697051997-09-18. Service bulletin. SUSPENSION:REAR:SPRINGS:COIL SPRINGS. VEHICLES BUILT BEFORE 4/11/97 MAY EXPERIENCE A RATTLE OR CLUNK. *TW
BC22259705011997-09-12. Service bulletin. SUSPENSION:REAR:SPRINGS:COIL SPRINGS. RATTLE OR CLUNK NOISE IN REAR OF VEHICLE CAUSED BY THE BUSHING FALLING OUT OF THE SWAY BAR LINK. *TW
977131997-07-17. Service bulletin. SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM. NOISE- "BUZZING"- UNDERHOOD WHEN AIR SUSPENSION IS IN OPERATION. *JD
BC0318A970201997-06-27. Service bulletin. SUSPENSION:FRONT. FRONT DRIVE AXLE FLUID LEAK. *TW
BC10179972301997-06-27. Service bulletin. SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM. ALL AIR SUSPNESION EXPEDTIONS ARE SHIPPED WITH THE AIR SUSPENSION SWITCH IN THE OFF POSITION. *JD
BC10065972301997-06-27. Service bulletin. SUSPENSION:FRONT. IF 4X4 FRONT AXLE IS LEAKING THROUGH THE VENT TUBE, ORDER THE NEW FRONT AXLE TUBE ASSEMBLY FROM THE NATIONAL PARTS DEPOT. *JD
BC35139723011997-06-27. Service bulletin. SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM. AIR SUSPENSION VEHICLES ARE SHIPPED WITH THE AIR SUSPENSION SWITCH IN THE OFF POSITION. *JD
BC03189723011997-06-27. Service bulletin. SUSPENSION. FRONT DRIVE AXLE FLUID LEAK. *JD
BC03189702011997-06-27. Service bulletin. SUSPENSION. FRONT DRIVE AXLE FLUID LEAK. *JD
BC07439610181997-04-24. Service bulletin. SUSPENSION:REAR:SPRINGS:AIR SUSPENSION SYSTEM. PROCEDURE WHEN AIR SUSPENSION LIGHT IS ON. *TT

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.