WenmarOpen by Wenmar Pro

Service bulletins for the 1994 Ford Bronco

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

94 on file from NHTSA, as of 2026-10-19.

By type

By component

Bulletins, newest first
BC23619705011997-09-12. Service bulletin. UNKNOWN OR OTHER. AUTHORIZED WARRANTY PART REPLACEMENT OF BRAKE PADS TO CORRECT EXCESSIVE BRAKE NOISE. *TW
BC23019705011997-09-12. Service bulletin. POWER TRAIN:MANUAL TRANSMISSION. NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL. *TW
97681997-07-17. Service bulletin. UNKNOWN OR OTHER. FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
975111997-07-17. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
97781997-07-17. Service bulletin. EXTERIOR LIGHTING:HEADLIGHTS. HEADLAMP- HEADLAMP HOUSING MELTS- AMBULANCE AND EMERGENCY VEHICLES ONLY. *JD
BC32879702061997-07-17. Service bulletin. POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE). THE CLUTCH MAY BE HARD TO DEPRESS DUE TO DUST/CONTAMINATION ENTERING THE SLAVE CYLINDER. *TW
97471997-06-27. Service bulletin. STRUCTURE. FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD
973101997-06-27. Service bulletin. SUSPENSION:FRONT:SPRINGS:LEAF SPRING ASSEMBLY:HANGER,BRACKET. NOISE- "POPPING/CREAKING"- FRONT FRAME OR SUSPENSION BRACKETS- FRAME- "POPPING/CREAKING"- FASTENER REPLACEMENT. *JD
BC03269723011997-06-27. Service bulletin. AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE. AIR BAG LAMP FLASH-OUT CODE 33 ON VEHICLES EQUIPED WITH A PASSENGER SIDE AIR BAG. *JD
9626121997-06-17. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER. TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
962261997-06-17. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER. AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW
962251997-06-17. Service bulletin. FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM. MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW
962221997-06-17. Service bulletin. SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS. BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
962211997-06-17. Service bulletin. VISIBILITY:WINDSHIELD. WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
962491997-06-17. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER. TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
BC00579611011997-06-17. Service bulletin. AIR BAGS:FRONTAL. DIAGNOSING AN AIR BAG LAMP FLASH-OUT CODE 33 (PASSENGER SIDE AIR BAG HIGH RESISTANCE OR OPEN)
BC03269611291997-06-17. Service bulletin. AIR BAGS:FRONTAL. WHEN DIAGNOSING AN AIR BAG LAMP FLASH-OUT CODE 33 (PASSENGER SIDE AIR BAG HIGH RESISTANCE OR OPEN) ON A 1994-1996 F150 OR BRONCO THAT IS NOT EQUIPPED WITH A PASSENGER SIDE AIR BAG, CHECK FOR PROPER GROUND FROM PIN 7, CIRCUIT 629, AT THE AIR BAG DIAGNOSTIC MONITOR CONNECTOR C218, TO THE NEGATIVE BATTERY POST. *TW
952121996-04-25. Service bulletin. SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP. THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. IF PETROLEUM-BASED GREASE IS USED TO LUBRICATE ANY PART OF THE DISC BRAKE SYSTEM, IT COULD CAUSE RUBBER PARTS TO SWELL IF LUBRICANT CONTACTS THE RUBBER MATERIAL.
BC01319601021996-04-25. Service bulletin. POWER TRAIN:AXLE ASSEMBLY. 4X4 FRONT AXLES MUST USE HYPOID 4X4 GEAR OIL P/N F1TZ-19580-A & HIGH TEMP 4X4 FRONT AXLE & WHEEL BEARING GREASE WHEN SERVICING. IT IS NOT RECOMMENDED TO USE HEAVIER WEIGHT LUBES IN THESE FRONT AXLES.
9515111996-04-25. Service bulletin. ELECTRICAL SYSTEM:IGNITION. HESITATION/STUMBLE - INTERMITTENT - 4.9L, 5.0L, 5.8L AND 7.5L ENGINES. MISS-INTERMITTENT-4.9L, 5.0L, 5.8L AND 7.5L ENGINES. NO START/NO SPARK INTERMITTENT - 4.9L, 5.0L, 5.8L AND 7.5L ENGINES. STALL - INTERMITTENT - 4.9L, 5.0L, 5.8L AND 7.5L ENGINES. *SD
BC29229504011995-11-01. Service bulletin. VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM; ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD; ENGINE AND ENGINE COOLING:ENGINE; ENGINE AND ENGINE COOLING:ENGINE:GASOLINE; ENGINE AND ENGINE COOLING:COOLING SYSTEM; STRUCTURE:BODY:BUMPERS; EQUIPMENT:APPLIANCE:AIR CONDITIONER. UNKNOWN
9511131995-11-01. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. DELAYED FORWARD ENGAGEMENT AND/OR HEAT STAINED FORWARD CLUTCH PLATES AFTER INSTALLING CENTER SUPPORT SERVICE. *TW
9511121995-11-01. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. REVISED DESIGN TRANSMISSION REAR CASE BUSHING. *TW
BC41929504011995-11-01. Service bulletin. STRUCTURE:BODY:BUMPERS. REVISED MOUNTING BOLT TORQUE FOR FRONT BUMPER. *TW
BC43219507051995-11-01. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. VEHICLES EXPERIENCING OCCASIONAL HARSH REVERSE ENGAGEMENT CONCERNS. *TW

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.