Recalls that may apply to the 1996 Ford Aerostar
A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.
By component
| 99V029000 | 1999-02-09. ELECTRICAL SYSTEM:IGNITION:SWITCH. VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES WERE PRODUCED WITH A HIGHER THAN SPECIFIED ELECTRICAL LOAD THROUGH THE ACCESSORY POWER FEED CIRCUIT. THE POTENTIAL FOR CONTACT BETWEEN THE B2 (BATTERY), A2 (ACCESSORY), AND P1 (PROOF) CIRCUITS CAN OCCUR, CREATING A SHORT CIRCUIT, ALLOWING CURRENT TO FLOW THROUGH THE GROUND WIRE. Built 1991-08-12 to 1997-08-22. |
|---|---|
| 97V204000 | 1997-11-13. POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE). VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT. Built 1992-01-31 to 1997-01-20. |
| 96V161000 | 1996-08-29. EQUIPMENT:OTHER:LABELS. THE CERTIFICATION LABELS ON THE INVOLVED VEHICLES HAS INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATIONS. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." Built 1995-12-15 to 1996-03-11. |
| 96V070000 | 1996-04-22. LATCHES/LOCKS/LINKAGES:DOORS:LATCH. WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS." Built 1996-02-01 to 1996-03-01. |
| 2001193 | 2001-07-16. Other. Certain vehicles, from Ontario to Newfoundland, could experience a corrosion related failure of the spare tire winch cable. If the cable breaks while the vehicle is being driven, the spare tire could drop down, potentially creating a roadway obstacle. Correction: Owners are to inspect the cable, and if corrosion or broken wire strands are present the vehicle is to be taken to a dealer for replacement of the winch assembly. Program ends September 30, 2003. |
|---|---|
| 1999032 | 1999-03-02. Electrical. On certain vehicles, a short circuit could occur at the A2 accessory terminal in the ignition switch of these vehicles when the switch is in the "on" position causing overheating and the potential for a vehicle fire. Correction: A jumper harness with a relay will be installed which will re-route and activate all A2 accessories through the relay. |
| 1997207 | 1997-11-20. Powertrain. On certain Aerostar AWD vehicles, extended operation at speeds of over 130 kph may result in structural failure of the transmission/transfer case assembly. This could result in fluid expulsion, driveshaft separation or loss of vehicle drive. Fluid leakage in the presence of an ignition source could cause a vehicle fire and driveshaft separation may lead to loss of vehicle control. Correction: Transfer case extension housing will be replaced and steel driveshaft will be replaced with an aluminum driveshaft. |
| 1997042 | 1997-02-20. Emissions. THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S. 1103 - EXHAUST EMISSIONS. VEHICLES MAY HAVE BEEN BUILT WITH INCORRECT MASS AIRFLOW SENSORS INSTALLED IN THE EMISSIONS CONTROL SYSTEM. WITH THE INCORRECT SENSOR INSTALLED THE AFFECTED VEHICLES MAY EXCEED THE EMISSIONS STANDARD. CORRECTION: MASS AIRFLOW SENSOR WILL BE REPLACED WITH THE CORRECT PART. |
| 1996071 | 1996-05-09. Structure. THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S 206 - DOOR LATCHES, HINGES AND LOCKS. THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1000 POUND TRANSVERSE LOAD AS REQUIRED BY THE STANDARD. CORRECTION: DRIVER DOOR LATCH WILL BE INSPECTED AND, IF NECESSARY, REPLACED. |
A campaign lists a year, a make and a model, and often only some of the vehicles built. A list with nothing on it is not a clearance either. The lookups below check one VIN.
Check one vehicle officially
Contains information licensed under the Open Government Licence – Canada.