Transport Canada recall 1997207
A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.
| Published by | Transport Canada (Canada) |
|---|---|
| Campaign number | 1997207 |
| Manufacturer's number | 97S83 |
| Reported | 1997-11-20 |
| Component | Powertrain |
| Notification type | Safety Mfr |
| Units potentially affected | 22467 |
What is wrong
On certain Aerostar AWD vehicles, extended operation at speeds of over 130 kph may result in structural failure of the transmission/transfer case assembly. This could result in fluid expulsion, driveshaft separation or loss of vehicle drive. Fluid leakage in the presence of an ignition source could cause a vehicle fire and driveshaft separation may lead to loss of vehicle control. Correction: Transfer case extension housing will be replaced and steel driveshaft will be replaced with an aluminum driveshaft.
| 1992 FORD AEROSTAR | |
|---|---|
| 1993 FORD AEROSTAR | |
| 1994 FORD AEROSTAR | |
| 1995 FORD AEROSTAR | |
| 1996 FORD AEROSTAR | |
| 1997 FORD AEROSTAR |
A vehicle with no link is not in this site's catalog, which covers cars, multipurpose vehicles and trucks by model year. The campaign is from data as of 2026-10-19.
Bulletins for the same vehicles and component
| 042107 | 2005-04-28. Service bulletin. GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT |
|---|---|
| 03148 | 2003-10-29. Service bulletin. NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT |
| 0282 | 2002-12-09. Service bulletin. SOME VEHICLES BUILT PRIOR TO 9/15/2001 MAY EXHIBIT LOW LINE PRESSURE READINGS WHILE IN DRIVE, NO 2ND GEAR, NO 3RD GEAR, NO ENGINE BRAKING IN MANUAL 1ST AND SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS. *TT |
| 15887 | 2002-12-04. Service bulletin. SOME VEHICLES MAY EXHIBIT A NO 1-2 UPSHIFT, NO 2-3 UPSHIFT, A NO ENGINE BRAKING CONDITION IN MANUAL 1 OR DIAGNOSTIC TROUBLE CODE P0732 (GEAR 2 INCORRECT RATIO) OR P0733 (GEAR 3 INCORRECT RATIO). *TT |
| 02138 | 2002-11-04. Service bulletin. LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 SET ON VEHICLES BUILT BEFORE 12/1/2001. *TT |
| 01181 | 2001-11-30. Service bulletin. BRAKE SHIFT INTERLOCK.*JB |
| 002310 | 2001-03-05. Service bulletin. SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT |
| 99152 | 2001-01-05. Service bulletin. INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT |
| 96726 | 2000-06-22. Service bulletin. WHEN REPLACING AN INTERNAL WIRING HARNESS ON 4R44E/4R55E TRANSMISSIONS BUILT BEFORE 11/30/95 WITH A NEW HARNESS, THE FLUID PAN MUST BE REPLACED ALSO. FAILURE TO CHANGE OVER OR CONVERT THE FLUID PAN MAY RESULT IN A TRANSMISSION FLUID LEAK OR A DAMAGED WIRING HARNESS. *TT |
| 0015 | 2000-06-06. Service bulletin. INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS |
A bulletin is the manufacturer's note to its dealers. It is not part of this recall.
Check one vehicle officially
Contains information licensed under the Open Government Licence – Canada.