WenmarOpen by Wenmar Pro

Service bulletins for the 2024 BMW i4

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

48 on file from NHTSA, as of 2026-10-19.

By type

By component

Only bulletins with type: Service bulletin are shown. Show all

Bulletins, newest first
B6406262026-07-31. Service bulletin. STRUCTURE:BODY. A “whistling” noise is heard from the centerconsole/instrument panel when using theheating and air conditioning (HVAC) system. Heard with the blower motor set tospeed 2 or above Noise goes away on high blower speed Noise is loudest with the vents on theback of the center console in the closedposition Noise is heard the most near thecharging tray (where center consolemeets instrument panel)
B6106262026-04-27. Service bulletin. ELECTRICAL SYSTEM. Charging sessions cannot be started or they are interrupted while using a Level 2 AC high-power charging station, or with a Level 3 DC charging station. Charging may start normally but can interrupt after some time. Level 2 (240 V) Flex Charger and Wall box may also be affected. The red or white LED is displayed on the high-voltage charging socket; however, no associated fault codes are stored.
B5106262026-04-27. Service bulletin. STRUCTURE:BODY. While driving on rough surfaces, a “tapping” noise can be heard from the tailgate area
B1205232026-03-13. Service bulletin. POWER TRAIN. The customer states there is a Drivetrain Malfunction message displayed in the instrument cluster. In addition, the following fault memory entries are saved in the CCU (Combined Charging Unit) 0317F2 - High-voltage system, insulation fault detected: when switch contactors are closed. 0317F1 - High-voltage system, insulation resistance below warning threshold: when switch contactors are closed. The fault memory entries (isolation faults) can occur both individually and in combination and must be traced back to the eDrive motor based on the ISTA test procedure. If ISTA test procedure lists possible cause of fault as; A metal chip is found behind the brush module (between the brush module and the end shield of the electrical machine). Repair required. Refer to service solution no. 20000794435083 in Aftersales Information Research (AIR). Follow information in the Procedure section below.
B1701242026-02-26. Service bulletin. ENGINE. There is coolant leaking from under the car Low heater output Possible Check Control message “Drive, you can continue driving” (ID49) Possible fault codes stored in these BEV vehicles: 224163 – Electric auxiliary heater for the high-voltage battery unit: Undervoltage or internal communication fault 8049AA - Coolant level sensor, expansion tank: Coolant level low or short circuit to ground or line disconnection 80124F – Electric auxiliary heater: Communication in electric auxiliary heater faulty 224F60 - Coolant level sensor, expansion tank: Coolant level low or short circuit to ground or line disconnection 224111 - Cooling system for power electronics: Coolant loss detected 224107 - Cooling system for high-voltage battery unit, component protection: Detection of coolant loss
B6411252026-01-05. Service bulletin. UNKNOWN OR OTHER. Insufficient cooling power in the passenger area. The following faults may be stored: 0380CA - Malfunction or electrical fault of the heat pump circuit expansion valve detected E70C51 - Heat pump circuit changeover valve is not responding E70C44 - Heat pump circuit expansion valve is not responding
B6411252025-11-25. Service bulletin. UNKNOWN OR OTHER. Insufficient cooling power in the passenger area. The following faults may be stored: 0380CA - Malfunction or electrical fault of the heat pump circuit expansion valve detected E70C51 - Heat pump circuit changeover valve is not responding E70C44 - Heat pump circuit expansion valve is not responding
B4105252025-07-02. Service bulletin. ELECTRICAL SYSTEM; STRUCTURE:BODY. While attempting to fuel/charge the vehicle,the fuel/charge door will not open.
B1701242025-04-03. Service bulletin. ENGINE. There is coolant leaking from under the car Low heater output Possible Check Control message “Drive, you can continue driving” (ID49) Possible fault codes stored in these BEV vehicles: 224163 – Electric auxiliary heater for the high-voltage battery unit: Undervoltage or internal communication fault 8049AA - Coolant level sensor, expansion tank: Coolant level low or short circuit to ground or line disconnection 80124F – Electric auxiliary heater: Communication in electric auxiliary heater faulty 224F60 - Coolant level sensor, expansion tank: Coolant level low or short circuit to ground or line disconnection 224111 - Cooling system for power electronics: Coolant loss detected 224107 - Cooling system for high-voltage battery unit, component protection: Detection of coolant loss
B6103252025-03-11. Service bulletin. ELECTRICAL SYSTEM. This is an informational bulletin regarding Plug & Charge function complaint diagnosis. Possible customer complaints: Plug & Charge menu does not appear in the vehicle, function not available Problems with the configuration, for example: Contracts cannot be installed Fault / problems when attempting charging with Plug & Charge Plug & Charge contract disappeared Plug & Charge payment method expired
B6402252025-03-03. Service bulletin. STRUCTURE:BODY. The customer states that when the AC system is on, there is a vibrating noise heard from within theinstrument panel. The noise is intermittent. The noise can be heard better outside the vehicle with the hood open.
B1701242025-02-24. Service bulletin. ENGINE. There is coolant leaking from under the car Low heater output Possible Check Control message “Drive, you can continue driving” (ID49) Possible fault codes stored in these BEV vehicles: 224163 – Electric auxiliary heater for the high-voltage battery unit: Undervoltage or internal communication fault 8049AA - Coolant level sensor, expansion tank: Coolant level low or short circuit to ground or line disconnection 80124F – Electric auxiliary heater: Communication in electric auxiliary heater faulty 224F60 - Coolant level sensor, expansion tank: Coolant level low or short circuit to ground or line disconnection 224111 - Cooling system for power electronics: Coolant loss detected 224107 - Cooling system for high-voltage battery unit, component protection: Detection of coolant loss
B1701242025-02-10. Service bulletin. ENGINE. There is coolant leaking from under the car Low heater output Possible Check Control message “Drive, you can continue driving” (ID49) Possible fault codes stored in these BEV vehicles: 224163 – Electric auxiliary heater for the high-voltage battery unit: Undervoltage or internalcommunication fault 8049AA - Coolant level sensor, expansion tank: Coolant level low or short circuit to ground or linedisconnection 80124F – Electric auxiliary heater: Communication in electric auxiliary heater faulty 224F60 - Coolant level sensor, expansion tank: Coolant level low or short circuit to ground or linedisconnection 224111 - Cooling system for power electronics: Coolant loss detected 224107 - Cooling system for high-voltage battery unit, component protection: Detection of coolantloss
B5118232024-09-01. Service bulletin. STRUCTURE:BODY. A groaning noise is heard from the trunk whendriving on rough roads.
B3301242024-07-25. Service bulletin. POWER TRAIN. The vehicle will no longer move when put into gear. There may also be loud noise coming from the HEAT*(electric drivetrain)/Rear axles. *German acronym for Highly integrated electric drivetrain topology- Hochintegrierte Elektrifizierte Antriebs-Topologie
B6402242024-05-29. Service bulletin. ENGINE. DELIVERY STOP: COOLANT CHANGEOVER VALVE
B6112242024-05-03. Service bulletin. ELECTRICAL SYSTEM. The Combined Charging Unit (CCU) may not have been produced according to BMW specifications. This can lead to an internal coolant leak which can result in a failure of the Combined Charging Unit.Possible faults may include- HV charging interruption No high-voltage readiness when starting up The high-voltage system switching off while driving, causing the vehicle to coast slowly to a stop
B1701242024-05-03. Service bulletin. ENGINE AND ENGINE COOLING. There is coolant leaking from under the car Low heater output Possible Check Control message “Drive, you can continue driving” (ID49) Possible fault codes stored in these BEV vehicles: 224163 – Electric auxiliary heater for the high-voltage battery unit: Undervoltage or internal communication fault 8049AA - Coolant level sensor, expansion tank: Coolant level low or short circuit to ground or line disconnection 80124F – Electric auxiliary heater: Communication in electric auxiliary heater faulty 224F60 - Coolant level sensor, expansion tank: Coolant level low or short circuit to ground or line disconnection 224111 - Cooling system for power electronics: Coolant loss detected 224107 - Cooling system for high-voltage battery unit, component protection: Detection of coolant loss
B6107242024-04-01. Service bulletin. ELECTRICAL SYSTEM. This Informational Bulletin is intended as a guided work through process to address BEV/PHEV charging issues. The step-by-step guide will help walk you through the correct “basic” steps that should be followed when addressing and diagnosing battery electric vehicles (BEV) and plug in hybrid vehicles (PHEV) charging issues.
B6106242024-04-01. Service bulletin. ELECTRICAL SYSTEM. This Informational Bulletin is intended as a guided work-through process to address customer charging complaints. The step-by-step guide will help walk you through the “basic” procedure to test the charger/infrastructure when the vehicle does not charge, either at a: Home charger AC Level 1/Level 2 - Flexible Fast Charger/hard wired Wallbox, or a Public AC Level 2, or DC Level 3 - Fast Charging Station Note: All PHEV and BEV vehicles may be affected.
B6112242024-04-01. Service bulletin. ELECTRICAL SYSTEM. BMW AG has issued a Delivery Stop (effective March 21, 2024) on certain Model Year 2023 - 2024 BMW vehicles that were produced between September 24, 2022, and December 14, 2023.
B6402242024-03-02. Service bulletin. ENGINE AND ENGINE COOLING:COOLING SYSTEM; ELECTRICAL SYSTEM. The coolant changeover valve may develop a coolant leak when the outside temperatures go below 19°F (-7°C). The vehicles operating systems would also need to be at that same low temperature (example: being parked outside, overnight in low temperatures).
B6103242024-03-02. Service bulletin. ELECTRICAL SYSTEM. Gen 5 BEV/PHEV vehicles may set the Combined Charging Unit (CCU) in programming abort due to nocommunication to the HV charge socket electronics.
B1205232024-03-02. Service bulletin. POWER TRAIN. The customer states there is a Drivetrain Malfunction message displayed in the instrument cluster. In addition, the following fault memory entries are saved in the CCU (Combined Charging Unit) 0317F2 - High-voltage system, insulation fault detected: when switch contactors are closed. 0317F1 - High-voltage system, insulation resistance below warning threshold: when switch contactors are closed. The fault memory entries (isolation faults) can occur both individually and in combination and must be traced back to the eDrive motor based on the ISTA test procedure. If ISTA test procedure lists possible cause of fault as; A metal chip is found behind the brush module (between the brush module and the end shield of the electrical machine). Repair required. Refer to service solution no. 20000794435083 in Aftersales Information Research (AIR). Follow information in the Procedure section below.
B6402242024-02-01. Service bulletin. ENGINE AND ENGINE COOLING. The coolant changeover valve may develop a coolant leak when the outside temperatures go below 19°F (-7°C). The vehicles operating systems would also need to be at that same low temperature (example: being parked outside, overnight in low temperatures).

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.