WenmarOpen by Wenmar Pro

Service bulletins for the 2022 BMW i4

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

94 on file from NHTSA, as of 2026-10-19.

By type

By component

Only bulletins with component: Electrical system are shown. Show all

Bulletins, newest first
B6409252026-01-05. Service campaign. ELECTRICAL SYSTEM. A faulty electric auxiliary heater may have been installed in the certain vehicles. This could result in thefailure of the electric auxiliary heater, utilized for the vehicle interior.
B1214252025-11-25. Service campaign. ELECTRICAL SYSTEM; POWER TRAIN. RSU availability. BMW AG is conducting a Service Action on certain Model Year 2025 - 2026 BMW vehicles that were produced between March 17, 2021 – November 6, 2025. In certain driving situations there can be a loss of traction or wheel slip followed by a throttle or torque requirement that can potentially damage the axle shafts. Damage of the drive shaft can cause it to break.
B6409252025-09-03. Service campaign. ELECTRICAL SYSTEM. A faulty electric auxiliary heater may have been installed in the certain vehicles. This could result in thefailure of the electric auxiliary heater, utilized for the vehicle interior.
B1205232024-12-31. Service bulletin. ELECTRICAL SYSTEM. The customer states there is a Drivetrain Malfunction message displayed in the instrument cluster. In addition, the following fault memory entries are saved in the CCU (Combined Charging Unit) 0317F2 - High-voltage system, insulation fault detected: when switch contactors are closed. 0317F1 - High-voltage system, insulation resistance below warning threshold: when switch contactors are closed. The fault memory entries (isolation faults) can occur both individually and in combination and must be traced back to the eDrive motor based on the ISTA test procedure. If ISTA test procedure lists possible cause of fault as; A metal chip is found behind the brush module (between the brush module and the end shield of the electrical machine). Repair required. Refer to service solution no. 20000794435083 in Aftersales Information Research (AIR). Follow information in the Procedure section below.
B6112242024-05-03. Service bulletin. ELECTRICAL SYSTEM. The Combined Charging Unit (CCU) may not have been produced according to BMW specifications. This can lead to an internal coolant leak which can result in a failure of the Combined Charging Unit.Possible faults may include- HV charging interruption No high-voltage readiness when starting up The high-voltage system switching off while driving, causing the vehicle to coast slowly to a stop
B6107242024-04-01. Service bulletin. ELECTRICAL SYSTEM. This Informational Bulletin is intended as a guided work through process to address BEV/PHEV charging issues. The step-by-step guide will help walk you through the correct “basic” steps that should be followed when addressing and diagnosing battery electric vehicles (BEV) and plug in hybrid vehicles (PHEV) charging issues.
B6106242024-04-01. Service bulletin. ELECTRICAL SYSTEM. This Informational Bulletin is intended as a guided work-through process to address customer charging complaints. The step-by-step guide will help walk you through the “basic” procedure to test the charger/infrastructure when the vehicle does not charge, either at a: Home charger AC Level 1/Level 2 - Flexible Fast Charger/hard wired Wallbox, or a Public AC Level 2, or DC Level 3 - Fast Charging Station Note: All PHEV and BEV vehicles may be affected.
B6103242024-03-02. Service bulletin. ELECTRICAL SYSTEM. Gen 5 BEV/PHEV vehicles may set the Combined Charging Unit (CCU) in programming abort due to nocommunication to the HV charge socket electronics.
B6124222024-02-01. Service bulletin. ELECTRICAL SYSTEM. The Combined Charging Unit (CCU) may be affected by a manufacturing defect.
B6113052024-02-01. Service bulletin. ELECTRICAL SYSTEM. The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle “discharged battery” complaints.
B6125232023-11-01. Service bulletin. ELECTRICAL SYSTEM. The purpose of this Service Bulletin (SIB) is informational regarding DC (direct current) charging complaints on Gen 5 Battery Electric Vehicles (BEV). It serves as a supporting argument and is intended to help distinguish between a standard designed function or component operation from an actual system fault in a DC charging customer complaint (i.e., “DC Not charging or “DC charging too slow”. Helpful “Tips and Tricks” have been included on each topic within the document that can be used as reference to aid in the diagnosis or in understanding the system. The situation involves several possible causes: 1. Limitation of charging power by the charging station or charging app configuration. 2. Decreasing charging power at a very high state of charge (SoC). 3. Too frequent DC charging attempts within a short period of time. 4. The high-voltage battery is not at the ideal temperature. 5. Ageing of the high-voltage battery.
B6123232023-11-01. Service bulletin. ELECTRICAL SYSTEM. BMW AG has issued a Service Action on certain Model Year 2022 BMW i4 Gran Coupe vehicles that wereproduced between August 10, 2022 – September 2, 2022.
B6120232023-09-25. Service bulletin. ELECTRICAL SYSTEM; POWER TRAIN. ?The customer states there is a Drivetrain Malfunction message displayed in the instrument cluster, and in some cases the vehicle will not go into drive readiness.
B6407232023-09-18. Service bulletin. ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS. ?BMW AG has issued a Delivery Stop (effective June 29, 2023) on certain Model Year 2023 BMW i4 vehicles that were produced between April 19, 2023, and April 24, 2023. Contaminants were found on the printed circuit board of the electric A/C compressor (EKK).
B6308212023-07-24. Service bulletin. EXTERIOR LIGHTING; ELECTRICAL SYSTEM. Headlight check control (CC) message 128 "High beam headlight failure" is displayed. The following fault codes are stored during a vehicle test: 80419A - Left high-beam headlight: Short circuit and/or 8041A5 - light outputs: Number of permitted short circuit cycles exceeded
B6101232023-06-26. Service bulletin. ELECTRICAL SYSTEM. Due to a software error, the vehicle sporadically does not achieve sleep mode. As a result, the 12-volt battery becomes discharged and may cause a no-start condition.
SIB6608232023-05-15. Service bulletin. ELECTRICAL SYSTEM:ADAS:HUD:CAMERA/SENSOR; ELECTRICAL SYSTEM:ADAS:DRIVER MONITORING:CAMERA/SENSOR. Issues with the various functions of the camera-based driver assistance systems (KAFAS system) can possibly lead to following customer complaints: KAFAS camera system deactivates itself, due to system restrictions that are not clear to the customer KAFAS camera system cannot be activated due to system restrictions that are not clear to the customer Road signs are sporadically not detected.
B6201232023-05-01. Service bulletin. ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL. Customers may complain about a loss of displayed estimated electric driving range in the instrument cluster (KOMBI) after programming to I-level S18A-22-07-5XX.
B6109232023-05-01. Service bulletin. ELECTRICAL SYSTEM. The gear selector switch (GWS) consists of the control electronics circuit and the selector lever. The sensors for recording the gearshift lever position and for inhibiting inadvertent gearshifts are integrated in the control electronics.
B6101232023-05-01. Service bulletin. ELECTRICAL SYSTEM. Due to a software error, the vehicle sporadically does not achieve sleep mode. As a result, the 12-volt battery becomes discharged and may cause a no-start condition.
B6520212023-03-20. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM. BMW AG has issued a Delivery Stop (effective October 25, 2021) on certain Model Year 2022 BMW vehicles that were produced after October 25, 2021. Due to supply chain limitations, certain vehicles were produced without a CID with touch function and and without Reversing Assistant.
B6504222023-03-20. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT. Due to component-related supply issues, the central information displays (CID) in some of the Model Year 2022 vehicles listed above were produced without the integrated touch screen function.
B6101202023-03-20. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT:ELECTRICAL:WIRELESS CHARGER/CRADLE. Customer is unable to power up or charge accessories through a plug adapter inserted in the front 12-volt power socket plug. Alternatively, it will only operate when constant downward hand pressure is maintained.
B1205222023-03-20. Service bulletin. POWER TRAIN; ELECTRICAL SYSTEM. A bearing in the front electric drive unit could fail due to a manufacturing defect, resulting in a noise while driving.
B1205222023-01-30. Service bulletin. ELECTRICAL SYSTEM. BMW AG has issued a Delovery Stop (effective December 1, 2022) on certain Model Year 2023 BMW i4 and i7 vehicles that were produced between October 5, 2022 and November 10, 2022. Due to a supplier production issue, it may cause the electric drive unit to fail.

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.