WenmarOpen by Wenmar Pro

Service bulletin 25KWA

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

The communication, as NHTSA indexes it (as of 2026-10-19)
TypeService bulletin
NHTSA id11013799
Published by NHTSA2025-02-05
Manufacturer's number25KWA
Manufacturer's date2025-01-29
Campaign id or software version25KWA
NHTSA componentVEHICLE SPEED CONTROL; ELECTRICAL SYSTEM; ENGINE

NHTSA's summary

Safety Recall – Interim Notification Certain vehicles may have an oversized magnet carrier in the throttle pedal assembly. The magnet carrier acts as the pivot for the throttle pedal. An oversized magnet carrier may cause the throttle pedal to stick. If the throttle pedal fails to return to idle, or sticks, it may increase the risk of a crash. Drivers may feel sticking or that the pedal doesn’t return to idle once released. Pressing the service brake will overcome a stuck throttle pedal and allow the vehicle to stop. This bulletin will be updated when parts and procedures are available.

The document

The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.

Components

Electrical system, Engine, Throttle and cruise control

Vehicles listed
KENWORTH T1802023, 2024
KENWORTH T2802023, 2024
KENWORTH T3802023, 2024
KENWORTH T4802023, 2024

Listing a model year does not mean every vehicle of it is concerned: the document says which.

Recalls for the same vehicles and component
25V0410002025-01-29. EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH; ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL; EXTERIOR LIGHTING:LIGHTING CONTROL MODULE:SOFTWARE
25V0140002025-01-16. VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
24V9150002024-12-09. ELECTRICAL SYSTEM:SOFTWARE; SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
20224702022-08-18. Engine
22V6310002022-08-17. ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.

Other bulletins for the same vehicles and component
P0012026-09-29. Service bulletin. "Kenworth: Dealers should check the chassis list and SIR weekly for VIN changes. 2 chassis added to the chassis list. Peterbilt: Dealers should check the chassis list and SIR weekly for VIN changes. 10 chassis added to the chassis list."
43-0802026-06-17. Service bulletin. "KW: A new recommended repair has been added to verify the software level and close the campaign in SIR.The repair procedure has been updated with additional note boxes for clear instructions. PB: The repair procedure has been updated with additional note boxes for clear instructions."
R26012026-06-04. Service bulletin. Updated primary and/or secondary chassis modules for certain pre-production Kenworth chassis are now available for installation.
02-1772026-06-03. Service bulletin. Troubleshooting procedures for 2.1m cab power windows are now available.
45-0692026-03-05. Service bulletin. Cummins TSB 210203 has been updated to remove the PACCAR suction side fuel filter part number from Table 1 as the filter is no longer compatible.
24PBE_KWE2026-03-05. Service bulletin. The Parts section has been updated to clarify that freight charges for safety recall orders should not be passed on to the end customer.
24KWE / 24PBE2026-02-05. Service bulletin. The right-hand shift stalk may have an improper wire harness terminal crimp within the wire harness connector. Loss of communication between the right-hand shift stalk and the vehicle may result in the vehicle being disabled after it comes to a stop, thereby increasing the risk of crash or injury. A warning will appear on the dash display when communication is lost, including transmission or engine warnings, “!” next to DNR/DNRP indicator, “-“ in the DNR/DNRP indicator, and/or chimes, depending upon whether you are operating a diesel/gas or battery electric vehicle.
24PBE_24KWE2026-02-05. Warranty extension. 24PBE_24KWE RH Shift Stalk Update Warranty section has been updated with revised verbiage for picture requirements.
24PBE/KWE2026-01-06. Warranty extension. The right-hand shift stalk may have an improper wire harness terminal crimp within the wire harness connector. Loss of communication between the right-hand shift stalk and the vehicle may result in the vehicle being disabled after it comes to a stop, thereby increasing the risk of crash or injury. A warning will appear on the dash display when communication is lost, including transmission or engine warnings, “!” next to DNR/DNRP indicator, “-“ in the DNR/DNRP indicator, and/or chimes, depending upon whether you are operating a diesel/gas or battery electric vehicle.
25KWB/25PBB2026-01-06. Service bulletin. A new Recommended Repair has been added. It must be used if safety recall 25PACF is performed prior to or at the same time as this repair since the 25PACF remedy also satisfies this safety recall.