Service bulletins for the 2023 Kenworth T280
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
31 on file from NHTSA, as of 2026-10-19.
| 24PBE_24KWE | 2026-02-05. POWER TRAIN; ELECTRICAL SYSTEM. 24PBE_24KWE RH Shift Stalk Update Warranty section has been updated with revised verbiage for picture requirements. |
|---|---|
| 24PBE/KWE | 2026-01-06. POWER TRAIN; ELECTRICAL SYSTEM. The right-hand shift stalk may have an improper wire harness terminal crimp within the wire harness connector. Loss of communication between the right-hand shift stalk and the vehicle may result in the vehicle being disabled after it comes to a stop, thereby increasing the risk of crash or injury. A warning will appear on the dash display when communication is lost, including transmission or engine warnings, “!” next to DNR/DNRP indicator, “-“ in the DNR/DNRP indicator, and/or chimes, depending upon whether you are operating a diesel/gas or battery electric vehicle. |
A warranty extension may pay for a repair after the basic warranty has ended. Read the document for which vehicles and which repair it covers.
By type
By component
| 42-070 | 2026-10-17. Service bulletin. UNKNOWN OR OTHER. Due to supplier constraints, an authorized aftermarket surge tank has been made available. |
|---|---|
| P001 | 2026-09-29. Service bulletin. ENGINE. "Kenworth: Dealers should check the chassis list and SIR weekly for VIN changes. 2 chassis added to the chassis list. Peterbilt: Dealers should check the chassis list and SIR weekly for VIN changes. 10 chassis added to the chassis list." |
| 24KWL/PBL | 2026-08-20. Service bulletin. FORWARD COLLISION AVOIDANCE: WARNINGS. The verbiage in the Introduction section has been updated. |
| 43-080 | 2026-06-17. Service bulletin. ELECTRICAL SYSTEM. "KW: A new recommended repair has been added to verify the software level and close the campaign in SIR.The repair procedure has been updated with additional note boxes for clear instructions. PB: The repair procedure has been updated with additional note boxes for clear instructions." |
| 02-177 | 2026-06-03. Service bulletin. ELECTRICAL SYSTEM. Troubleshooting procedures for 2.1m cab power windows are now available. |
| 14-034 | 2026-05-06. Service bulletin. UNKNOWN OR OTHER. Bogie Crossmember Torque Value Update - Procedure has been updated to correct torque values. |
| 22KWE/PBE | 2026-04-07. Service bulletin. STEERING. Sheppard Recall Order Process Update - The Parts section has been updated with revised steps for opening a TCS365 Order Support – Order Inquiry case. |
| 45-069 | 2026-03-05. Service bulletin. ENGINE. Cummins TSB 210203 has been updated to remove the PACCAR suction side fuel filter part number from Table 1 as the filter is no longer compatible. |
| 24PBE_KWE | 2026-03-05. Service bulletin. ELECTRICAL SYSTEM. The Parts section has been updated to clarify that freight charges for safety recall orders should not be passed on to the end customer. |
| 24KWE / 24PBE | 2026-02-05. Service bulletin. ELECTRICAL SYSTEM. The right-hand shift stalk may have an improper wire harness terminal crimp within the wire harness connector. Loss of communication between the right-hand shift stalk and the vehicle may result in the vehicle being disabled after it comes to a stop, thereby increasing the risk of crash or injury. A warning will appear on the dash display when communication is lost, including transmission or engine warnings, “!” next to DNR/DNRP indicator, “-“ in the DNR/DNRP indicator, and/or chimes, depending upon whether you are operating a diesel/gas or battery electric vehicle. |
| 24PBE_24KWE | 2026-02-05. Warranty extension. POWER TRAIN; ELECTRICAL SYSTEM. 24PBE_24KWE RH Shift Stalk Update Warranty section has been updated with revised verbiage for picture requirements. |
| 25PACF | 2026-01-06. Service bulletin. EXTERIOR LIGHTING. Parts and procedures are now available for all affected chassis equipped with Vehicle Electronic Control Unit (VECU) part number Q21-1157-013-011 / Q21-1157-013-013 / Q21-1157-002-002 / Q21-1157-004-004 / Q21-1157-006-006 / Q21-1157-009-009. See attached Parts Matrix for required parts per chassis. |
| 24KWE/24PBE | 2026-01-06. Emissions. SERVICE BRAKES. The parts section has been updated for clarity. The right-hand shift stalk may have an improper wire harness terminal crimp within the wire harness connector. Loss of communication between the right-hand shift stalk and the vehicle may result in the vehicle being disabled after it comes to a stop, thereby increasing the risk of crash or injury. A warning will appear on the dash display when communication is lost, including transmission or engine warnings, “!” next to DNR/DNRP indicator, “-“ in the DNR/DNRP indicator, and/or chimes, depending upon whether you are operating a diesel/gas or battery electric vehicle. |
| 24PBE/KWE | 2026-01-06. Warranty extension. POWER TRAIN; ELECTRICAL SYSTEM. The right-hand shift stalk may have an improper wire harness terminal crimp within the wire harness connector. Loss of communication between the right-hand shift stalk and the vehicle may result in the vehicle being disabled after it comes to a stop, thereby increasing the risk of crash or injury. A warning will appear on the dash display when communication is lost, including transmission or engine warnings, “!” next to DNR/DNRP indicator, “-“ in the DNR/DNRP indicator, and/or chimes, depending upon whether you are operating a diesel/gas or battery electric vehicle. |
| 43-076 | 2026-01-06. Service bulletin. FUEL/PROPULSION SYSTEM. Certain vehicle model years 2020-2025 K270, K370, T270, T280, T370, T380, T480, T680, T880, W900 chassis have updated Greenhouse Gas (GHG) labels available for installation. |
| 25KWB/25PBB | 2026-01-06. Service bulletin. EXTERIOR LIGHTING; ELECTRICAL SYSTEM. A new Recommended Repair has been added. It must be used if safety recall 25PACF is performed prior to or at the same time as this repair since the 25PACF remedy also satisfies this safety recall. |
| 24KWE | 2025-12-05. Service campaign. ELECTRICAL SYSTEM; POWER TRAIN. The right-hand shift stalk may have an improper wire harness terminal crimp within the wire harness connector. Loss of communication between the right-hand shift stalk and the vehicle may result in the vehicle being disabled after it comes to a stop, thereby increasing the risk of crash or injury. A warning will appear on the dash display when communication is lost, including transmission or engine warnings, “!” next to DNR/DNRP indicator, “-“ in the DNR/DNRP indicator, and/or chimes, depending upon whether you are operating a diesel/gas or battery electric vehicle. |
| 25PACF | 2025-09-03. Service campaign. EXTERIOR LIGHTING. Procedures are now available for Phase 1 chassis equipped with Internal Combustion Engines (ICE) and Vehicle Electronic Control Unit (VECU) part number Q21-1157-013-011 / Q21-1157-013-013. Parts and procedures for Phase 2 chassis will be available at a later date. This bulletin will be updated at that time. Please refer to the condition section for more details. Certain Ethernet Multiplexed Architecture (EMUX) chassis fail to conform to Federal and Canada Motor Vehicle Safety Standards (FMVSS/CMVSS) No. 108. Delayed or unsteady illumination of the vehicle’s stop lamps, reverse lamps, turn signal lamps and inadvertent change in headlamp illumination or lift axle position may" |
| 25KWB | 2025-04-04. Service bulletin. ELECTRICAL SYSTEM; EXTERIOR LIGHTING. Safety Recall Updated software and repair procedures are now available. The Exterior Lighting Switch (ELS) in certain T180/T280/T380/T480 chassis may not function and can be reset only by a key cycle. This issue may result in non-compliance with FMVSS/CMVSS 101 and 108. Affected chassis must have the Vehicle Software updated. |
| 25KWB | 2025-03-04. Other. EXTERIOR LIGHTING; ELECTRICAL SYSTEM. "Safety Recall – Interim Notification The Exterior Lighting Switch (ELS) in certain T180/T280/T380/T480 chassis may not function and can be reset only by a key cycle. This issue may result in non-compliance with FMVSS/CMVSS 101 and 108. This bulletin will be updated when software and programming procedures are available." |
| 25KWA | 2025-02-05. Service bulletin. VEHICLE SPEED CONTROL; ELECTRICAL SYSTEM; ENGINE. Safety Recall – Interim Notification Certain vehicles may have an oversized magnet carrier in the throttle pedal assembly. The magnet carrier acts as the pivot for the throttle pedal. An oversized magnet carrier may cause the throttle pedal to stick. If the throttle pedal fails to return to idle, or sticks, it may increase the risk of a crash. Drivers may feel sticking or that the pedal doesn’t return to idle once released. Pressing the service brake will overcome a stuck throttle pedal and allow the vehicle to stop. This bulletin will be updated when parts and procedures are available. |
| 98-026 | 2024-06-04. Service bulletin. POWER TRAIN. New tools are required to support PACCAR TX-8 / ZF transmissions. Part numbers E0l-1012 (Adapter, Jack TX-8), E0l-1014 (Front Seal Installer), and E0l-1015 (Rear Seal Installer) are currently available to order |
| 24KWE | 2024-04-03. Service bulletin. ELECTRICAL SYSTEM; POWER TRAIN. Safety Recall – INTERIM NOTIFICATION Parts are not currently available for this safety recall. This bulletin will be updated once repair parts are available. The right-hand shift stalk may have an improper wire harness terminal crimp within the wire harness connector. Loss of communication between the right-hand shift stalk and the transmission may result in the vehicle becoming disabled after it comes to a stop thereby increasing the risk of crash or injury. A transmission fault will appear on the dash display if communication is lost. |
| 24KWA | 2024-03-04. Service bulletin. VISIBILITY; BACK OVER PREVENTION. SAFETY RECALL Certain T180/T280/T380/T480 chassis may have cab mirror glass lock rings not fully seated. This could result in loss of mirror glass, reducing rear visibility and increasing the risk of an accident or injury. Missing mirrors cause non-compliance with FMVSS 111 / CMVSS 111. Mirror glass lock rings must be inspected and, if necessary, reseated. |
| 23KWJ | 2024-01-05. Service bulletin. SERVICE BRAKES, AIR. Safety Recall 23KWJ: T280/T380/T480 Delayed Trailer Brake Release T280/T380/T480 Delayed Trailer Brake Release. Safety Recall Certain T280/T380/T480 chassis built with 2.1m Medium Duty End of Frame Trailer Connections and Tractor Protection Valves may not meet the standard trailer brake release timing requirements by 0.5 seconds. A delay in the trailer brake release may create momentary instability to the trailer and increase the risk of a crash. |
The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.