Service bulletin T-SB-0008-22
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 10209005 |
| Published by NHTSA | 2022-03-14 |
| Manufacturer's number | T-SB-0008-22 |
| Manufacturer's date | 2022-02-08 |
| NHTSA component | AIR BAGS; LANE DEPARTURE |
NHTSA's summary
TSB: Some 2020 ? 2021 model year Highlander Hybrid vehicles may exhibit one or more of the following conditions: ?The fuel gauge displays less than full when the fuel nozzle automatically clicks off. ?The total amount of fuel dispensed while refueling is less than expected when the fuel nozzle automatically clicks off. ?The Low Fuel warning light illuminates sooner than expected. Additionally, the distance to empty mileage displayed in the Multi-Information Display (MID) may be less than expected. To address these concerns an updated fuel tank, fuel gauge bracket, and fuel sender gauge assembly were developed. Follow the procedures in this bulletin to address these conditions
The document
The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.
Components
Air bags, Driver assistance
| TOYOTA HIGHLANDER HYBRID | 2020, 2021 (the catalog's model; the bulletin names a series or trim of it) |
|---|
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| 2023684 | 2023-12-20. Airbag |
|---|---|
| 23V865000 | 2023-12-20. AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION |
| 22V239000 | 2022-04-13. ELECTRONIC STABILITY CONTROL (ESC):CONTROL MODULE:SOFTWARE |
| 2020480 | 2020-10-14. Airbag |
| 20V633000 | 2020-10-14. SEATS; AIR BAGS |
A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.
| TSB010421 | 2024-04-01. Service bulletin. TSB: Some 2018 ? 2024 model year Toyota vehicles equipped with an A25A-FKS, A25A-FXS, M20A-FKS, or M20A-FXS engine may exhibit one or more of the following conditions: ?Milky/discolored engine oil. ?An ?Oil Pressure Low? warning message on the Multi-information Display (MID). ?A MIL ON condition with Diagnostic Trouble Codes (DTCs) P05202A (Engine Oil Pressure Sensor/Switch ?A? Signal Stuck in Range) and/or P052477 (Engine Oil Pressure Too Low [Severe]) present. Moisture from blow-by gases condenses and accumulates in the engine oil during short trips in extreme cold weather. When the moisture in the oil freezes, the oil pressure may drop, and the aforementioned warning indicators may display. Follow the procedures in this bulletin to address these conditions. |
|---|---|
| TSB005923 | 2023-10-16. Service bulletin. TSB: Some drivers of 2020 ? 2022 model year Highlander Hybrid vehicles may be sensitive to the momentary transition from regenerative braking to hydraulic braking under certain driving conditions, such as while driving downhill, or turning with light brake pedal application. The brake actuator control module can be updated to improve brake feeling for this condition. Follow the Repair Procedure in this bulletin to address this condition. |
| TSB003220 | 2023-10-16. Service bulletin. TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2023 model year vehicles may be available provided the requests meet the criteria listed in this Service Bulletin. Follow the Procurement Procedure in this bulletin to request a replacement certification label or VIN plate. |
| T-TT-0726-23 | 2023-08-28. Service bulletin. TT: Some 2021 - 2023 Highlander HV, RAV4 HV and Sienna HV vehicles equipped with Rear Motor Generator, MGR (Q610), may duplicate an abnormal noise (Drone, Growl, Humming, and/or other) from the MGR at various vehicle speeds and normal drive conditions. Please contact TAS for diagnostic instructions to aid in resolution of the condition. |
| T-TT-0726-23 | 2023-04-17. Service bulletin. TT: Some 2021 - 2023 Highlander HV, RAV4 HV and Sienna HV vehicles equipped with Rear Motor Generator, MGR (Q610), may duplicate an abnormal noise (Drone, Growl, Humming, and/or other) from the MGR at various vehicle speeds and normal drive conditions. Please contact TAS for diagnostic instructions to aid in resolution of the condition. |
| T-SB-0115-22 Rev | 2023-04-17. Service bulletin. TSB: Some 2019 ? 2022 model year Avalon, 2018 ? 2023 model year Camry, 2017 ? 2022 model year Highlander, and 2017 ? 2020 model year Sienna vehicles equipped with a 2GR-FKS engine may exhibit a knocking noise from the vacuum pump at idle. |
| T-SB-0094-21 Rev | 2022-12-19. Service bulletin. TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this service bulletin is to provide general guidelines and procedures for odor remediation. This service bulletin provides a guide on how to prepare the interior of the vehicle prior to an odor remediation being performed, as well as contact information for an approved vendor who will arrange the remediation, and instructions on how to prepare the interior of the vehicle for reassembly once the remediation has been completed. Refer to all model and model year specific Repair Manuals and the EPA (Environmental Protection Agency) website for the most up-to-date safety and precautionary guidelines. This service bulletin is to provide a general overview and direction for the odor remediation process. |
| TTT063620 | 2022-06-21. Service bulletin. TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions |
| 22TC01 Team Memb | 2022-04-18. Service bulletin. SSC: SPECIAL SERVICE CAMPAIGN 22TC01 Over-the-Air (OTA) pilot program. This pilot program would enable you to complete Special Service Campaign 22TC01 for DCM (Data Communication Module) Reprogramming for Safety Connect, which includes your vehicle. With your active telematics account, you are encouraged to complete this campaign using this Over-the-Air (OTA) update by following these steps: 1) To complete this update, each Team Member will use the Toyota/Lexus App installed on their phone. 2) Within a few days of this E-Mail, we will send a notification to your Toyota/Lexus app to schedule and install the update on your vehicle. 3) Click on either the notification on your lock screen or the tile in the app to review the update and then continue in the App to approve the update. 4) The night after you approve the update, the telematics module will perform the update, and you will receive a confirmation notification through the app. |
| 22TC01 Dealer Le | 2022-03-14. Service bulletin. DL: Due to improper programming of the Data Communication Module (DCM), which provides cellular communication in various situations, including emergencies, the driver and Safety Connect operator may not be able to hear each other?s voices during a Safety Connect call |